1999 DODGE RAM Service Repair Manual

warning light seats timing belt cooling oil filter bluetooth

Page 1065 of 1691

$DODGE RAM 1999 Service Repair Manual \ \ \ \ \ \ \ Rear Axle DANA 70 Model 267 (2WD) $

\

\
\
\

\
\
\

Rear Axle DANA 70 Model 267 (2WD) 7 Pts. (3.3L)

Lubricant
\
\
\

\
\

DANA 70 Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\

\
\

DANA 80 Model 286 (2WD) 6.8.Pts. (3.2L)

\
\
\

\
\

DANA 80 Model 286 (4WD) 10.1 Pts. (4.8L)

\

\
\
\

\
\
\

Rear Axle Model 267 (2WD) 7 Pts. (3.3L)

Limited Slip
\
\
\

\
\

Differential Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\

\
\

Model 286 (2WD) 6.8 Pts. (3.2L)

\
\
\

\
\

Model 286 (4WD) 10.1 Pts. (4.8L)

\

\
\
\

\
\
\

Front Axle Model 248 7.6 Pts. (3.6L)

Lubricant

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

27,000 MILE (43,000 KM) SEVERE DUTY SERVICE
27,000 MILE (43,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 10F SAE 15W-40

(
1) (-12C) To Over 30F (-1C)

\
\
\

\
\

Ambient Temperature Less Than SAE 10W-30

0F (-18C) To Over 30F(-1C)

\
\
\

\
\

Ambient Temperature Less Than With Block Heater:

-10F(-23C) Up To 0F (-18C) SAE 10W-30

Page 1066 of 1691

$DODGE RAM 1999 Service Repair Manual Without Block Heater: SAE 5W-30 \ \$

Without Block Heater:

SAE 5W-30

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil Capacity, Upper Safe Mark 10 Qts. (9.5L)

\
\
\

\
\

Capacity, Lower Safe Mark 8 Qts. (7.5L)

\

\
\
\

\
\
\

Engine Drained 26 Qts. (24.5L)

Coolant

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

30,000 MILE (48,000 KM) SEVERE DUTY SERVICE
30,000 MILE (48,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Rotate Tires

\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

Clean Fuel Strainer

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter

\
\
\
\
\
\
\

Fuel Filter

Page 1067 of 1691

$DODGE RAM 1999 Service Repair Manual \ \ \ \ \ \ \ LUBRICATION SPECIFICATIONS$

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 10F SAE 15W-40

(
1) (-12C) To Over 30F (-1C)

\
\
\

\
\

Ambient Temperature Less Than SAE 10W-30

0F (-18C) To Over 30F(-1C)

\
\
\

\
\

Ambient Temperature Less Than With Block Heater:

-10F(-23C) Up To 0F (-18C) SAE 10W-30

Without Block Heater:

SAE 5W-30

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil Capacity, Upper Safe Mark 10 Qts. (9.5L)

\
\
\

\
\

Capacity, Lower Safe Mark 8 Qts. (7.5L)

\

\
\
\

\
\
\

Engine Drained 26 Qts. (24.5L)

Coolant

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

33,000 MILE (53,000 KM) SEVERE DUTY SERVICE
33,000 MILE (53,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Page 1068 of 1691

$DODGE RAM 1999 Service Repair Manual Lubricate Steering Linkage \ \ \ \ \ \$

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 10F SAE 15W-40

(
1) (-12C) To Over 30F (-1C)

\
\
\

\
\

Ambient Temperature Less Than SAE 10W-30

0F (-18C) To Over 30F(-1C)

\
\
\

\
\

Ambient Temperature Less Than With Block Heater:

-10F(-23C) Up To 0F (-18C) SAE 10W-30

Without Block Heater:

SAE 5W-30

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred for use in all Dodge

trucks. Use only API approved oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil Capacity, Upper Safe Mark 10 Qts. (9.5L)

\
\
\

\
\

Capacity, Lower Safe Mark 8 Qts. (7.5L)

\

\
\
\

\
\
\

Engine Drained 26 Qts. (24.5L)

Coolant

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

36,000 MILE (58,000 KM) SEVERE DUTY SERVICE
36,000 MILE (58,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

