2001 CHRYSLER VOYAGER Service Manual

clock setting spark plugs replace automatic transmission fluid clutch lock spare tire

Page 17 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
FUEL GAUGE CHECKSUM FAILURE......................................571
FUEL LEVEL SENDING UNIT INPUT OPEN................................572
FUEL LEVEL SENDING UNIT INPUT S

TABLE OF CONTENTS - Continued
FUEL GAUGE CHECKSUM FAILURE......................................571
FUEL LEVEL SENDING UNIT INPUT OPEN................................572
FUEL LEVEL SENDING UNIT INPUT SHORT...............................574
IOD WAKEUP CLUSTER OUTPUT OPEN..................................576
IOD WAKEUP CLUSTER OUTPUT SHORT.................................578
LEFT TURN SIGNAL INDICATOR OPEN (HIGHLINE).........................580
LEFT TURN SIGNAL INDICATOR OPEN (LOWLINE).........................582
LEFT TURN SIGNAL INDICATOR SHORT (HIGHLINE)........................584
LEFT TURN SIGNAL INDICATOR SHORT (LOWLINE)........................586
LOOPBACK FAILURE...................................................588
NO ABS BUS MESSAGES RECEIVED.....................................589
NO BCM BUS MESSAGES RECEIVED....................................590
NO FCM BUS MESSAGES RECEIVED....................................591
NO ORC BUS MESSAGES RECEIVED....................................592
NO PCM BUS MESSAGES RECEIVED....................................593
NO TCM BUS MESSAGES RECEIVED....................................594
PANEL DIMMING OUTPUT SHORT.......................................595
REAR FOG INDICATOR OUTPUT OPEN...................................600
REAR FOG INDICATOR OUTPUT SHORT..................................602
RIGHT TURN SIGNAL INDICATOR OPEN (HIGHLINE)........................604
RIGHT TURN SIGNAL INDICATOR OPEN (LOWLINE)........................606
RIGHT TURN SIGNAL INDICATOR SHORT (HIGHLINE)......................608
RIGHT TURN SIGNAL INDICATOR SHORT (LOWLINE).......................610
SPEEDOMETER CHECKSUM FAILURE....................................612
TACHOMETER CHECKSUM FAILURE.....................................613
TCM MESSAGE MISMATCH.............................................614
TEMPERATURE GAUGE CHECKSUM FAILURE.............................615
*ANY PCI BUS INDICATOR INOPERATIVE.................................616
INTELLIGENT POWER MODULE
ACCESSORY POWER OUTPUT #1 OPEN.................................617
ACCESSORY POWER OUTPUT #1 SHORTED TO BATTERY..................619
ACCESSORY POWER OUTPUT #2 OPEN.................................621
ACCESSORY POWER OUTPUT #2 SHORTED TO BATTERY..................623
CPA NOT ENGAGED...................................................625
IGN RUN/START INPUT WIRING.........................................627
IGNITION START INPUT WIRING.........................................629
INTERNAL DRIVER FAULT #1............................................631
INTERNAL DRIVER FAULT #2............................................632
INTERNAL DRIVER FAULT #3............................................633
INTERIOR LIGHTING
DOME LAMP OUTPUT SHORT...........................................634
DOME SWITCH INPUT OPEN............................................635
DOME SWITCH INPUT SHORT...........................................636
FRONT COURTESY LAMPS OUTPUT SHORT..............................638
HALO/DOOR/LIFTGATE LAMP OUTPUT SHORT............................640
READING LAMP OUTPUT SHORT........................................641
MEMORY SEAT
BCM MESSAGE NOT RECEIVED.........................................642
CHARGING VOLTAGE HIGH MESSAGE...................................643
CHARGING VOLTAGE LOW MESSAGE....................................644
xiv

Page 18 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
EEPROM REFRESH FAILURE...........................................645
FRONT RISER DOWN POSITION STUCK..................................646
FRONT RISER SENSOR OUT OF RANGE

