Page 145 of 2103

ENGINE OVERHAUL Cylinder Head and Valves,
Oversize I.D.
RemovalInstallation
PressPress
Push rod
Valve
guide Push rod
Valve
guide
(2) Rebore the valve seat hole in the cylinder to’
selected oversize valve seat diameter.
I n t a k e s e a t r i n g h o l e ’
0.3 O.S. 35.30 35.33 mm (1.3989 1.3909 in.)
0.6 OS. 35.60
35.63 mm (1.4018
Exhaust seat ring hole diameters
0.3 O.S. 33.30
33.33 mm (1.3110 1.3122 in.)
0.6 O.S. 33.60
36.63 mm (1.3228 in.)
(3) Before fitting the valve seat, either heat the cylinder head
up to approximately
or cool the valve seat
in liquid nitrogen, to prevent the cylinder head bo re from
galling.
(4) Using a valve seat cutter, correct the valve seat to the
specified width and angle.
See “VALVE SEAT RECONDITIONING PROCEDURE”.
VALVE GUIDE REPLACEMENT PROCEDURE
(1) Using the push rod and a press, remove the valv e guide
toward cylinder head gasket surface.
(2) Rebore valve guide hole to the new oversize valve guide
outside diameter.
Valve guide hole diameters
0.05 O.S. 12.05
12.07 mm in.)
0.25 O.S. 12.25
12.27 mm
0.50 O.S. 12.50 12.52 mm In.)
NOTE
Do not install a valve guide of the same size again .
(3) Using the special tool, press-fit the valve gui de, working
from the cylinder head top surface.
(4) After installing valve guides, insert new valve s in them
to check for sliding condition.
(5) When valve guides have been replaced, check for valve
contact and correct valve seats as necessary.
TSB RevisionI
Page 146 of 2103
ENGINE OVERHAUL.
FRONT CASE, COUNTERBALANCE SHAFT AND OIL
REMOVAL AND INSTALLATION
1 3 1
24 Nm17
10 Nm
I18I I
76
17 Nm
19 Nm 101 4
45 Nm
33. . Nm
17I
10 Nm19 Nm14
40 Nm
5
Removal steps
Oil filter
2. Oil cooler bolt
3. Oil cooler
4. Drain plug
5. Drain plug gasket
6. Oil pan
7.Oil screen
8. Oil screen gasket
9. Baffle plate 10. Plug11. O-ring 12. Flange bolt 13. Oil pressure switch 14. Oil pressure gauge unit15. Relief plug
16. Gasket 17. Relief spring
18. Relief plunger
TSB Revision 19. Oil filter bracket
20. Oil filter bracket gasket
21. Oil pump cover
22. Oil pump driven gear 23. Oil pump drive gear 24. Crankshaft front oil seal
25. Oil pump oil seal 26. Counterbalance shaft oil seal 27. Front case
28. Front case gasket
29. Counterbalance shaft, left
30. Counterbalance shaft, right
31. Counterbalance shaft, front 32. shaft, rear
33. shaft, rear bearing,
Page 147 of 2103
Front Case,
ENGINE OVERHAUL and Pan
Phillips screwdriver
F r o n tbearing
REMOVAL SERVICE POINTS
PAN REMOVAL
(1) Remove all oil pan bolts.
(2) Drive in the special tool between the
and.
oil pan.
NOTE
Never use a screwdriver or chisel, instead of
tool, as a deformed oil pan flange result in oil leakage.
PLUG REMOVAL
(1) If the plug is too tight, hit the plug head wit h a hammer
two to three times, and theplug will be easily loosened.
FLANGE BOLT REMOVAL
(1) Remove the plug on the side of cylinder block.
(2) Insert a Phillips screwdriver [shank diameter 8 mm
in.)] into the plug hole to lock the counterbalance shaft.
(3) Loosen the flange bolt.
COUNTERBALANCE FRONT
REMOVAL ,
Using the special tool, remove the counterbalance s haft
front bearing from the cylinder block.
NOTE
Be sure to remove the front bearing
If it has not been removed, the Rear Bearing Puller cannot
b e u s e d .
