2001 NISSAN ALMERA Service Manual

Page 2481 of 2898

NISSAN ALMERA 2001  Service Manual 4 CHECK ANY PART
Is there any part to be replaced? (Evaporator, condenser, liquid tank or in case there is evidence of a large amount of
lubricant leakage.)
YesorNo
Ye s©GO TO HA-82.
No©Carry out th

Page 2482 of 2898

NISSAN ALMERA 2001  Service Manual Lubricant Adjusting Procedure for Components
Replacement Except Compressor
=NJHA0160S0201After replacing any of the following major components, add the
correct amount of lubricant to the system.
Amoun

Page 2483 of 2898

NISSAN ALMERA 2001  Service Manual RHA065DH
Compressor
REMOVAL AND INSTALLATIONNJHA0161
RHA803H
SERVICE PROCEDURE
Maintenance of Lubricant Quantity in Compressor (Contd)
HA-83

Page 2484 of 2898

NISSAN ALMERA 2001  Service Manual RHA804H
Compressor Clutch Ð CSV613 (CALSONIC
make)
OVERHAULNJHA0211
RHA805H
SERVICE PROCEDURE
Compressor (Contd)
HA-84

Page 2485 of 2898

NISSAN ALMERA 2001  Service Manual RHA136E
REMOVALNJHA0212+When removing center bolt, hold clutch disc with clutch disc
wrench.
RHA399FA
RHA124FA
+Remove the clutch disc using the clutch disc puller.
Insert the holders three pins into

Page 2486 of 2898

NISSAN ALMERA 2001  Service Manual RHA806H
+Remove the connector from the connector bracket.
RHA145E
+Remove the snap ring using external snap ring pliers.
RHA126F
INSPECTIONNJHA0213Clutch DiscNJHA0213S01If the contact surface shows si

Page 2487 of 2898

NISSAN ALMERA 2001  Service Manual RHA143E
+Install the pulley assembly using the installer and a hand
press, and then install the snap ring using snap ring pliers.
RHA127F
+Install the clutch disc on the drive shaft, together with the

Page 2488 of 2898

NISSAN ALMERA 2001  Service Manual Heater & Cooling Unit (Heater Core)
REMOVALNJHA0193
RHA807H
1. Drain the cooling system. Refer to LC-18 (QG), LC-44 (YD),
ªChanging Engine Coolantº.
2. Discharge the A/C system. Refer to HA-78.
3. D