TABLE OF CONTENTS - Continued
EEPROM REFRESH FAILURE...........................................645
FRONT RISER DOWN POSITION STUCK..................................646
FRONT RISER SENSOR OUT OF RANGE HIGH............................648
FRONT RISER SENSOR OUT OF RANGE LOW.............................651
FRONT RISER UP POSITION STUCK.....................................654
HORIZONTAL FORWARD POSITION STUCK...............................656
HORIZONTAL REARWARD POSITION STUCK..............................658
HORIZONTAL SENSOR OUT OF RANGE HIGH.............................660
HORIZONTAL SENSOR OUT OF RANGE LOW.............................663
LEFT MIRROR HORIZONTAL SENSOR OUT OF RANGE HIGH................666
LEFT MIRROR HORIZONTAL SENSOR OUT OF RANGE LOW................668
LEFT MIRROR VERTICAL SENSOR OUT OF RANGE HIGH...................670
LEFT MIRROR VERTICAL SENSOR OUT OF RANGE LOW...................672
MEMORY POSITION SWITCH STUCK.....................................674
MEMORY SWITCH INPUT OPEN.........................................676
MEMORY SWITCH INPUT SHORT........................................678
REAR RISER DOWN POSITION STUCK...................................680
REAR RISER SENSOR OUT OF RANGE HIGH.............................682
REAR RISER SENSOR OUT OF RANGE LOW..............................685
REAR RISER UP POSITION STUCK......................................688
RECLINER DOWN POSITION STUCK.....................................690
RECLINER SENSOR OUT OF RANGE HIGH...............................692
RECLINER SENSOR OUT OF RANGE LOW................................695
RECLINER UP POSITION STUCK........................................698
RIGHT MIRROR HORIZONTAL SENSOR OUT OF RANGE HIGH...............700
RIGHT MIRROR HORIZONTAL SENSOR OUT OF RANGE LOW...............702
RIGHT MIRROR VERTICAL SENSOR OUT OF RANGE HIGH.................704
RIGHT MIRROR VERTICAL SENSOR OUT OF RANGE LOW..................706
OVERHEAD CONSOLE
BUS MESSAGES MISSING..............................................708
COMPASS TEST FAILURE..............................................710
DEMAGNETIZE COMPASS AS PER SERVICE MANUAL......................711
EC MIRROR DAY/NIGHT LINE FAULT.....................................712
EVIC INTERNAL FAILURE...............................................714
OTIS MODULE MESSAGE MISMATCH....................................715
OTIS MODULE MESSAGE MISMATCH (DIESEL)............................717
*REPAIRING CMTC DISPLAYS DOUBLE DASH(--)INTEMP DISPLAY........719
POWER DOOR LOCKS/RKE
DRIVER DOOR LOCK SWITCH INPUT OPEN...............................722
DRIVER DOOR LOCK SWITCH INPUT SHORT.............................724
DRIVER DOOR LOCK SWITCH INPUT STUCK..............................726
LEFT CYLINDER LOCK SWITCH INPUT OPEN.............................728
LEFT CYLINDER LOCK SWITCH INPUT SHORT............................730
LEFT CYLINDER LOCK SWITCH INPUT STUCK............................732
LEFT UNLOCK OUTPUT FAILURE........................................734
LIFTGATE CYLINDER SWITCH INPUT OPEN...............................736
LIFTGATE CYLINDER SWITCH INPUT SHORT..............................738
LIFTGATE CYLINDER SWITCH INPUT STUCK..............................740
LIFTGATE UNLOCK POWER OUTPUT SHORT.............................742
LOCK OUTPUT FAILURE................................................744
PASSENGER DOOR LOCK SWITCH INPUT OPEN..........................747
xv

Page 19 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
PASSENGER DOOR LOCK SWITCH INPUT SHORT.........................749
PASSENGER DOOR LOCK SWITCH INPUT STUCK.........................751
RIGHT CYLINDER LOCK SWITCH INPUT OPE

