2005 NISSAN X-TRAIL Service Repair Manual

manual transmission climate settings wheel bolts fuel cap release navigation update service indicator

Load previous 8 pages

Page 385 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual OVERHEATING CAUSE ANALYSIS
CO-29
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
CO

Except cool-
ing system
parts mal-
function— Overload on engineAbusive drivingHigh engine rpm under no
load
Driving in low g

Page 386 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual CO-30
[YD22DDTi]
COOLING SYSTEM

COOLING SYSTEMPFP:21020
Cooling CircuitEBS00BAX
PBIC0935E

Page 387 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual COOLING SYSTEM
CO-31
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
CO

System ChartEBS00LS1
MBIA0056E

Page 388 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual CO-32
[YD22DDTi]
ENGINE COOLANT

ENGINE COOLANTPFP:KQ100
InspectionEBS00BAY
LEVEL CHECK
Check if the reservoir tank engine coolant level is within “MIN” to
“MAX” when engine is cool.
Adjust

Page 389 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual ENGINE COOLANT
CO-33
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
CO

If contaminated, flush engine cooling system. Refer to CO-34, "FLUSHING COOLING SYSTEM" .
REFILLING ENGINE COOLANT
1. Install reservoir tan

Page 390 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual CO-34
[YD22DDTi]
ENGINE COOLANT

10. Warm up engine, and check for sound of engine coolant flow while running engine from idle up to 3,000
rpm with heater temperature controller set at several positi

Page 391 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual RADIATOR
CO-35
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
CO

RADIATORPFP:21400
Removal and InstallationEBS00BB0
WARNING:
Do not remove radiator cap when engine is hot. Serious burns could occur from high-pre

Page 392 of 4555

NISSAN X-TRAIL 2005 Service Repair Manual CO-36
[YD22DDTi]
RADIATOR

Start and warm up engine. Visually check if there is no leaks of engine coolant.
Checking Radiator CapEBS01FA3
Check valve seat of radiator cap.
–Check if valve seat i

CO-36
[YD22DDTi]
RADIATOR

Start and warm up engine. Visually check if there is no leaks of engine coolant.
Checking Radiator CapEBS01FA3
Check valve seat of radiator cap.
–Check if valve seat is swollen to the extent that the edge of the
plunger cannot be seen when watching it vertically from the top.
–Check if valve seat has no soil and damage.
Pull negative-pressure valve to open it, and make sure that it is
completely closed when released.
–Make sure that there is no dirt or damage on the valve seat of
radiator cap negative-pressure valve.
–Make sure that there are no unusualness in the opening and
closing conditions of negative-pressure valve.
Check radiator cap relief pressure.
–When connecting radiator cap to the radiator cap tester (com-
mercial service tool) and the radiator cap tester adapter (special
service tool), apply engine coolant to the cap seal surface.
Replace radiator cap if there is an unusualness related to the above three.
CAUTION:
When installing radiator cap, thoroughly wipe out the radiator filler neck to remove any waxy residue
or foreign material.
Checking RadiatorEBS011WN
Check radiator for mud or clogging. If necessary, clean radiator as follows.
Be careful not to bend or damage the radiator fins.
When radiator is cleaned without removal, remove all surrounding parts such as cooling fan, radiator
shroud and horns. Then tape the harness and connectors to prevent water from entering.
1. Apply water by hose to the back side of the radiator core vertically downwards.
2. Apply water again to all radiator core surface once per minute.
3. Stop washing if any stains no longer flow out from the radiator.
4. Blow air into the back side of radiator core vertically downwards.
Use compressed air lower than 490 kPa (4.9 bar, 5 kg/cm2 , 71psi) and keep distance more than 30 cm
(11.8 in).
5. Blow air again into all the radiator core surface once per minute until no water sprays out.
PBIC2816E
SMA967B
Standard:
78 - 98 kPa (0.78 - 0.98bar, 0.8 - 1.0 kg/cm
2 , 11 - 14 psi)
Limit:
59 kPa (0.59bar, 0.6 kg/cm
2 , 9 psi)
SLC755AC

Load next 8 pages

Page: < prev 1-10 ... 353-360 361-368 369-376 377-384 385-392 393-400 401-408 409-416 417-424 ... 4560 next >

four wheel drive battery replacement diagnostic menu spark plugs towing capacity oil capacity