2003 FORD MUSTANG Workshop Manual

rims fuel pump service indicator overheating heating language

Load previous 8 pages

Page 777 of 4378

FORD MUSTANG 2003 Workshop Manual 4 N805572-
S36 Air bag module retaining screws (2 reqd)
5 3L518 Steering wheel spoke cover
(2 reqd)
6 — Lock tabs
7 14A664 Clockspring
8 13318 Turn indicator cancel cam
9 3C610 Sn

Page 778 of 4378

FORD MUSTANG 2003 Workshop Manual NOTE:
All fasteners are important because they can affect the performance of vital parts and systems.
Incorrect installation of the fasteners can result in major repair expenses. They must be instal

Page 779 of 4378

FORD MUSTANG 2003 Workshop Manual Klj . 4 ba
42003 Mustang Workshop Manual
17. 11. 2011file:///C:/Ford/2000 - 2004/tsocache/SHEF_4464/S3B~us~en~ ...

Page 780 of 4378

FORD MUSTANG 2003 Workshop Manual GENERAL PROCEDURES
Supplemental Restraint System (SRS) Deactivation and
Reactivation
Deactivation
WARNING: Always wear safety glasses when repairing an air bag supplemental restraint
system (SRS

GENERAL PROCEDURES
Supplemental Restraint System (SRS) Deactivation and
Reactivation
Deactivation
WARNING: Always wear safety glasses when repairing an air bag supplemental restraint
system (SRS) vehicle and when handling an air bag module. This will reduce the risk of injury
in the event of an accidental deployment.
WARNING: After deployment, the air bag surface can contain deposits of sodium
hydroxide, a product of the gas generant combustion that is irritating to the skin. Wash your
hands with soap and water afterwards.
WARNING: Never probe the connectors on the air bag module. Doing so can result in air
bag deployment, which can result in personal injury.
WARNING: Air bag modules with discolored or damaged trim covers must be installed
new, not repainted.
WARNING: The restraint system diagnostic tool is for restraint system service only.
Remove from vehicle prior to road use. Failure to remove could result in injury and possible
violation of vehicle safety standards.
1. WARNING: To avoid accidental deployment and possible personal injury, the
backup power supply must be depleted before repairing or replacing any front or side air
bag supplemental restraint system (SRS) components and before servicing, replacing,
adjusting or striking components near the front or side air bag sensors, such as doors,
instrument panel, console, door latches, strikers, seats and hood latches.
Please refer to the appropriate vehicle shop manual to determine location of the front air
bag sensors.
The side air bag sensors are located at or near the base of the B- pillar.
To deplete the backup power supply energy, disconnect the battery ground cable and
wait at least one minute. Be sure to disconnect auxiliary batteries and power supplies (if equipped). SECTION 211-
04: Steering Column 2003 Mustang Workshop Manual Special Tool(s)
Diagnostic Tool, Restraint
System (2 Req'd)
418-
F088 (105- R0012) Klj . 1 ba
62003 Mustang Workshop Manual
17. 11. 2011file:///C:/Ford/2000 - 2004/tsocache/SHEF_4464/S3B~us~en~ ...

Page 781 of 4378

FORD MUSTANG 2003 Workshop Manual Disconnect the battery ground cable and wait at least one minute. For additional information,
refer to
Section 414 - 01 .
2. Remove the steering column opening lower finish panel. 1. Remove the s

Page 782 of 4378

FORD MUSTANG 2003 Workshop Manual 6. Open the glove compartment, push in on the tabs and open the glove compartment door to its
fullest extent.
7. Remove the right hand A/C register duct. �zRemove the two screws retaining the duct

Page 783 of 4378

FORD MUSTANG 2003 Workshop Manual 10. Connect the battery ground cable. For additional information, refer to
Section 414 - 01 .
11. With the restraint system diagnostic tools installed at all deployable devices, prove out the supp

Page 784 of 4378

FORD MUSTANG 2003 Workshop Manual 4. Install the right hand A/C register duct.
�zConnect the A/C duct at the air plenum.
�z Install the duct at the A/C register and install the two screws.
5. Close the glove compartment.
6. Remove

Load next 8 pages

Page: < prev 1-10 ... 745-752 753-760 761-768 769-776 777-784 785-792 793-800 801-808 809-816 ... 4384 next >

power steering dimensions engine oil capacity transmission remove seats maintenance reset