TABLE OF CONTENTS - Continued
PASSENGER DOOR LOCK SWITCH INPUT SHORT.........................749
PASSENGER DOOR LOCK SWITCH INPUT STUCK.........................751
RIGHT CYLINDER LOCK SWITCH INPUT OPEN............................753
RIGHT CYLINDER LOCK SWITCH INPUT SHORT...........................755
RIGHT CYLINDER LOCK SWITCH INPUT STUCK...........................757
RIGHT UNLOCK OUTPUT FAILURE.......................................759
RKE PROGRAM LINE OUTPUT OPEN....................................761
RKE PROGRAM LINE OUTPUT SHORT...................................763
POWER DOORS - LIFTGATE
AMBIENT TEMPERATURE SENSOR CIRCUIT OPEN........................764
AMBIENT TEMPERATURE SENSOR CIRCUIT SHORT TO GROUND...........766
CONTROL MODULE FAILURE - INTERNAL FAILURE........................768
INCOMPLETE LATCH CINCH - NO CURRENT..............................769
INCOMPLETE LATCH CINCH - NO PAWL TRANSITION......................771
INCOMPLETE LATCH CINCH - OVERCURRENT............................773
INCOMPLETE LATCH CINCH - PAWL SWITCH FAILURE.....................776
INCOMPLETE LATCH CINCH - RATCHET SWITCH FAILURE..................779
INCOMPLETE LATCH RELEASE - NO CURRENT...........................782
INCOMPLETE LATCH RELEASE - RATCHET SWITCH FAILURE...............785
INCOMPLETE LATCH RELEASE- OVERCURRENT..........................787
INCOMPLETE LATCH RELEASE- PAWL SWITCH FAILURE...................788
INCOMPLETE LATCH RELEASE- SECTOR GEAR RETURN FAILURE..........790
INCOMPLETE POWER CLOSE - FULL OPEN SWITCH FAILURE...............791
INCOMPLETE POWER CLOSE - MISSING HALL SIGNAL.....................793
INCOMPLETE POWER CLOSE - OVER CURRENT..........................796
INCOMPLETE POWER CLOSE - TIME OUT................................799
INCOMPLETE POWER OPEN - FULL OPEN SWITCH FAILURE................800
INCOMPLETE POWER OPEN - LATCH FAILURE............................802
INCOMPLETE POWER OPEN - MISSING HALL SIGNAL......................808
INCOMPLETE POWER OPEN - OVERCURRENT............................811
INCOMPLETE POWER OPEN - TIME OUT.................................814
IOD WAKE UPOPEN - PLG .............................................815
LOOPBACK TEST FAILURE.............................................817
LOSS OF BCM MESSAGES.............................................818
LOSS OF EATX MESSAGES.............................................819
LOSS OF FCM MESSAGES.............................................820
LOSS OF SBEC MESSAGES............................................821
OUTSIDE LIFTGATE HANDLE INPUT SHORT..............................822
OUTSIDE LIFTGATE HANDLE INPUT STUCK...............................823
OVERHEAD LIFTGATE SWITCH INPUT STUCK.............................824
OVERHEAD LIFTGATE/LOCKOUT SWITCHES OPEN........................825
OVERHEAD LIFTGATE/LOCKOUT SWITCHES SHORT.......................827
PINCH SENSOR CIRCUIT OPEN.........................................828
PINCH SENSOR SIGNAL CIRCUIT SHORT TO GROUND.....................831
*POWER LIFTGATE INOPERATIVE.......................................833
POWER DOORS - SLIDING
AMBIENT TEMPERATURE SENSOR CIRCUIT OPEN........................834
AMBIENT TEMPERATURE SENSOR CIRCUIT SHORT TO GROUND...........835
CONTROL MODULE FAILURE - INTERNAL FAILURE........................836
INCOMPLETE LATCH CINCH - NO CURRENT..............................837
INCOMPLETE LATCH CINCH - NO PAWL TRANSITION......................839
xvi

Page 20 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
INCOMPLETE LATCH CINCH - OVERCURRENT............................841
INCOMPLETE LATCH CINCH - PAWL SWITCH FAILURE.....................843
INCOMPLETE LATCH CINCH - RATCHET