TSB Revision
Page 148 of 2103
11Front Case, ENGINE OVERHAUL Shaft and
Rear bearing
COUNTERBALANCE SHAFT REAR BEARING
REMOVAL
Using the special tool, remove the counterbalance shaft
. rear bearing from the cylinder block.
NOTE
When removing the left counterbalance shaft, install the
special tool
to the front of the cylinder block.
INSTALLATION SERVICE POINTS
RIGHT COUNTERBALANCE REAR
BEARING INSTALLATION
(1) Apply engine oil to the outer surface of bearin g.
(2) Using special tools, install right rear bearing .
that oil hole of bearing is aligned oil hole of
block.
,
LEFT COUNTERBALANCE SHAFT
BEARING INSTALLATION
(1) Install the special tool (GUIDE to
block.
(2) Apply engine oil to the rear bearing outer
and bearing hole in cylinder block.
(3) Using the special tool, install’ the rear
NOTE
The left rear bearing has no oil holes.
TSB Revision
Page 149 of 2103
Front Case, Counterbalance
ENGINE OVERHAUL Shaft and
C y l i n d e rblock
COUNTERBALANCE
INSTALLATION
(1) Using special tools, install front bearing., ,
FRONT CASE
(1) Place the special tool on the front end of crankshaft and
apply a thin coat of engine oil to the outer
of the special tool to install the front
(2) Install the front case assembly through a new f ront case
gasket and temporarily tighten the flange bolts (ot her
than those for tightening the filter bracket).
COUNTERBALANCE SHAFT OIL SEAL
INSTALLATION
Page 150 of 2103
11Front Case, ENGINE OVERHAUL Shaft and
Socket
Oil seal
case
OIL PUMP OIL SEAL INSTALLATION
FRONT OIL SEAL INSTALLATION
(1) Using the special tool, install the crankshaft front seal
into the front case.
PUMP DRIVEN GEAR OIL PUMP DRIVE
GEAR INSTALLATION
Apply engine oil amply to the gears’ and line up align-
ment marks.
SEALANT APPLICATION TO OIL
GAUGE UNIT
(1) Coat the threads of switch with sealant and
the
switch using the special
Specified sealant: ATD Part No. 8660 or equivalent
Caution
1.Keep the end of threaded portion clear of sealant.
2. Avoid an
SEALANT APPLICATION TO OIL PRESSURE
SWITCH
(1) Coat the threads of switch with sealant and ins tall the
switch using the special tool.
Specified sealant: ATD Part or equivalent
Caution
1.Keep the end of threaded portion clear of
2. Avoid an overtightening.
TSB Revision
Page 151 of 2103
Front Case,, ENGINE OVERHAUL Shaft and ‘Pan
Phillips screwdriver
B O L T ,
(1) Phillips screwdriver hole in the left side
of the cylinder block to lock the counterbalance sh aft.
(2) Secure the oil pump driven gear onto the left c ounterbal-
ance shaft by tightening the flange bolt to specified torque.
PLUG INSTALLATION
(1) Install a new O-ring to the front case.
(2)Using the special tool, install the plug and tighten to speci-
fied torque.
TSB Revision
Page 152 of 2103
Front Case, ENGINE OVERHAUL Shaft and. Pan
Crank pulley side
8 mm bolts
Oil pan viewed from lower side
Drain pigasket
P A N .
(1) Clean both mating surfaces of and cylinder block.
(2) Apply a 4 mm in.) wide bead of to the entire
circumference of the oil pan flange.
Specified sealant:
MITSUBISHI GENUINE or
equivalent
NOTE. .
Be sure to install the oil pan quickly the sealant’
is wet (within 15 minutes);
(2) After installation, keep the sealed area
from,,
the oil and coolant for approx.
hour.
, .
(3) Note the difference in bolt lengths at the loca
tion
DRAIN PLUG GASKET INSTALLATION
Install the drain plug gasket in the direction show n in the
illustration.
OIL COOLER INSTALLATION
First insert the oil cooler projecting stopper in t he oil filter
bracket groove and then tighten the oil cooler
TSB Revision