2005 TOYOTA AVENSIS Service Repair Manual

wiring dashboard MPG jump cable change time fuel pump

Page 801 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual 050XD±10
F45085
Combination Meter
(ABS Warning Light)
(Brake Warning Light)
DLC3Left Front Speed Sensor Brake Actuator
(Include Skid Control ECU)
Skid Control Sensor
Speed Sensor Rotor
Parking Brak

Page 802 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual 050XB±14
05±704
±
DIAGNOSTICS ABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Using SST 09843±18040, connect the terminal Tc and CG of the DLC3.
If malf

050XB±14
05±704
±
DIAGNOSTICS ABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Using SST 09843±18040, connect the terminal Tc and CG of the DLC3.
If malfunction is not found when inspecting parts, inspect the ECU and grou\
nd points for poor contact.
If a malfunction code is displayed during the DTC check, check the circuit\
listed for that code. For de-
tails of each code, refer to the ºSee pageº for respective ºDTC No.º\
in the DTC chart.
When 2 or more DTCs are detected, perform circuit inspection one by one unti\
l the problem is identi-
fied.
\f

\b\f
C0200/31 (05±709)Right front wheel speed sensor signal malfunction Right front speed sensor
Right front speed sensor rotor
C0205/32
(05±709)Left front wheel speed sensor signal malfunction Left front speed sensor
Left front speed sensor rotor
C0210/33
(05±713)Right rear wheel speed sensor signal malfunction Right rear speed sensor
Right rear speed sensor rotor
C0215/34
(05±713)Left rear wheel speed sensor signal malfunction Left rear speed sensor
Left rear speed sensor rotor
C0226/21
(05±717)Open or short circuit in ABS actuator solenoid (SFR) circuit SFRR or SFRH circuit
C0236/22
(05±717)Open or short circuit in ABS actuator solenoid (SFL) circuit SFLR or SFLH circuit
C0246/23
(05±717)Open or short circuit in ABS actuator solenoid (SRR) circuit SRRR or SRRH circuit
C0256/24
(05±717)Open or short circuit in ABS actuator solenoid (SRL) circuit SRLR or SRLH circuit
C0273/13
(05±719)Open or short circuit in ABS motor relay circuit ABS motor relay
ABS motor relay circuit
C0278/11
(05±722)Open or short circuit in ABS solenoid relay circuit ABS solenoid relay
ABS solenoid relay circuit
C1237/37
(05±725)Speed sensor rotor is wrong number of teeth on one of the 4
wheels Speed sensor
Sensor rotor
Speed sensor circuit
C1241/41
(05±726)Low battery voltage or abnormally high battery voltage
Battery
Charging system
Power source circuit
C1249/58
(05±730)Open circuit in stop light switch circuit Stop light switch
Stop light switch circuit
C1300/62
(05±733)Malfunction in skid control ECU Battery
Skid control ECU
C1330/35
(05±709)Open circuit in right front speed sensor Right front speed sensor
Right front speed sensor circuit
C1331/36
(05±709)Open circuit in left front speed sensor Left front speed sensor
Left front speed sensor circuit
C1332/38
(05±713)Open circuit in right rear speed sensor Right rear speed sensor
Right rear speed sensor circuit
C1333/39
(05±713)Open circuit in left rear speed sensor Left rear speed sensor
Left rear speed sensor circuit
C1350 / 51
(05±735)Pump motor is locked
Open circuit in pump motor ground Brake actuator pump motor
Always ON
(05±737)Malfunction in ECU
Battery
Charging system
ABS warning light circuit
Power source circuit
Skid control ECU

Page 803 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual ± DIAGNOSTICSABS WITH EBD SYSTEM
05±705
AVENSIS REPAIR MANUAL (RM1018E)
DTC of speed sensor check function:
Code No.DiagnosisTrouble Area
C1271/71Low output voltage of right front speed sensor
Ri

Page 804 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual 0577T±04
F45095
ABS Warning Ligh t
BRAKE Warning
Light
C52361
Tc
CG
R01346
Norma l Code
Code 1 1 and 21
Code 11
4 sec. 0.25 sec.
2.5 sec.
1.5 sec. 0.25 sec.
2 sec.
0.5 sec . 0.5 sec.
Code 21
ON
O

Page 805 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual BR3890
05±700
± DIAGNOSTICSABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
(3) Clear the DTCs stored in ECU by depressing the
brake pedal 8 or more times within 5 sec.
(4) Check that the ABS w

