2006 LAND ROVER FRELANDER 2 Repair Manual

wheel bolts auxiliary battery open hood dead battery open trunk ground clearance jump cable

Load previous 8 pages

Page 1409 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual Publi s hed: 11-May-2011
Clutch -
Lubricants, Fluids, Sealers and AdhesivesItemSpecification
Recommended hydraul ic fluidSHELL DONAX Y B DOT4 ESL FLUID
General Specification
ItemSpecification
Clut ch

Page 1410 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual Publi s hed: 11-May-2011
Clutch - Clutch Disc and Pressure Plate
Removal and Inst all ati on
Special T ool(s) 303-1272
Locki ng Tool , Flywheel 308-667
Al igner, Clut ch
Removal Di sconnect t he bat

Page 1411 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual 5. CAUTION: Di scard the bolt s .
• NOTE: Loosen the bolt s of t he cl utch pres s ure pl ateeach two turns at a t ime in t he s equence s hown.
• NOTE: Res train t he flywheel .
5.
Installation

Page 1412 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual 2.
CAUTIONS: Examine the flywheel for s igns of s coring or
overheati ng. Renew i f worn or damaged. Examine the clut ch rel eas e beari ng for s igns of
wear or damage. Renew i f necess ary.
Clea

Page 1413 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual Remove t he s pecial t ool .
Speci al Tool (s ): 303-1272 4.
Inst all t he transmis si on.
Refer t o: Transmis s ion (308-03 Manual Trans mi s si on/Trans axl e,
Inst all at ion).
5.
Connect t

Page 1414 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual Publi s hed: 12-May-2011
Clutch Controls -
Torque SpecificationsDescriptionNmlb-ft
Clut ch bleed s crew107
Clut ch pedal box nuts2418Clut ch s lave cyl inder bol ts118

Page 1415 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual Publi s hed: 11-May-2011
Clutch Controls - Clutch Controls
Des cript ion and Operat ion
COMPONENT LOCATION
ItemPart NumberDescription1-Brake/clut ch res ervoir
2-Brake mas ter cylinder
3-Connector4-Lo

Page 1416 of 3229

LAND ROVER FRELANDER 2 2006 Repair Manual which i s hydraulicall y act uated from t he cl utch pedal.
Pres s ing t he clutch pedal pres surizes t he hydraul ic fluid in the mas t er cyli nder. The fl uid pres s ure is t rans ferred via a pip

which i s hydraulicall y act uated from t he cl utch pedal.
Pres s ing t he clutch pedal pres surizes t he hydraul ic fluid in the mas t er cyli nder. The fl uid pres s ure is t rans ferred via a pipefrom the mas t er cyli nder t o t he s lave cyl inder in the t rans mis s ion. The fluid press ure operates t he s lave cylinder which i nt urn pus hes the fingers of t he clut ch cover, rel easi ng the driven pl at e and di sengagi ng t he dri ve from t he engi ne crankshaftt o the trans mi s si on.
A hydrauli c clutch bl eed adapt or i s l ocated on the front of t he transmis s ion. The adapt or provi des the connect ion betweent he pres sure pipe from t he mas ter cyl inder to the s l ave cyli nder. The adapt or contains a bleed s crew to purge t he cl utchhydraulic sys tem of air aft er s ervice repl acement of one of the hydrauli c components. The adaptor als o i ncl udes a peakt orque li mit er. This prevent s ins t ant clut ch engagement if t he dri ver accident all y rel eas es t he clutch l ever t o preventdamage to the driveli ne components .
Stop/Start Vehicles - From 2010 MY
Clut ch Mast er Cyl inder and Linear Cl utch Sensor
The li near clut ch s ens or, l ocat ed on t he cl utch mas t er cyli nder and hardwi red t o t he CJB, i s us ed to s ens e t he posi ti on oft he cl utch pedal. It is us ed in conjunct ion wi th ot her sens or out puts t o t ri gger an engine res tart, engine s t op or st allrecovery on St op/Start vehi cl es. It is al s o us ed along wit h t he first and revers e gear s wi tches to compl ete cl ut chplaus ibil it y.
A magnet ins ide the clut ch mas ter cylinder provides t he posi ti on indicator for the linear cl utch s ensor. For t his reason, ift he mas ter cyl inder is replaced the correct replacement mas t er cyli nder mus t be i dent ified and fit t ed.For addit ional informat ion, refer t o: Starti ng Sys t em (303-06C Starti ng Syst em - TD4 2.2L Di es el, Vehicles Bui lt From:01-03-2009, Descripti on and Operat ion).
Linear Clutch Sens or

Load next 8 pages

Page: < prev 1-10 ... 1377-1384 1385-1392 1393-1400 1401-1408 1409-1416 1417-1424 1425-1432 1433-1440 1441-1448 ... 3232 next >

phone TPMS spark plugs replace fuel type differential MPG