Page 905 of 1503
Component Location s
ProCarManuals.com
Page 906 of 1503
Page 907 of 1503
EPS Control Unit Terminal Arrangement
18P CONNECTOR
WIRE SIDE OF FEMALE TERMINALSProCarManuals.com
Page 908 of 1503
3P CONNECTOR (LEFT SIDE)
VB: Battery voltage
IG SW: Ignition switch
VB: Battery voltage
IG SW: Ignition switch
PULSE UNIT 7P CONNECTOR (MT)
6P CONNECTOR
3P CONNECTOR (RIGHT SIDE)ProCarManuals.com
Page 909 of 1503

Troubleshooting Precautions
EPS Indicator Light
Under normal conditions, the EPS indicator light in the gauge assembly comes on when the ignition switch is turned to
the ON (II) position, then goes off after the engine is started. This indicates that the bulb and its circuits are operating cor-
rectly. If there is any trouble in the system, the EPS indicator light turns on during driving, and the power steering assist is
turned off. When the EPS indicator light comes on, the control unit memorizes the DTC. In this case, the control unit does
not activate the EPS system after the engine starts again but it keeps the EPS indicator light on.
Diagnostic Trouble Code (DTC)
• The lowest DTC is indicated first.
• The DTCs continue blinking until the ignition switch is turned off.
• The DTCs are erased from the control unit when the EPS control unit VBU power supply or connector is disconnected.
• The EPS system can be reset and the control unit's memory can be erased by disconnecting the CLOCK (7.5 A) fuse for
more than ten seconds.
Self-diagnosis:
The CPU (central processing unit) controls the following when it detects a problem during self-diagnosis:
1. Turns the EPS indicator light ON to alert the driver.
2. Power assist stops, and normal manual steering operation resumes (except DTC 33).
3. The EPS control unit memorizes the diagnostic trouble code (DTC).
4. After the DTC is stored in the control unit, the CPU stops self-diagnosis.
Troubleshooting:
• Before starting the troubleshooting, clear the DTC by disconnecting the CLOCK (7.5 A) fuse for ten seconds or more,
and test-drive the car. Check that the symptom of the trouble appears again, and then troubleshoot.
• When both EPS indicator light and A/T "D" indicator light come on, perform the A/T troubleshooting first.
• When the customer's reported problem cannot be verified in the car, ask the customer about the conditions when the
EPS indicator light came ON, then test-drive the car under those conditions, if possible. If the EPS indicator light does
not come ON during the test, check for loose connections or poor contacts at the connectors by wiggling the harness,
etc.
• The connector terminal numbers are viewed from the wire side for the female terminals and from the terminal side for
the male terminals.
• After the repair, test-drive the car and check that the EPS indicator light does not come ON again during the test. (Refer
to the Symptom-to-System Chart for diagnostic period.)ProCarManuals.com
Page 910 of 1503
Diagnostic Troubl e Cod e (DTC ) Indicatio n
1. Connec t th e SC S servic e connecto r t o th e servic e chec k connecto r unde r th e glov e box .
2 . Tur n th e ignitio n switc h O N (II) , bu t d o no t star t th e engine .
3 . Recor d th e blinkin g frequenc y o f th e EP S indicato r light . Th e blinkin g frequenc y indicate s th e diagnosti c troubl e cod e
(DTC) .
NOTE : Chec k th e DT C carefull y an d recor d it . Th e memor y o f th e DT C is erase d i f th e connecto r i s disconnecte d fro m
th e EP S contro l unit .
SCS SERVIC E CONNECTO R07PAZ-001010 0
SERVICE CHEC KCONNECTO R (2P )
ProCarManuals.com
Page 911 of 1503
• Initia l diagnosis : Performe d righ t afte r th e engin e start s unti l th e EP S indicato r ligh t goe s off .
• Regula r diagnosis : Continuousl y performe d (unde r som e conditions ) afte r th e EP S indicato r ligh t goe s of f unti l th e
engin e stops .
• Individua l part/syste m diagnosis : Diagnose s a specifi c part/syste m unde r it s operatin g conditions .
• CPU : Centra l Processin g Unit .
17-27
17-29
17-3 6
17-3 1
17-36
17-3 8
Diagnosti c Troubl e Cod e (DTC )
Symptom-to-Syste m Char t
ProCarManuals.com
Page 912 of 1503
Troubleshooting
Hard Steerin g
Refer t o th e Symptom-to-Syste m
Char t (se e pag e 17-25 ).
Powe r Assis t Chec k wit h Ca r Parked :
Connec t a sprin g scal e t o th e steerin g whee l an d tur n th e
wheel . Rea d th e measuremen t whe n th e fron t wheel s star t
to move .
ProCarManuals.com