TABLE OF CONTENTS - Continued
INCOMPLETE LATCH CINCH - OVERCURRENT............................841
INCOMPLETE LATCH CINCH - PAWL SWITCH FAILURE.....................843
INCOMPLETE LATCH CINCH - RATCHET SWITCH FAILURE..................845
INCOMPLETE LATCH RELEASE - FULL OPEN SWITCH FAILURE.............848
INCOMPLETE LATCH RELEASE - NO CURRENT...........................851
INCOMPLETE LATCH RELEASE - RATCHET SWITCH FAILURE...............853
INCOMPLETE LATCH RELEASE- NO REVERSE TO UNLOAD CLUTCH.........855
INCOMPLETE LATCH RELEASE- OVERCURRENT..........................856
INCOMPLETE LATCH RELEASE- PAWL SWITCH FAILURE...................857
INCOMPLETE LATCH RELEASE- SECTOR GEAR RETURN FAILURE..........859
INCOMPLETE POWER CLOSE - FULL OPEN SWITCH FAILURE...............860
INCOMPLETE POWER CLOSE - LATCH FAILURE...........................862
INCOMPLETE POWER CLOSE - MISSING HALL SIGNAL.....................868
INCOMPLETE POWER CLOSE - OVERCURRENT...........................871
INCOMPLETE POWER CLOSE - TIME OUT................................873
INCOMPLETE POWER OPEN - FULL OPEN SWITCH FAILURE................874
INCOMPLETE POWER OPEN - LATCH FAILURE............................876
INCOMPLETE POWER OPEN - MISSING HALL SIGNAL......................881
INCOMPLETE POWER OPEN - OVERCURRENT............................884
INCOMPLETE POWER OPEN - TIME OUT.................................886
IOD WAKE UPOPEN - PSD .............................................887
IOD WAKE UP PSD & PLG SHORT.......................................889
LEFT B-PILLAR SWITCH INPUT OPEN....................................891
LEFT B-PILLAR SWITCH INPUT SHORT...................................893
LEFT B-PILLAR SWITCH INPUT STUCK...................................894
LOOPBACK TEST FAILURE.............................................895
LOSS OF BCM MESSAGES.............................................896
LOSS OF EATX MESSAGES.............................................897
LOSS OF FCM MESSAGES.............................................898
LOSS OF SBEC MESSAGES............................................899
OVERHEAD LEFT SWITCH INPUT STUCK.................................900
OVERHEAD RIGHT SWITCH INPUT STUCK................................901
OVERHEAD RIGHT/LEFT SWITCHES SHORT..............................902
RIGHT B-PILLAR SWITCH INPUT OPEN...................................903
RIGHT B-PILLAR SWITCH INPUT SHORT..................................905
RIGHT B-PILLAR SWITCH INPUT STUCK..................................906
*POWER SLIDING DOOR INOPERATIVE..................................907
POWER MIRROR ± FOLDING
FOLD MIRROR OUTPUT FAILURE........................................908
PASSENGER MIRROR RELAY OUTPUT OPEN.............................910
PASSENGER MIRROR RELAY OUTPUT SHORT............................912
UNFOLD MIRROR OUTPUT FAILURE.....................................913
*BOTH MIRRORS DO NOT UNFOLD EXCEPT WITH EITHER FRONT DOOR. . . .916
*BOTH POWER FOLDING MIRRORS DO NOT FOLD........................917
*DRIVER FOLDING MIRROR DOES NOT FOLD.............................918
*PASSENGER FOLDING MIRROR DOES NOT FOLD........................920
VEHICLE THEFT/SECURITY
BCM MESSAGES NOT RECEIVED........................................922
HORN INPUT STUCK...................................................923
HORN RELAY OPEN...................................................924
HORN RELAY SHORTED TO BATTERY....................................925
xvii

Page 21 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
INTERNAL EEPROM WRITE ERROR......................................927
INTERNAL TRANSMIT FAILURE..........................................928
INTERNAL ULTRASONIC FAULT.....

