2003 DAEWOO MATIZ Service Repair Manual

BODY FRONT END 9R–11
DAEWOO M-150 BL2
D19C544A
11. Remove the bolts along the top of the fender.
a. Bolt.
12. Remove the fender.
b. Fender.
D19C527A
Installation Procedure
1. Install the fender.
Notice: Dissimilar metals in direct contact with each
other may corrode rapidly. Make sure to use the correct
fasteners to prevent premature corrosion.
2. Install the bolts along the top of the fender.
D19C545A
3. Install the front bumper spacer.
4. Install the cowl vent grille.
5. Raise and suitably support the vehicle.
6. Install the bolts under the fender.
7. Install the screws on the side of the front bumper
fascia.
8. Open the front door Install the bolt on the A–pillar.
9. Install the bolt at the base of the fender.
10. Install the wheelhouse splash shield with the
screws.
11. Lower the vehicle.

DAEWOO M-150 BL2
SECTION 9S
BODY REAR END
TABLE OF CONTENTS
Description and Operation 9S-2. . . . . . . . . . . . . . . . . .
Fuel Filler Door 9S-2. . . . . . . . . . . . . . . . . . . . . . . . . . .
Repair Instructions 9S-3. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 9S-3. . . . . . . . . . . . . . . . . . . . . . . . . . Fuel Filler Door 9S-3. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filler Door Remote Cable and Handle 9S-3. . . .
Tailgate Remote Cable and Handle 9S-5. . . . . . . . . .

9S – 2 BODY REAR END
DAEWOO M-150 BL2
DESCRIPTION AND OPERATION
FUEL FILLER DOOR
The fuel filler door attaches to the fuel tank pocket on the
right side of the vehicle.

BODY REAR END 9S–3
DAEWOO M-150 BL2
REPAIR INSTRUCTIONS
ON–VEHICLE SERVICE
D109C546
FUEL FILLER DOOR
Removal Procedure
1. Pull the fuel filler door opening lever and open the fuel
filler door.
2. Remove the fuel filler door.

Remove the bolts (1).

Remove the fuel filler door (2).
D109C547
Installation Procedure
1. Install the fuel filler door with the bolts.
D109C548
FUEL FILLER DOOR REMOTE CABLE
AND HANDLE
(Left–Hand Drive Shown, Right–Hand
Drive Similar)
Removal Procedure
1. Pry off the front rocker trim panel. Refer to Section
9G, Interior Trim.
2. Remove the fuel filler door remote handle.

Remove the screws (1).

Disconnect the cable (2).

Remove the fuel filler door remote handle (3).

9S –4 BODY REAR END
DAEWOO M-150 BL2
D109C549
3. Pry off the lower B–pillar trim panel. Refer to Section
9G, Interior Trim.
4. Pry off the rear rocker trim panel. Refer to Section to
9G, Interior Trim.
5. Pry off the luggage compartment wheelhouse trim
panel. Refer to Section to 9G, Interior Trim.
6. Remove the lock striker of the fuel filler.

Remove the lock striker by turning it rectangularly.
a. Lock striker
D19C550B
7. Remove the fuel filler door remote cable.

Remove the cable retaining strip.

Disconnect the fuel filler door remote cable (1).
D19C550C
Installation Procedure
1. Connect the fuel filler door remote cable to the fuel
filler door.
2. Retain the cable with the strip.
D19C549A
3. Install the lock striker of the fuel filler.
4. Install the luggage compartment wheelhouse trim
panel. Refer to Section 9G, Interior Trim.
5. Install the rear rocker trim panel. Refer to Section 9G,
Interior Trim.
6. Install the lower B–pillar trim panel. Refer to Section
9G, Interior Trim.

BODY REAR END 9S–5
DAEWOO M-150 BL2
D109C551
7. Connect the fuel filler door remote cable to the han-
dle.
8. Install the fuel filler door remote handle with the
screws.
D109C548
TAILGATE REMOTE CABLE AND
HANDLE
(Left–Hand Drive Shown, Right–Hand
Drive Similar)
Removal Procedure
1. Pry off the front rocker trim panel. Refer to Section
9G, Interior Trim.
2. Remove the tailgate remote handle.

Remove the screws (1).

Disconnect the cable (2).

Remove the tailgate remote handle (3).
D19C633A
3. Pry off the lower B–pillar trim panel. Refer to Section
9G, Interior Trim.
4. Pry off the rear rocker trim panel. Refer to Section
9G, Interior Trim.
5. Pry off the luggage compartment wheelhouse trim
panel. Refer to Section 9G, Interior Trim.
6. Disconnect the cable from the tailgate lock striker.
Refer to Section 9P, Doors.
7. Remove the tailgate remote cable.

Remove the cable retaining strip.

