1999 TOYOTA CAMRY Service Repair Manual

maintenance reset fuel tank removal fuse box location load capacity high beam TPMS

Load previous 8 pages

Page 337 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLECOMPONENT PARTS REMOVAL ±
AX±31
(c) Using SST, remove the gear and bearing.
SST 09350±32014 (09351±32061)
9. REMOVE OUTER RACE, SPACER AND OIL SLINGER
(a) Using SST, remove the

Page 338 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLECOMPONENT PARTS REMOVAL ±
AX±32
(d) Remove the bearing cage from drive pinion.
(e) Using SST, press out the bearing.
SST 09950±00020

Page 339 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLECOMPONENT PARTS REMOVAL ±
AX±33
GENERAL NOTES
The instructions here are organized so that you work on only one component group at a time.
This will help avoid confusion from simil

AUTOMATIC TRANSAXLECOMPONENT PARTS REMOVAL ±
AX±33
GENERAL NOTES
The instructions here are organized so that you work on only one component group at a time.
This will help avoid confusion from similar±looking parts of different subassemblies being on your work-
bench at the same time.
The component groups are inspected and repaired from the converter housing side.
As much as possible, complete the inspection, repair and assembly before proceeding to the next compo-
nent group. If a component group cannot be assembled because parts are being ordered, be sure to keep
all parts of that group in a separate container while proceeding with disassembly, inspection, repair and
assembly of other component groups.
Recommended fluid for the automatic transaxle: ATF D±@@@@@: [g 2] or DEXRON®@@@@@: [g
3](DEXRON®@@@@@: [g 2])
1. GENERAL CLEANING NOTES:
(a) All disassembled parts should be washed clean and any fluid passages and holes blown through with
compressed air.
(b) When using compressed air to dry parts, always aim away from yourself to prevent accidentally spray-
ing automatic transaxle fluid or kerosene in your face.
(c) The recommended automatic transaxle fluid or kerosene should be used for cleaning.
2. PARTS ARRANGEMENT:
(a) After cleaning, the parts should be arranged in the correct order to allow efficient inspection, repairs,
and reassembly.
(b) When disassembling a valve body, be sure to keep each valve together with the corresponding spring.
(c) New brakes and clutches that are to be used for replacement must be soaked in transaxle fluid for at
least fifteen minutes before assembly.
3. GENERAL ASSEMBLY:
(a) All oil seal rings, clutch discs, clutch plates, rotating parts, and sliding surfaces should be coated with
transmission fluid prior to reassembly.
(b) All gaskets and rubber O±rings should be replaced.
(c) Make sure that the ends of a snap ring are not aligned with one of the cutouts and are installed in the
groove correctly.
(d) If a worn bushing is to be replaced, the subassembly containing that bushing must be replaced.
(e) Check thrust bearings and races for wear or damage. Replace if necessary.
(f) Use petroleum jelly to keep parts in place.
AX02T±07

Page 340 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLESECOND COAST BRAKE ±
AX±34
SECOND COAST BRAKE
COMPONENTS
SECOND COAST BRAKE PISTON
DISASSEMBLY
1. REMOVE OIL SEAL RING
Remove the oil seal ring from the piston.
2. REMOVE PISTON R

Page 341 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLESECOND COAST BRAKE ±
AX±35
(b) Remove the inner spring, plate washer and piston rod.
SECOND COAST BRAKE COMPONENT
INSPECTION
If the lining of the brake band is peeling off or disc

Page 342 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLESECOND COAST BRAKE ±
AX±36
(b) Install the E±ring while pushing the piston.
3. INSTALL OIL SEAL RING
(a) Apply ATF to the oil seal ring.
(b) Install the oil seal ring to the pist

Page 343 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLEOIL PUMP ±
AX±37
OIL PUMP
COMPONENTS
OIL PUMP DISASSEMBLY
1. REMOVE OIL SEAL RINGS
Remove the 2 oil seal rings from the stator shaft back
side.
2. REMOVE THRUST WASHER FROM STATOR

Page 344 of 4592

TOYOTA CAMRY 1999 Service Repair Manual AUTOMATIC TRANSAXLEOIL PUMP ±
AX±38
3. REMOVE STATOR SHAFT
Remove the 11 bolts and stator shaft.
HINT: Keep the gears in assembly order.
4. REMOVE FRONT OIL SEAL
Pry off the oil seal with a screwdri

Load next 8 pages

Page: < prev 1-10 ... 305-312 313-320 321-328 329-336 337-344 345-352 353-360 361-368 369-376 ... 4592 next >

open bonnet wiper blades sunroof timing belt airbag disable tyre pressure