BR3890
05±700
± DIAGNOSTICSABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
(3) Clear the DTCs stored in ECU by depressing the
brake pedal 8 or more times within 5 sec.
(4) Check that the ABS warning light indicates the nor-
mal code blinking pattern.
(5) Remove the SST from the DLC3.
SST 09843±18040
HINT:
Disconnecting the battery cable during repairs will not erase the
DTCs in the ECU.
(f) With using hand±held tester:
Clear the DTCs.
(1) Turn the ignition switch ON.
(2) Operate the hand±held tester to erase the codes.
HINT:
Please refer to the hand±held tester operator's manual for fur-
ther details.
2. DATA LIST
HINT:
According to the DATA LIST displayed on the Hand±held tester, you can read the value and status of the
switch, sensor, actuator and so on without parts removal. Reading the DATA LIST as a first step of trouble-
shooting is one of the methods to shorten the labor time.
(a) Connect the Hand±held tester to the DLC3.
(b) Turn the ignition switch ON.
(c) From the display on the tester, read the ºDATA LISTº.
ItemMeasurement Item /
Range (Display)Normal ConditionDiagnostic Note
ABS MOT RELAYABS motor relay / ON or
OFFON : Motor relay ON±
SOL RELAYSolenoid relay / ON or
OFFON : Solenoid relay ON±
STOP LIGHT SWStop light switch / ON or
OFF
ON : Brake pedal de-
pressed
OFF : Brake pedal re-
leased
±
PKB SWParking brake switch / ON
or OFFON : Parking brake applied
OFF : Parking brake re-
leased
±
ABS OPERT FRABS operation (FR) / BE-
FORE or OPERATE
BEFORE : No ABS opera-
tion (FR)
OPERATE : During ABS
operation (FR)
±
ABS OPERT FLABS operation (FL) / BE-
FORE or OPERATE
BEFORE : No ABS opera-
tion (FL)
OPERATE : During ABS
operation (FL)
±
ABS OPERT RRABS operation (RR) / BE-
FORE or OPERATE
BEFORE : No ABS opera-
tion (RR)
OPERATE : During ABS
operation (RR)
Speed indicated on
speedometer
ABS OPERT RLABS operation (RL) / BE-
FORE or OPERATE
BEFORE : No ABS opera-
tion (RL)
OPERATE : During ABS
operation (RL)
Speed indicated on
speedometer

Page 806 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual ± DIAGNOSTICSABS WITH EBD SYSTEM
05±701
AVENSIS REPAIR MANUAL (RM1018E)
ItemDiagnostic Note Normal Condition Measurement Item /
Range (Display)
WHEEL SPD FR
Wheel speed sensor (FR)
reading / min.:

Page 807 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual 05±702
± DIAGNOSTICSABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
ItemVehicle Condition / Test DetailsDiagnostic Note
SFRRTurns ABS solenoid (SFRR) ON / OFF
Operation of solenoid
(clicking s

05±702
± DIAGNOSTICSABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
ItemVehicle Condition / Test DetailsDiagnostic Note
SFRRTurns ABS solenoid (SFRR) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SFRHTurns ABS solenoid (SFRH) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SFLRTurns ABS solenoid (SFLR) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SFLHTurns ABS solenoid (SFLH) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SRRRTurns ABS solenoid (SRRR) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SRRHTurns ABS solenoid (SRRH) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SRLRTurns ABS solenoid (SRLR) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SRLHTurns ABS solenoid (SRLH) ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SFRR & SFRHTurns ABS solenoid SFRR & SFRH ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SFLR & SFLHTurns ABS solenoid SFLR & SFLH ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SRRR & SRRHTurns ABS solenoid SRRR & SRRH ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SRLR & SRLHTurns ABS solenoid SRLR & SRLH ON / OFF
Operation of solenoid
(clicking sound) can be
heard
SFRH & SFLHTurns ABS solenoid SFRH & SFLH ON / OFF
Operation of solenoid
(clicking sound) can be
heard
ABS MOT RELAYTurns ABS motor relay ON / OFFOperation of motor can be
heard
ABS WARN LIGHTTurns ABS warning light ON / OFFObserve combination me-
ter
BRAKE WRN LIGHTTurns BRAKE warning light ON / OFFObserve combination me-
ter
4. FREEZE FRAME DATA
(a) The vehicle (sensor) status memorized during ABS operation or at the time of error code detection can
be displayed using the hand±held tester.
(b) Only one record of the freeze frame data is stored and the freeze frame data generated during ABS
operation are constantly updated. Also, the number of the operations of the ignition switch ºONº after
the freeze frame data is stored can be memorized up to 31 and it can be displayed.
HINT:
If the ignition switch ºONº operation exceeds 31 times, º31º appears on the display.
(c) If the diagnosis code malfunction occurs, the freeze frame data at the occurrence of the malfunction
is stored but the ABS actuation data is not stored.

Page 808 of 5135

TOYOTA AVENSIS 2005 Service Repair Manual BR3904
0.13 sec.
ON
OFF 0.13 sec.
±
DIAGNOSTICS ABS WITH EBD SYSTEM
05±703
AVENSIS REPAIR MANUAL (RM1018E)Hand±held tester display
Measurement ItemReference Value*
VEHICLE SPDVehicle speedSpeed i

Load next 8 pages

Page: < prev 1-10 ... 769-776 777-784 785-792 793-800 801-808 809-816 817-824 825-832 833-840 ... 5136 next >

adding oil start stop button engine oil airbag off odometer seat adjustment