Disconnect the tailgate remote cable (1).
D109C551
Installation Procedure
1. Connect the tailgate remote cable to the tailgate lock
striker.
2. Retain the cable with the strip.
3. Install the luggage compartment wheelhouse trim
panel. Refer to Section 9G, Interior Trim.
4. Install the rear rocker trim panel. Refer to Section 9G,
Interior Trim.
5. Install the lower B–pillar trim panel. Refer to Section
9G, Interior Trim.
6. Connect the tailgate remote cable to the handle.
7. Install the tailgate remote handle with the screws.

REMOTE KEYLESS ENTRY AND ANTI–THEFT SYSTEM 9T – i
DAEWOO M-150 BL2
SECTION 9T
REMOTE KEYLESS ENTRY AND
ANTI-THEFT SYSTEM
TABLE OF CONTENTS
Description and Operation 9T-2. . . . . . . . . . . . . . . . . .
Remote Keyless Entry and
Anti-Theft System 9T-2. . . . . . . . . . . . . . . . . . . . . . .
Remote Locking and Unlocking 9T-2. . . . . . . . . . . . . .
Security Indicator 9T-2. . . . . . . . . . . . . . . . . . . . . . . . . .
Intrusion Sensing 9T-2. . . . . . . . . . . . . . . . . . . . . . . . . .
Siren 9T-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle Locator 9T-2. . . . . . . . . . . . . . . . . . . . . . . . . . .
Autolocking (Safety Lock) 9T-3. . . . . . . . . . . . . . . . . .
Control Module/Receiver 9T-3. . . . . . . . . . . . . . . . . . . Repair Instructions 9T-4. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 9T-4. . . . . . . . . . . . . . . . . . . . . . . . . .
Siren 9T-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Password Programming 9T-5. . . . . . . . . . . . . . . . . . . .
Specifications 9T-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 9T-6. . . . . . . . . . .
Schematic and Routing Diagrams 9T-7. . . . . . . . . . .
Remote Keyless Entry and
Anti-Theft System 9T-7. . . . . . . . . . . . . . . . . . . . . . .
IMMOBILIZER ANTI-THEFT SYSTEM
TABLE OF CONTENTS
Description and Operation 9T-10. . . . . . . . . . . . . . . . .
Immobilizer System 9T-10. . . . . . . . . . . . . . . . . . . . . . .
Electronically Coded Keys 9T-10. . . . . . . . . . . . . . . . .
Detection Coil 9T-10. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Immobilizer Control Unit 9T-10. . . . . . . . . . . . . . . . . . .
Serial Data Link 9T-11. . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Control Module (ECM) 9T-11. . . . . . . . . . .
Security Indicator 9T-12. . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 9T-13. . . .
Immobilizer System (FENIX 5MR) 9T-13. . . . . . . . . .
Immobilizer System (SIRIUS D3) 9T-13. . . . . . . . . . .
DTC 1600 ECM Immobilizer Error
(No Answer) 9T-14. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC 1601 ECM Immobilizer Error
(Incorrect Answer) 9T-16. . . . . . . . . . . . . . . . . . . . . .
DTC 1602 ECM Immobilizer Error
(ECM Locked) 9T-18. . . . . . . . . . . . . . . . . . . . . . . . .
P1628 ECM Immobilizer Error 9T-20. . . . . . . . . . . . . .
P1629 ECM Immobilizer Error 9T-22. . . . . . . . . . . . . . Key Status Errors (FENIX 5MR) 9T-24. . . . . . . . . . . .
Key Status Errors (SIRIUS D3) 9T-24. . . . . . . . . . . . .
Communication Between Immobilizer and
Test Equipment (FENIX 5MR) 9T-25. . . . . . . . . . . .
Communication Between Immobilizer and
Test Equipment (SIRIUS D3) 9T-25. . . . . . . . . . . . .
Repair Instructions 9T-26. . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 9T-26. . . . . . . . . . . . . . . . . . . . . . . . .
Key Coding Procedure 9T-26. . . . . . . . . . . . . . . . . . . .
ID Code Reprogramming 9T-26. . . . . . . . . . . . . . . . . .
Transponder 9T-27. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Detection Coil 9T-27. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Immobilizer Control Unit 9T-28. . . . . . . . . . . . . . . . . . .
Specifications 9T-30. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 9T-30. . . . . . . . . .
Schematic and Routing Diagrams 9T-31. . . . . . . . . .
Immobilizer Anti-Theft System 9T-31. . . . . . . . . . . . .
Remote Keyless Entry and Immobilizer
Anti-theft System 9T-32. . . . . . . . . . . . . . . . . . . . . . .

9T–ii REMOTE KEYLESS ENTRY AND ANTI–THEFT SYSTEM
DAEWOO M-150 BL2
BLANK