Page 1785 of 4555
TROUBLE DIAGNOSIS
EC-1381
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
Worksheet Sample
DTC Inspection Priority ChartEBS012AT
If some DTCs are displayed at the same time, perform inspections one by one based on the following priority
chart.
NOTE:
If DTC U1000 is displayed with other DTC, first perform the trouble diagnosis for DTC U1000. Refer to
EC-1425, "
DTC U1000 CAN COMMUNICATION LINE" .
MTBL0533
Page 1786 of 4555
![NISSAN X-TRAIL 2005 Service Repair Manual EC-1382
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
Basic InspectionEBS011XF
Precaution:
Perform Basic Inspection without electrical or mechanical loads applied;
Headlamp switch is OFF.
On vehicles NISSAN X-TRAIL 2005 Service Repair Manual EC-1382
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
Basic InspectionEBS011XF
Precaution:
Perform Basic Inspection without electrical or mechanical loads applied;
Headlamp switch is OFF.
On vehicles](/manual-img/5/57403/w960_57403-1785.png)
EC-1382
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
Basic InspectionEBS011XF
Precaution:
Perform Basic Inspection without electrical or mechanical loads applied;
Headlamp switch is OFF.
On vehicles equipped with daytime light systems, set lighting switch to the 1st position to light
only small lamps.
Air conditioner switch is OFF.
Rear defogger switch is OFF.
Steering wheel is in the straight-ahead position, etc.
Priority Detected items (DTC)
1
U1000 CAN communication line
P0016 Crankshaft position - camshaft position correlation
P0102 P0103 Mass air flow sensor
P0112 P0113 Intake air temperature sensor
P0117 P0118 Engine coolant temperature sensor
P0122 P0123 P0222 P0223 P2135 Accelerator pedal position sensor
P0182 P0183 Fuel pump temperature sensor
P0192 P0193 Fuel rail pressure sensor
P0237 P0238 Turbocharger boost sensor
P0335 P0336 Crankshaft position sensor
P0340 P0341 Camshaft position sensor
P0563 Battery voltage
P0605 P0606 ECM
P0642 P0643 P0652 P0653 Sensor power supply
P1260 - P1267 Fuel injector adjustment resistor
P1610 - P1617 NATS
P2228 P2229 Barometric pressure sensor
2
P0089 P0628 P0629 P1272 - P1275 Fuel pump
P0200 - P0204 P1268 - P1271 P2146 - P2149 Fuel injector
P0686 ECM relay
P1212 TCS communication line
3
P0088 P0093 Fuel system
P0217 Engine over temperature (OVERHEAT)
P0234 Turbocharger system
P0501 P0502 P0503 ASCD vehicle speed sensor
P0504 ASCD brake switch
P0580 P0581 ASCD steering switch
P1211 TCS control unit
Page 1787 of 4555
![NISSAN X-TRAIL 2005 Service Repair Manual TROUBLE DIAGNOSIS
EC-1383
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
1. INSPECTION START
1. Check service records for any recent repairs that may indicate a related malfunction.
2. Check the NISSAN X-TRAIL 2005 Service Repair Manual TROUBLE DIAGNOSIS
EC-1383
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
1. INSPECTION START
1. Check service records for any recent repairs that may indicate a related malfunction.
2. Check the](/manual-img/5/57403/w960_57403-1786.png)
TROUBLE DIAGNOSIS
EC-1383
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
1. INSPECTION START
1. Check service records for any recent repairs that may indicate a related malfunction.
2. Check the current need for scheduled maintenance, especially for fuel filter and air cleaner filter. Refer to
MA-7, "
Periodic Maintenance" .
3. Open engine hood and check the following:
–Harness connectors for improper connections
–Vacuum hoses for splits, kinks, or improper connections
–Wiring for improper connections, pinches, or cuts
4. Start engine and warm it up to the normal operating tempera-
ture.
>> GO TO 2.
2. PREPARATION FOR CHECKING IDLE SPEED
With CONSULT-II
Connect CONSULT-II to the data link connector.
