Page 1369 of 2103
AUTOMATIC
PLANETARY ‘GEAR
DISASSEMBLY AND REASSEMBLY
parts with automatic
6
I
Disassembly steps
1. Thrust bearing
2.Rivet
3. Wave washer
4. One way clutch outer
race
. .
End
Planetarycarrier
P O I N T S ’
B E A R I N G
(1) the only one short not
and lose the 17 rollers in the not
the other short pinions.
.
T S B R e v i s i o n
Page 1370 of 2103
AUTOMATIC TRANSAXLE
Planetary Gear
RIVET REMOVAL
(1) Shift the stopper plate to ensure that the rivet head does
not hit it.
NOTE
Make sure that the stopper plate claw is not at
the groove in the one-way clutch outer race.
(2) Using a pin punch, drive out the
REASSEMBLY SERVICE
B E A R I N G
(1) Install a new thrust bearing car&r.. sure
that it fits correctly in the spot faced carrier..
(2) Apply unsparingly to the inside surface of the
short pinion and attach the 17 rollers on the
T S B R e v i s i o n
Page 1371 of 2103
A U T O M A T I C T R A N S A X L E ,
Rear thrustwasher
I
Notch
Arrow
Line up the holes of the
thrust washer “A” with the shaft of the carrier.
Install the short pinion,
washer and align the holes. Use care not to allow the
rollers to get out of position.
,
(5) Insert the pinion shaft. Make sure that the fla ttened end
of pinion shaft is correctly fitted in the hole of the rear
thrust plate when the pinion shafts is inserted.
ONE-WAY CLUTCH INSTALLATION:
(1) Push the one-way clutch into the sure
that arrow on the outside inside diameter of cage i s di-
rected upward as shown in the illustration when the
way clutch is pushed in.
WAVE WASHER INSTALLATION
(1) Install washer to the rivet so that its
is placed on the outer race
RIVET INSTALLATION
(1) Stake the rivet using a punch and press.
NOTE
(1) Use a punch with a tip angle.
(2) Stake the rivet with a load of 11
Ibs.).
TSB RevisionI
Page 1372 of 2103
AUTOMATIC TRANSAXLE
Gear and Transfer Drive Gear Set
GEAR AND TRANSFER DRIVE GEAR SET
DISASSEMBLY AND REASSEMBLY
8
Disassembly steps
1. Snap ring2. Stopper plate 3. Bearing 4. Bearing
.
5. drive
6. Snap ring7. Output flange8. gear
DISASSEMBLY SERVICE POINT
TRANSFER DRIVE GEAR REMOVAL
(1) Using the special tool, remove the transfer drive g ear
together with two bearings from
output flange.
Caution
Install the special tool in position between the ou tput
flange and bearings.
TSB Revision
Page 1373 of 2103
AUTOMATIC TRANSAXLE
and Drive Gear Set
(2) Using the special tool, remove the
sides of the transfer drive gear.
2
REASSEMBLY SERVICE POINTS
DRIVE GEAR BEARING
INSTALLATION
(1) Using the special tool, press-fit the bearings into both
sides of the transfer
gear.
(2) Using the special tool, install the transfer dr ive gear to
the output flange.
SNAP SELECTION
(1) Measure the snap ring groove ‘clearance and sel ect the
appropriate spacer to obtain the
end
S t a n d a r d v a l u e : m m i n . )
T S B R e v i s i o n
Page 1374 of 2103
AUTOMATIC TRANSAXLE
Differential
DIFFERENTIAL23300310063
DISASSEMBLY AND REASSEMBLY
8
parts with automatic,
Disassembly steps
1. Bolt2. Differential drive gear 3. Ball bearing 4. Taper roller bearing 5. Lock pin 6. Pinion shaft
Pinion 8. Washer 9 . S i d e g e a r 10. Spacer11. Differential case
DISASSEMBLY SERVICE POINTS
BEARING REMOVAL
(1) Using the special tool, remove the bearing.
TSBRevision
Page 1375 of 2103
AUTOMATIC TRANSAXLE
TSB
the
ROLLER BEARING’
(1) Using the special tool, remove the taper roller bearing.
P I N R E M O V A L
(1) Using a pin punch, drive out the lock pin.. .
The lock pin may be removed with
bunch.
REASSEMBLY SERVICE
S P A C E R
PINION INSTALLATION
(1) Fit the spacer to the back face of
gear, then
install the gear into the differential case.
(2) Fit a washer to back of the pinion two pinions
at the same time into position to gear.’
. . .
.
pinion’shaft.
.
(4) Measure the backlash between the side gear and pinion.
Standard
mm in.)
(5)If the backlash is out of specification, select the appropriate
spacer and disassemble and reassemble the gears as
necessary.
NOTE
Adjustso that the backlash inboth side gears equals.
Page 1376 of 2103
A U T O M A T I C
-Differential
2160030
(1) Align lock pin hole in pinion,
the case and install the ,
Caution,
1 . D o n o t r e u s e l o c k p i n s . ’
2. Make the lock pin lower than the
the
differential case flange.
3. Press-fitting load is over
ROLLER BEARING INSTALLATION
Using the special tool, the into both
sides of the differential case.
BEARING INSTALLATION
BOLTS INSTALLATION
(1) Apply ATF to the differential
gear bolts;
tighten to the specified the shown order.
Differential drive gear bolt: 135
(98
.
Revision