Page 3025 of 3870
Fig. 87: Removing Adhesive Adhered To Threaded Holes Of Drive Gear By Turning Tap
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
3. Apply 3M
TM
stud locking 8730, 8731 or equivalent to the threaded holes of
the drive
gear.
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3026 of 3870
Fig. 88: Applying Stud Locking Or Equivalent To Threaded Holes Of Drive Gear
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
4. Install the drive gear onto the differential case with the mating marks properly
aligned. Tighten the drive gear attaching bolts to the specified torque in a
diagonal sequence.
Tightening torque: 84 +/- 4 N.m (62 +/- 3 ft-lb)
>>I<< DIFFERENTIAL SIDE BEARING INNER RACE INSTALLATION Use special tool MB990728 to press-fit the differential side bearing inner races into
the differential case.
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3027 of 3870
Fig. 89: Installing Differential Side Bearing Inner Race
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
>>J<< DIFFERENTIAL SIDE BEARING NUT INSTALLATION/SNAP RING & FINAL DRIVE GEAR BACKLASH
ADJUSTMENT Adjust the final drive gear backlash by the following procedure:
1. Using special tools MB991367 and MB991385, temporarily tighten the side
bearin
g nut to
just before
preloadin
g of the side bearin
g.
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3028 of 3870
Fig. 90: Tightening Side Bearing Nut
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
2. Measure the final drive gear backlash at four points or more on the
circumference of the drive gear.
Standard value: 0.11 - 0.16 mm (0.004 - 0.006 inch)
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3029 of 3870
Fig. 91: Measuring Final Drive Gear Backlash
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
3. Using special tools MB991367, MB991385, adjust the backlash to standard
value by moving the side bearing nut as shown.
NOTE: First loosen the side bearing nut then tighten the side
bearing nut the same amount as when it was loosened.
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3030 of 3870
Fig. 92: Adjusting Backlash To Standard Value By Moving Side Bearing Nut
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
4. Using special tools MB991367 and MB991385, apply the preload, turn down
both right and left side bearing nuts on half the distance between centers of two
neighboring holes.
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3031 of 3870
Fig. 93: Using Special Tools And Apply Preload
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
5. Fit the sna
p rin
g at either
position shown to lock the side bearin
g nut.
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor
Page 3032 of 3870
Fig. 94: Fitting Snap Ring At Either Position
Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
6. Check the final drive gear tooth contact. If poor contact is evident, make
adjustment. (Refer to DISASSEMBLY
).
7. Measure the drive gear runout.
Limit: 0.05 mm (0.002 inch)
2004 Mitsubishi Endeavor LS
2004 SUSPENSION Rear Axle < AWD > - Endeavor