TABLE OF CONTENTS - Continued
INTERNAL EEPROM WRITE ERROR......................................927
INTERNAL TRANSMIT FAILURE..........................................928
INTERNAL ULTRASONIC FAULT.........................................929
LOOPBACK ERROR....................................................935
NO VALID MESSAGES RECEIVED........................................936
PCI BUS SHORTED TO BATTERY........................................937
PCI BUS SHORTED TO GROUND........................................938
PCM MESSAGES NOT RECEIVED........................................939
VEHICLE THEFT ALARM INDICATOR OUTPUT OPEN.......................940
VEHICLE THEFT ALARM INDICATOR OUTPUT SHORT......................941
*ALARM TRIPS ON ITS OWN............................................942
*HOOD DOES NOT TRIP VTSS..........................................943
*LEFT FRONT DOOR DOES NOT TRIP VTSS..............................944
*LEFT SLIDING DOOR DOES NOT TRIP VTSS.............................945
*LIFTGATE DOES NOT TRIP VTSS.......................................946
*REPEATER LAMPS INOPERATIVE WITH ALARM...........................947
*RIGHT FRONT DOOR DOES NOT TRIP VTSS.............................948
*RIGHT SLIDING DOOR DOES NOT TRIP VTSS............................949
*VTSS INDICATOR INOPERATIVE........................................950
*VTSS INDICATOR LAMP INOPERATIVE...................................951
*VTSS SIREN INOP....................................................952
*VTSS WILL NOT ARM..................................................955
WINDSHIELD WIPER & WASHER
FR WIPER HI-LO RELAY OPEN..........................................956
FR WIPER HI-LO RELAY SHORT TO BATT.................................958
FRONT WASH SWITCH INPUT STUCK....................................959
FRONT WASHER OUTPUT OPEN........................................961
FRONT WIPER NOT PARKED............................................963
FRONT WIPER ON RELAY OPEN........................................965
FRONT WIPER ON RELAY SHORT TO BATT...............................966
FRONT WIPER PARK SWITCH SHORT TO GND............................967
FRONT WIPER SWITCH MUX INPUT OPEN................................969
FRONT WIPER SWITCH MUX INPUT SHORT TO GROUND...................971
HEADLAMP WASHER RELAY OPEN......................................973
HEADLAMP WASHER RELAY SHORT TO BATT.............................975
REAR WASH SWITCH INPUT STUCK.....................................976
REAR WASHER OUTPUT OPEN.........................................978
REAR WIPER OUTPUT OPEN...........................................980
REAR WIPER OUTPUT SHORT TO GROUND..............................982
REAR WIPER SWITCH MUX INPUT OPEN.................................984
REAR WIPER SWITCH MUX INPUT SHORT TO GROUND....................986
VERIFICATION TESTS
VERIFICATION TESTS..................................................988
8.0 COMPONENT LOCATIONS..............................................995
8.1AIRBAG SYSTEM.................................................995
8.2BODY CONTROL MODULE.........................................996
8.3ENGINE CONTROL MODULE.......................................996
8.4HEATING & A/C...................................................996
8.4.1ACTUATORS ± FRONT LHD...............................996
xviii

Page 22 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
8.4.2ACTUATOR ± FRONT RHD................................997
8.4.3ACTUATOR ± FRONT LHD................................997
8.4.4ACTUATOR ± FRONT RHD....................

