2011 FORD KUGA Workshop Manual

remote control compression ratio check transmission fluid carplay ESP inoperative brake pads replacement

Popular search:

Diesel climate control maintenance Power steering park aid pairing phone coolant temperature

Load previous 8 pages

Page 257 of 2057

FORD KUGA 2011 1.G Workshop Manual �(��
12mm
��6�S�H�F�L�D�O �7�R�R�O��V��
�(��
��
��
�*��H�Q�� .�X�J�D��
��

Page 258 of 2057

FORD KUGA 2011 1.G Workshop Manual �� R �Q�R�W �X�V�H �W�K�H �S�U�H�S�U�L�Q�W�H�G �F�X�W�O�L�Q�H�V��*�H�Q�H�U�D�O �(�T�X�L�S�P�H�Q�W� �)�O�D�W �)�L�O�H
�(��
�
� �
�
�[�
�� R �Q�R�W �X�V�H �W�K�H �S�U�H�S�U�L�

Page 259 of 2057

FORD KUGA 2011 1.G Workshop Manual �(��
�
�
� �
�[�
��
�*��H�Q�� .�X�J�D��
��
��
�3�D�U�N�L�Q�J �$�L�G
��
�5�(�0�2�9�$�/ �$�1� �,�1�6�7�$�/�/�$�7�,�2�

Page 260 of 2057

FORD KUGA 2011 1.G Workshop Manual ��
�*��H�Q�� .�X�J�D��
��
�3�D�U�N�L�Q�J �$�L�G
��
�5�(�0�2�9�$�/ �$�1� �,�1�6�7�$�/�/�$�7�,�2�1
�(��
�(��
T

Page 261 of 2057

FORD KUGA 2011 1.G Workshop Manual 7.
8.
Refer to: Rear Bumper Cover (501-19 Bumpers,
Removal and Installation). G1186710en
2008.50 Kuga 8/2011 413-13-62
Parking Aid
413-13-62
REMOVAL AND INSTALLATIONTO MODEL INDEX
BACK TO CHAPTER INDE

Page 262 of 2057

FORD KUGA 2011 1.G Workshop Manual SECTION 414-00 Charging System - General
Information
VEHICLE APPLICATION:
2008.50 Kuga
PAGE
CONTENTS
DIAGNOSIS AND TESTING
414-00-2
Charging System.....................................................

Page 263 of 2057

FORD KUGA 2011 1.G Workshop Manual Charging System
Refer to Wiring Diagrams Section 414-02, for
schematic and connector information.
General Equipment
Midtronics EXP-1050 battery tester
Midtronics GR590-2
Ford diagnostic equipment
Insp

Charging System
Refer to Wiring Diagrams Section 414-02, for
schematic and connector information.
General Equipment
Midtronics EXP-1050 battery tester
Midtronics GR590-2
Ford diagnostic equipment
Inspection and Verification
WARNINGS: Batteries contain sulphuric acid. Avoid
contact with skin, eyes, or clothing. Also,
shield your eyes when working near
batteries to protect against possible
splashing of the acid solution. In case of
acid contact with skin or eyes, flush
immediately with water for a minimum of
15 minutes and get prompt medical
attention. If acid is swallowed, call a
physician immediately. Failure to follow
these instructions may result in personal
injury.
Batteries normally produce explosive
gases which can cause personal injury.
Therefore, do not allow flames, sparks or
lighted substances to come near the
battery. When charging or working near a
battery, always shield your face and
protect your eyes. Always provide
ventilation. Failure to follow these
instructions may result in personal injury.
1. Verify the customer concern.
2. Visually inspect for obvious signs of mechanical
or electrical damage.
Visual Inspection Chart Electrical
Mechanical
– Fuse(s)
– Wiring harness(es)
– Generator
– Electricalconnector(s)
– Battery junction box (BJB)
– Battery
– Battery cables
– Battery monitoring sensor (BMS)
– Charging system warning indicator
–
Accessory drive belt
– Generator
3. If an obvious cause for an observed or reported concern is found, correct the cause (if possible)
before proceeding to the next step.
4. Check the operation of the charging system warning indicator lamp, located in the instrument
cluster. Normal operation is as follows:
Normal Charging System Voltages Charging System
Warning Indicator Operation
Engine to
battery ground
Battery
Gener-
ator B+ Circuit
I Circuit
Ignition Switch
Position
OFF
0V
10-12V
10-12V
0V
Position 0
Illuminated
0V
10-12V
10-12V
0V
Position II
OFF
0V
13-15V
13-15V
13-15V
Position II with
the engine
running
5. If the cause is not visually evident, verify the symptom and refer to the Component Tests. Component Tests
Generator On-Vehicle Tests - No-Load Test
1. Turn off all electrical loads and the ignition
switch. G1055063en
2008.50 Kuga 8/2011 414-00-2
Charging System - General Information
414-00-2
DIAGNOSIS AND TESTINGTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL

Page 264 of 2057

FORD KUGA 2011 1.G Workshop Manual 2. Switch the multimeter to the voltage function.
3. Connect the leads of the multimeter across the
battery terminals.
4. Read the voltage (base voltage).
5. Start the engine.
6. Run the engine at 150

Load next 8 pages

Page: < prev 1-10 ... 225-232 233-240 241-248 249-256 257-264 265-272 273-280 281-288 289-296 ... 2064 next >

coolant capacity fuse box location wheel winter tires steering wheel catalytic converter

Popular search:

Starting starter Interior trim brake rotor power steering fluid tire type oil pressure