1999 DODGE RAM Service Repair Manual

wiper fluid alternator lane assist low beam fuel cap center console

Popular search:

air filter adding oil 2500 diesel headlight bulb tire type battery location tire pressure

Load previous 8 pages

Page 1121 of 1691

$DODGE RAM 1999 Service Repair Manual Engine 5.9L: Drained 20 Qts. (19L) Coolant \ \ \ \ \$

Engine 5.9L: Drained 20 Qts. (19L)

Coolant
\
\
\

\
\

8.0L: Drained 24 Qts. (22.7L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

18,000 MILE (29,000 KM) SEVERE DUTY SERVICE
18,000 MILE (29,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter (
1)

\
\
\
\
\
\
\

(
1) 8.0L: Change oil filter at every oil change.

5.9L: If mileage is less than 6,000 miles (9,600 Km) Yearly,

replace the oil filter at every oil change.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 0 F SAE 10W-30

(
1) (-18C) To Over 100F (38C)

\
\
\

\
\

Ambient Temperature Less Than SAE 5W-30

-20F (-29C) Up To 32F (0C)

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

Page 1122 of 1691

$DODGE RAM 1999 Service Repair Manual \ \b\ \ \ \b\ \ \ Item Condition$

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil 5.9L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

8.0L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

5.9L: Drained 4.5 Qts. (4.2L)

\

\
\
\

\
\
\

Engine 5.9L: Drained 20 Qts. (19L)

Coolant
\
\
\

\
\

8.0L: Drained 24 Qts. (22.7L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

21,000 MILE (34,000 KM) SEVERE DUTY SERVICE
21,000 MILE (34,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Rotate Tires

\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter (
1)

\
\
\
\
\
\
\

(
1) 8.0L: Change oil filter at every oil change.

5.9L: If mileage is less than 6,000 miles (9,600 Km) Yearly,

replace the oil filter at every oil change.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 0 F SAE 10W-30

(
1) (-18C) To Over 100F (38C)

\
\
\

\
\

Ambient Temperature Less Than SAE 5W-30

-20F (-29C) Up To 32F (0C)

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

Page 1123 of 1691

$DODGE RAM 1999 Service Repair Manual \ \ \ \ \ \ \ Brake Fluid All $

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil 5.9L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

8.0L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

5.9L: Drained 4.5 Qts. (4.2L)

\

\
\
\

\
\
\

Engine 5.9L: Drained 20 Qts. (19L)

Coolant
\
\
\

\
\

8.0L: Drained 24 Qts. (22.7L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

24,000 MILE (38,000 KM) SEVERE DUTY SERVICE
24,000 MILE (38,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

Front Wheel Bearings (4x2)

\
\
\
\
\
\
\

Brake Linings

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

Automatic Transmission Bands

\
\
\
\
\
\
\

Clean & Relubricate Crankcase Inlet Air Filter (5.9L)

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter (
1)

\
\
\
\
\
\
\

Page 1124 of 1691

$DODGE RAM 1999 Service Repair Manual Automatic Transmission Fluid & Filter \ \ \ \ \ \$

Automatic Transmission Fluid & Filter

\
\
\
\
\
\
\

Rear Axle Fluid

\
\
\
\
\
\
\

Front Axle Fluid (4x4)

\
\
\
\
\
\
\

Engine Air Cleaner & Air Pump Filters

\
\
\
\
\
\
\

(
1) 8.0L: Change oil filter at every oil change.

5.9L: If mileage is less than 6,000 miles (9,600 Km) Yearly,

replace the oil filter at every oil change.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 0 F SAE 10W-30

(
1) (-18C) To Over 100F (38C)

\
\
\

\
\

Ambient Temperature Less Than SAE 5W-30

-20F (-29C) Up To 32F (0C)

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\

\
\
\

\
\
\

Automatic All ATF+2 Type 7176

Transmission

Fluid

\

\
\
\

\
\
\

Rear Axle All Mopar Hypoid Lubricant

Lubricant SAE 80W-90

(
2) GL-5 Gear Lube

\

\
\
\

\
\
\

4x4 Front All Mopar Hypoid Lubricant

Axle SAE 80W-90

Lubricant GL-5 Gear Lube

\

\
\
\

\
\
\

Wheel Bearing All High Temperature Multi-

Grease -Purporse EP Grease

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

(
2) - Axles with Limited-Slip Differentials require the use of

a 5% Friction Modifier, such as Mopar Gear Oil Additive

Friction Modifier.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil 5.9L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

8.0L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

5.9L: Drained 4.5 Qts. (4.2L)

\

\
\
\

\
\
\

Page 1125 of 1691

$DODGE RAM 1999 Service Repair Manual Engine 5.9L: Drained 20 Qts. (19L) Coolant \ \ \ \ \$

Engine 5.9L: Drained 20 Qts. (19L)