TABLE OF CONTENTS - Continued
8.4.2ACTUATOR ± FRONT RHD................................997
8.4.3ACTUATOR ± FRONT LHD................................997
8.4.4ACTUATOR ± FRONT RHD................................998
8.4.5EVAPORATOR TEMPERATURE SENSOR LHD................998
8.4.6EVAPORATOR TEMPERATURE SENSOR RHD...............999
8.4.7C202 CONNECTOR......................................999
8.4.8ACTUATORS ± REAR...................................1000
8.4.9REAR A/C HEATER UNIT CONNECTOR....................1000
8.5CABIN HEATER.................................................1001
8.5.1DIESEL CABIN HEATER ASSIST (CABIN HEATER) ASSEMBLY .1001
8.5.2C331 CONNECTOR.....................................1001
8.5.3C330 CONNECTOR.....................................1002
8.7MEMORY SYSTEM...............................................1002
8.7.1MEMORY SEAT MIRROR MEDULE/SEAT MOTORS..........1002
8.7.2MEMORY SEAT MIRROR MODULE CIRCUIT BREAKER.......1003
8.8OVERHEAD SWITCHES..........................................1003
8.9POWER FOLDING MIRRORS......................................1003
8.10POWER LIFTGATE SYSTEM.......................................1004
8.10.1MODULE..............................................1004
8.10.2PINCH SENSORS (TAPE SWITCH)........................1004
8.10.3LATCH ASSEMBLY......................................1005
8.11POWER DOOR LOCK/RKE SYSTEM................................1005
8.11.1DOOR LOCK MOTOR/AJAR SWITCH......................1005
8.11.1CYLINDER LOCK SWITCH...............................1005
8.11.3REMOTE KEYLESS ENTRY MODULE......................1006
8.12POWER SLIDING DOOR..........................................1006
8.12.1MODULE..............................................1006
8.12.2LOWER DRIVE UNIT....................................1006
8.12.3LATCH ASSEMBLY......................................1007
8.13VEHICLE THEFT SECURITY SYSTEM...............................1007
8.13.1RKE/THATCHAM ALARM MODULE........................1007
8.13.2RKE/THATCHAM ALARM MODULE CONNECTORS...........1007
8.13.3VTSS LED.............................................1008
8.13.4VTSS SIREN...........................................1008
8.13.5FRONT INTRUSION SENSOR.............................1009
8.13.6REAR INTRUSION SENSOR.............................1009
9.0 CONNECTOR PINOUTS...............................................1011
A/C-HEATER CONTROL C1 (MTC) - BLACK/RED 20 WAY...................1011
A/C-HEATER CONTROL C2 (MTC) - BLACK/BLUE 10 WAY..................1011
AMBIENT TEMP SENSOR (EXCEPT BASE) - BLACK 2 WAY.................1011
ATC REMOTE SENSOR (ATC)-4WAY...................................1012
AUTO TEMP CONTROL C1 - WHITE 13 WAY..............................1012
AUTO TEMP CONTROL C2 - BLACK 13 WAY..............................1012
AUTO TEMP CONTROL C3-4WAY.....................................1012
BLOWER MOTOR RESISTOR C1 (MTC) - BLACK 6 WAY....................1013
BLOWER MOTOR RESISTOR C2 (MTC) - BLACK 2 WAY....................1013
BODY CONTROL MODULE C1 - BLACK/BLACK 6 WAY.....................1013
BODY CONTROL MODULE C2 - BLACK/GREEN 34 WAY....................1014
BODY CONTROL MODULE C3 - BLACK/WHITE 34 WAY....................1015
BODY CONTROL MODULE C4 - BLACK/GRAY 34 WAY.....................1016
BODY CONTROL MODULE C5 - BLACK/BLACK 34 WAY....................1017
xix

Page 23 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
C200 - GRAY (BODY SIDE).............................................1018
C200 - GRAY (INSTRUMENT PANEL SIDE)................................1020
C201 - YELLOW (BODY SIDE)