Without CONSULT-II
Install diesel tacho tester to the vehicle.
>> GO TO 3.
3. CHECK IDLE SPEED
With CONSULT-II
1. Select “CKPS·RPM (TDC)” in “DATA MONITOR” mode with CONSULT-II.
2. Read idle speed.
Without CONSULT-II
Read idle speed.
OK or NG
OK >>INSPECTION END
NG >> GO TO 4.
SEF142I
725±25 rpm
SEF817Y
725±25 rpm
Page 1788 of 4555
EC-1384
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
4. CHECK FOR INTAKE AIR LEAK
Listen for an intake air leak after the mass air flow sensor.
OK or NG
OK >> GO TO 5.
NG >> Repair or replace.
5. BLEED AIR FROM FUEL SYSTEM
1. Stop engine.
2. Use priming pump to bleed air from fuel system. Refer to EC-1370, "
AIR BLEEDING" .
>> GO TO 6.
6. CHECK IDLE SPEED AGAIN
With CONSULT-II
1. Start engine and let it idle.
2. Select “CKPS·RPM (TDC)” in “DATA MONITOR” mode with CONSULT-II.
3. Read idle speed.
Without CONSULT-II
Read idle speed.
OK or NG
OK >>INSPECTION END
NG >> GO TO 7.
7. DRAIN WATER FROM FUEL FILTER
Drain water from fuel filter. Refer to EC-1370, "
WATER DRAINING" .
>> GO TO 8. 725±25 rpm
SEF817Y
725±25 rpm
Page 1789 of 4555
TROUBLE DIAGNOSIS
EC-1385
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
8. CHECK IDLE SPEED AGAIN
With CONSULT-II
1. Start engine and let it idle.
2. Select “CKPS·RPM (TDC)” in “DATA MONITOR” mode with CONSULT-II.
3. Read idle speed.
Without CONSULT-II
Read idle speed.
OK or NG
OK >>INSPECTION END
NG >> GO TO 9.
9. CHECK AIR CLEANER FILTER
Check air cleaner filter for clogging or breaks.
OK or NG
OK >> GO TO 10.
NG >> Replace air cleaner filter.
10. CHECK BATTERY VOLTAGE
Check battery voltage.
OK or NG
OK >> GO TO 12.
NG >> GO TO 11.
11 . CHECK BATTERY
Refer to SC-4, "
BATTERY" .
OK or NG
OK >> Check charging system. Refer to SC-13, "CHARGING SYSTEM" .
NG >> Repair or replace.
12. CHECK COMPRESSION PRESSURE
Check compression pressure. Refer to EM-209, "
CHECKING COMPRESSION PRESSURE" .
OK or NG
OK >> GO TO 13.
NG >> Follow the instruction of “CHECKING COMPRESSION PRESSURE”.725±25 rpm
SEF817Y
725±25 rpm
Voltage: More than 12.13V
Page 1790 of 4555
EC-1386
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
13. CHECK IDLE SPEED AGAIN
With CONSULT-II
1. Start engine and let it idle.
2. Select “CKPS·RPM (TDC)” in “DATA MONITOR” mode with CONSULT-II.
3. Read idle speed.
Without CONSULT-II
Read idle speed.
OK or NG
OK >>INSPECTION END
NG >> 1. Replace fuel injector.