Coolant
\
\
\

\
\

8.0L: Drained 24 Qts. (22.7L)

\

\
\
\

\
\
\

Automatic 46RE: Dry Fill 1726 Pts. (812.3L)

Transmission
\
\
\

\
\

Fluid 47RE: Dry Fill 1733 Pts. (815.6L)

\

\
\
\

\
\
\

Rear Axle 9-1/4: Drained 4.8 Pts. (2.3L)

Fluid
\
\
\

\
\

Model 248 (2WD) 6.3 Pts. (3L)

\
\
\

\
\

Model 248 (4WD) 7.3 Pts. (3.4L)

\
\
\

\
\

Model 267 (2WD) 7 Pts. (3.3L)

\
\
\

\
\

Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\

\
\

Model 286 (2WD) 6.8.Pts. (3.2L)

\
\
\

\
\

Model 286 (4WD) 10.1 Pts. (4.8L)

\

\
\
\

\
\
\

Rear Axle Model 248 (2WD) 6.3 Pts. (3L)

Limited Slip
\
\
\

\
\

Differential Model 248 (4WD) 7.3 Pts. (3.4L)

\
\
\

\
\

Model 267 (2WD) 7 Pts. (3.3L)

\
\
\

\
\

Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\

\
\

Model 286 (2WD) 6.8 Pts. (3.2L)

\
\
\

\
\

Model 286 (4WD) 10.1 Pts. (4.8L)

\

\
\
\

\
\
\

Front Axle Model 216 6.8 Pts. (3.6L)

Lubricant
\
\
\

\
\

Model 248 7.6 Pts. (3.6L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

27,000 MILE (43,000 KM) SEVERE DUTY SERVICE
27,000 MILE (43,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Rotate Tires

\
\
\
\
\
\
\

Page 1126 of 1691

$DODGE RAM 1999 Service Repair Manual Lubricate Steering Linkage \ \ \ \ \ \$

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter (
1)

\
\
\
\
\
\
\

(
1) 8.0L: Change oil filter at every oil change.

5.9L: If mileage is less than 6,000 miles (9,600 Km) Yearly,

replace the oil filter at every oil change.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 0 F SAE 10W-30

(
1) (-18C) To Over 100F (38C)

\
\
\

\
\

Ambient Temperature Less Than SAE 5W-30

-20F (-29C) Up To 32F (0C)

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil 5.9L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

8.0L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

5.9L: Drained 4.5 Qts. (4.2L)

\

\
\
\

\
\
\

Engine 5.9L: Drained 20 Qts. (19L)

Coolant
\
\
\

\
\

8.0L: Drained 24 Qts. (22.7L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

30,000 MILE (48,000 KM) SEVERE DUTY SERVICE
30,000 MILE (48,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

Page 1127 of 1691

$DODGE RAM 1999 Service Repair Manual \b\ \ \ \ \ \ \ Exhaust System$

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

PCV Valve (5.9L)

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter (
1)

\
\
\
\
\
\
\

Spark Plugs

\
\
\
\
\
\
\

(
1) 8.0L: Change oil filter at every oil change.

5.9L: If mileage is less than 6,000 miles (9,600 Km) Yearly,

replace the oil filter at every oil change.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 0 F SAE 10W-30

(
1) (-18C) To Over 100F (38C)

\
\
\

\
\

Ambient Temperature Less Than SAE 5W-30

-20F (-29C) Up To 32F (0C)

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil 5.9L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

8.0L: Drained, W/New Filter 5 Qts. (4.7L)

\
\
\

\
\

5.9L: Drained 4.5 Qts. (4.2L)

\

\
\
\

\
\
\

Engine 5.9L: Drained 20 Qts. (19L)

Coolant
\
\
\

\
\

8.0L: Drained 24 Qts. (22.7L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

Page 1128 of 1691

$DODGE RAM 1999 Service Repair Manual dipstick (if available) to measure level. \f \ \ \ \ \ \$

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

33,000 MILE (53,000 KM) SEVERE DUTY SERVICE
33,000 MILE (53,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Rotate Tires

\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter (
1)

\
\
\
\
\
\
\

(
1) 8.0L: Change oil filter at every oil change.

5.9L: If mileage is less than 6,000 miles (9,600 Km) Yearly,

replace the oil filter at every oil change.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 0 F SAE 10W-30

(
1) (-18C) To Over 100F (38C)

\
\
\

\
\

Ambient Temperature Less Than SAE 5W-30

-20F (-29C) Up To 32F (0C)

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Load next 8 pages

Page: < prev 1-10 ... 1089-1096 1097-1104 1105-1112 1113-1120 1121-1128 1129-1136 1137-1144 1145-1152 1153-1160 ... 1696 next >

air suspension night vision phone seats navigation change wheel

Popular search:

stop start run flat airbag off airbag disable CD changer tires tire type