TABLE OF CONTENTS - Continued
C200 - GRAY (BODY SIDE).............................................1018
C200 - GRAY (INSTRUMENT PANEL SIDE)................................1020
C201 - YELLOW (BODY SIDE)..........................................1021
C201 - YELLOW (INSTRUMENT PANEL SIDE).............................1022
C202 - GRAY (COMPONENT SIDE)......................................1022
C202 - GRAY (INSTRUMENT PANEL SIDE)................................1023
C304 - YELLOW (BODY SIDE)..........................................1023
C304 - YELLOW (SEAT SIDE)...........................................1023
C305 - GRAY (BODY SIDE).............................................1024
C306 - YELLOW (BODY SIDE)..........................................1024
C306 - YELLOW (SEAT SIDE)...........................................1024
C307 - GRAY (BODY SIDE).............................................1024
C307 - GRAY (SEAT SIDE).............................................1025
C311 - GRAY (BODY SIDE).............................................1025
C311 - GRAY (REAR A/C JUMPER SIDE).................................1026
C314 (HIGH LINE) - BLACK (BODY SIDE).................................1026
C314 (HIGH LINE) - BLACK (LIFTGATE SIDE).............................1027
C315 (HIGH LINE) - BLACK (BODY SIDE).................................1027
C315 (HIGH LINE) - BLACK (LIFTGATE SIDE).............................1027
C316 (POWER SLIDING DOOR) - BLACK (LEFT DOOR WIRE TRACK ASSEMBLY
SIDE)...............................................................1028
C316 (POWER SLIDING DOOR) - BLACK (LEFT SLIDING DOOR SIDE)........1028
C317 (POWER SLIDING DOOR) - BLACK (RIGHT DOOR WIRE TRACK ASSEMBLY
SIDE)...............................................................1028
C317 (POWER SLIDING DOOR) - BLACK (RIGHT SLIDING DOOR SIDE)......1028
C322 (MEMORY) - BLACK (BODY SIDE)..................................1029
C322 (MEMORY) - BLACK (POWER SEAT SIDE)...........................1029
C324 (MANUAL SLIDING DOOR) - BLACK (LEFT DOOR WIRE TRACK ASSEMBLY
SIDE................................................................1029
C324 (MANUAL SLIDING DOOR) - BLACK (LEFT MANUAL SLIDING DOOR
SIDE)...............................................................1030
C325 (MANUAL SLIDING DOOR) - BLACK (RIGHT DOOR WIRE TRACK ASSEMBLY
SID.................................................................1030
C325 (MANUAL SLIDING DOOR) - BLACK (RIGHT MANUAL SLIDING DOOR
SIDE)...............................................................1030
C326 - YELLOW (SAFETY SEAT SIDE)...................................1030
C326 - YELLOW (SEAT SIDE)...........................................1030
C327 - YELLOW (SAFETY SEAT SIDE)...................................1031
C327 - YELLOW (SEAT SIDE)...........................................1031
C330 (DIESEL) - GRAY (CABIN HEATER JUMPER SIDE)....................1031
C330 (DIESEL) - LT. GRAY (BODY SIDE)..................................1031
C331 (DIESEL) - BLACK (CABIN HEATER JUMPER SIDE)...................1031
C331 (DIESEL) - GRAY (CABIN HEATED COMPONENT SIDE)................1032
CABIN HEATER ASSIST C1 (DIESEL) - BLACK 6 WAY......................1032
CABIN HEATER ASSIST C2 (DIESEL) - BLACK 2 WAY......................1032
CD CHANGER-8WAY................................................1033
CENTER DOME LAMP (BASE/HIGH LINE) - GRAY 3 WAY...................1033
CLOCKSPRING C1 - WHITE 6 WAY......................................1033
CLOCKSPRING C2 - YELLOW 4 WAY....................................1034
CLOCKSPRING C4 - BLACK 2 WAY......................................1034
CLOCKSPRING C5 - YELLOW 4 WAY....................................1034
CONTROLLER ANTILOCK BRAKE - BLACK 24 WAY........................1035
DATA LINK CONNECTOR - BLACK 16 WAY...............................1035
xx

Page 24 of 4284

CHRYSLER VOYAGER 2001 Service Manual TABLE OF CONTENTS - Continued
DIAGNOSTIC JUNCTION PORT - BLACK 16 WAY..........................1036
DOSING PUMP - BLACK 2 WAY.........................................1036
DRIVER AIRBAG C1 - BROWN 2 WA