2. GO TO 3. 725±25 rpm
SEF817Y
725±25 rpm
Page 1791 of 4555
![NISSAN X-TRAIL 2005 Service Repair Manual TROUBLE DIAGNOSIS
EC-1387
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
Symptom Matrix ChartEBS011XG
SYSTEM — Basic engine control systemSYMPTOM
Reference page
HARD/NO START/RESTART (EXCP. HA) NISSAN X-TRAIL 2005 Service Repair Manual TROUBLE DIAGNOSIS
EC-1387
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
Symptom Matrix ChartEBS011XG
SYSTEM — Basic engine control systemSYMPTOM
Reference page
HARD/NO START/RESTART (EXCP. HA)](/manual-img/5/57403/w960_57403-1790.png)
TROUBLE DIAGNOSIS
EC-1387
[YD (WITHOUT EURO-OBD)]
C
D
E
F
G
H
I
J
K
L
MA
EC
Symptom Matrix ChartEBS011XG
SYSTEM — Basic engine control systemSYMPTOM
Reference page
HARD/NO START/RESTART (EXCP. HA) ENGINE STALL HESITATION/SURGING/FLAT SPOT KNOCK/DETONATION
LACK OF POWER POOR ACCELERATION HI IDLE LOW IDLE
NO START (with first firing) NO START (without first firing) HARD TO START WHEN ENGINE IS COLD HARD TO START WHEN ENGINE IS HOT
AT I D L E DURING DRIVING WHEN DECELERATING
Warranty symptom code AA AB AC AD AE AF
Fuel pump 55555555 55 5 —
Fuel injector 3333333334433EC-1474
Glow control system 1 1 1 1 1EC-1643
Engine body 3333333 344 3EM-222
Fuel transport pump 2 2 2EC-1682
EGR system33EC-1651
Air cleaner and duct33EM-142
Fuel rail pressure relief valve 3 3 3 3 3 3 3 3 3 3 3EC-1434
ENGINE CONTROLFuel pump circuit 4 4 4 4 4 4 4 4 4 4 4EC-1570
Fuel injector circuit 1111111111111EC-1474
Mass air flow sensor circuit 1 1 1EC-1438
Engine coolant temperature circuit 1 1 1 1EC-1449
Vehicle speed signal circuit1LAN-4
Accelerator pedal position sensor circuit 1 1 1EC-1455
Fuel rail pressure sensor circuitEC-1466
Page 1792 of 4555
![NISSAN X-TRAIL 2005 Service Repair Manual EC-1388
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
1 - 5: The numbers refer to the order of inspection.
(continued on next page)
ENGINE CONTROL
Crankshaft position sensor circuit 1 1 1 1 1 1 1 1 1 1E NISSAN X-TRAIL 2005 Service Repair Manual EC-1388
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
1 - 5: The numbers refer to the order of inspection.
(continued on next page)
ENGINE CONTROL
Crankshaft position sensor circuit 1 1 1 1 1 1 1 1 1 1E](/manual-img/5/57403/w960_57403-1791.png)
EC-1388
[YD (WITHOUT EURO-OBD)]
TROUBLE DIAGNOSIS
1 - 5: The numbers refer to the order of inspection.
(continued on next page)
ENGINE CONTROL
Crankshaft position sensor circuit 1 1 1 1 1 1 1 1 1 1EC-1512
Camshaft position sensor circuit 3 3EC-1525
Turbocharger boost sensor circuit 1 1 1EC-1659
Turbocharger boost control solenoid
valve circuit111EC-1659
Start signal circuit 1 1 1 1 1 1 1 1 1EC-1696
Ignition switch circuit 1 1 1 1EC-1415
Power supply for ECM circuit 1 1 1 1EC-1415
Cooling fan relay circuitEC-1480
EGR volume control valve circuit 1 1 1EC-1651
Glow relay circuit 1 1 1 1EC-1643
ECM relay (Self-shutoff) circuit 1 1 1 1EC-1584
ECM, connector circuit 2 2 2 2 2 2 2 2 2 2 2 2 2EC-1566,
EC-1641
NATS (Nissan Anti-theft System) 1EC-1373
SYSTEM — Basic engine control systemSYMPTOM
Reference page
HARD/NO START/RESTART (EXCP. HA) ENGINE STALL HESITATION/SURGING/FLAT SPOT KNOCK/DETONATION LACK OF POWER POOR ACCELERATION HI IDLE
LOW IDLE
NO START (with first firing) NO START (without first firing)
HARD TO START WHEN ENGINE IS COLD HARD TO START WHEN ENGINE IS HOT AT I D L E DURING DRIVING WHEN DECELERATING
Warranty symptom code AA AB AC AD AE AF