TABLE OF CONTENTS - Continued
DIAGNOSTIC JUNCTION PORT - BLACK 16 WAY..........................1036
DOSING PUMP - BLACK 2 WAY.........................................1036
DRIVER AIRBAG C1 - BROWN 2 WAY....................................1036
DRIVER AIRBAG C2 - BLACK 2 WAY.....................................1036
DRIVER BLEND DOOR ACTUATOR (ATC) - GRAY 2 WAY...................1037
DRIVER BLEND DOOR ACTUATOR (MTC) - GRAY 2 WAY...................1037
DRIVER DOOR LOCK SWITCH - BLACK 3 WAY...........................1037
DRIVER SEAT BELT SWITCH - WHITE 2 WAY.............................1037
DRIVER SEAT BELT TENSIONER-2WAY................................1038
ELECTRIC WIPER DE-ICER C1 - WHITE 2 WAY...........................1038
ELECTRIC WIPER DE-ICER C2 - WHITE 2 WAY...........................1038
ENGINE CONTROL MODULE C1 (DIESEL) - BLACK 81 WAY.................1039
ENGINE CONTROL MODULE C2 (DIESEL) - BLACK 40 WAY.................1041
EVAPORATOR TEMPERATURE SENSOR - BLACK 2 WAY...................1041
FRONT BLOWER MODULE C1 (ATC) - BLACK 4 WAY......................1042
FRONT BLOWER MODULE C2 (ATC) - BLACK 2 WAY......................1042
FRONT READING LAMPS/SWITCH - BLACK 6 WAY........................1042
GLOVE BOX LAMP - BLUE 2 WAY.......................................1042
HALO LAMP - BLUE 2 WAY.............................................1042
HEADLAMP SWITCH - BLACK 13 WAY...................................1043
HEADLAMP WASHER PUMP MOTOR (BUILT-UP-EXPORT) - BLACK 2 WAY. . . .1043
IGNITION SWITCH - BLACK 5 WAY......................................1043
INSTRUMENT CLUSTER - BLACK 13 WAY................................1044
INTELLIGENT POWER MODULE C1 - LT. GREEN/RED 20 WAY..............1044
INTELLIGENT POWER MODULE C2 - GREEN/BLUE 10 WAY................1045
INTELLIGENT POWER MODULE C3 (DIESEL) - YELLOW/RED 20 WAY........1045
INTELLIGENT POWER MODULE C3 (GAS) - NATURAL/RED 20 WAY..........1046
INTELLIGENT POWER MODULE C4 - BLUE 10 WAY.......................1046
INTELLIGENT POWER MODULE C5 - BLACK 4 WAY.......................1046
INTELLIGENT POWER MODULE C6 - NATURAL 10 WAY....................1047
INTELLIGENT POWER MODULE C7 - BLACK/RED 20 WAY..................1047
INTELLIGENT POWER MODULE C8 - ORANGE 10 WAY....................1048
INTELLIGENT POWER MODULE C9 - BLACK 10 WAY......................1048
LEFT B-PILLAR SWITCH - GRAY 3 WAY..................................1048
LEFT CINCH/RELEASE MOTOR (POWER SLIDING DOOR) - GRAY 4 WAY.....1048
LEFT CYLINDER LOCK SWITCH - BLACK 2 WAY..........................1049
LEFT DOOR SPEAKER - BLACK/RED 6 WAY..............................1049
LEFT FOG LAMP - WHITE 2 WAY.......................................1049
LEFT FRONT DOOR AJAR SWITCH (BASE) - BLACK 2 WAY.................1049
LEFT FRONT DOOR LOCK MOTOR/AJAR SWITCH (EXCEPT BASE) -
BLACK 4 WAY........................................................1050
LEFT FRONT PARK/TURN SIGNAL LAMP (EXCEPT BUILT-UP-EXPORT) -
BLACK 3 WAY........................................................1050
LEFT FULL OPEN SWITCH (POWER SLIDING DOOR) - BLACK 2 WAY........1050
LEFT HEADLAMP (EXCEPT BUILT-UP-EXPORT) - BLACK 3 WAY.............1050
LEFT HIGH BEAM LAMP (BUILT-UP-EXPORT) - BLACK 2 WAY...............1051
LEFT INSTRUMENT PANEL SPEAKER - BLACK 2 WAY.....................1051
LEFT LOW BEAM LAMP (BUILT-UP-EXPORT) - BLACK 2 WAY...............1051
LEFT PARK LAMP (BUILT-UP-EXPORT) - BLACK 2 WAY....................1051
LEFT POWER MIRROR - BLACK 12 WAY.................................1052
LEFT REAR PILLAR SPEAKER - BLACK 2 WAY............................1052
LEFT REAR READING LAMP (LUXURY) - GRAY 3 WAY.....................1052
LEFT REAR SPEAKER - BLACK/RED 6 WAY..............................1052
xxi

Load next 8 pages

Page: < prev 1-8 9-16 17-24 25-32 33-40 41-48 49-56 ... 4288 next >

tailgate oil viscosity ABS open gas tank coolant temperature boot