Page 1069 of 1691

$DODGE RAM 1999 Service Repair Manual \ \ \ \ \ \ \ Brake Hoses$

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

Brake Linings

\
\
\
\
\
\
\

Drive Belts

\
\
\
\
\
\
\

Water Pump Weep Hole For Blockage

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Rotate Tires

\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

Automatic Transmission Bands

\
\
\
\
\
\
\

Clean Fuel Strainer

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter

\
\
\
\
\
\
\

Automatic Transmission Fluid & Filter

\
\
\
\
\
\
\

Rear Axle Fluid

\
\
\
\
\
\
\

Front Axle Fluid (4x4)

\
\
\
\
\
\
\

Transfer Case Fluid

\
\
\
\
\
\
\

Fuel Filter

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 10F SAE 15W-40

(
1) (-12C) To Over 30F (-1C)

\
\
\

\
\

Ambient Temperature Less Than SAE 10W-30

0F (-18C) To Over 30F(-1C)

\
\
\

\
\

Ambient Temperature Less Than With Block Heater:

-10F(-23C) Up To 0F (-18C) SAE 10W-30

Without Block Heater:

SAE 5W-30

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\

\
\
\

\
\
\

Automatic All ATF+2 Type 7176

Page 1070 of 1691

$DODGE RAM 1999 Service Repair Manual Transmission Fluid \ \$

Transmission

Fluid

\

\
\
\

\
\
\

Transfer Case All ATF+2 Type 7176

Fluid Or DEXRON III ATF

\

\
\
\

\
\
\

Rear Axle All Mopar Hypoid Lubricant

Lubricant SAE 80W-90

(
2) GL-5 Gear Lube

\

\
\
\

\
\
\

4x4 Front All Mopar Hypoid Lubricant

Axle SAE 80W-90

Lubricant GL-5 Gear Lube

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred. Use only API approved

oil with Starburst Symbol.

(
2) - Axles with Limited-Slip Differentials require the use of

a 5% Friction Modifier, such as Mopar Gear Oil Additive

Friction Modifier.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil Capacity, Upper Safe Mark 10 Qts. (9.5L)

\
\
\

\
\

Capacity, Lower Safe Mark 8 Qts. (7.5L)

\

\
\
\

\
\
\

Engine Drained 26 Qts. (24.5L)

Coolant

\

\
\
\

\
\
\

Automatic 46RE: Dry Fill 17 Qts. (16L)

Transmission
\
\
\

\
\

Fluid 47RE: Dry Fill 17 Qts. (16L)

\

\
\
\

\
\
\

Rear Axle DANA 70 Model 267 (2WD) 7 Pts. (3.3L)

Lubricant
\
\
\

\
\

DANA 70 Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\

\
\

DANA 80 Model 286 (2WD) 6.8.Pts. (3.2L)

\
\
\

\
\

DANA 80 Model 286 (4WD) 10.1 Pts. (4.8L)

\

\
\
\

\
\
\

Rear Axle Model 267 (2WD) 7 Pts. (3.3L)

Limited Slip
\
\
\

\
\

Differential Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\

\
\

Model 286 (2WD) 6.8 Pts. (3.2L)

\
\
\

\
\

Model 286 (4WD) 10.1 Pts. (4.8L)

\

\
\
\

\
\
\

Front Axle Model 248 7.6 Pts. (3.6L)

Lubricant

\

\
\
\

\
\
\

Transfer Case NV241 5 Pts. (2.7L)

Fluid
\
\
\

\
\

NV241 HD 6.5 Pts. (3.5L)

\
\
\

\
\

NV241 HD W/PTO 9 Pts. (4.9L)

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

Page 1071 of 1691

$DODGE RAM 1999 Service Repair Manual 39,000 MILE (62,000 KM) SEVERE DUTY SERVICE 39,000 MILE (62,000 KM) SEVERE DUTY SERVICE\ \ \ \ \$

39,000 MILE (62,000 KM) SEVERE DUTY SERVICE
39,000 MILE (62,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 10F SAE 15W-40

(
1) (-12C) To Over 30F (-1C)

\
\
\

\
\

Ambient Temperature Less Than SAE 10W-30

0F (-18C) To Over 30F(-1C)

\
\
\

\
\

Ambient Temperature Less Than With Block Heater:

-10F(-23C) Up To 0F (-18C) SAE 10W-30

Without Block Heater:

SAE 5W-30

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\

(
1) - SAE 10W-30 engine oil is preferred for use in all Dodge

trucks. Use only API approved oil with Starburst Symbol.

\
\
\
\
\
\
\

FLUID CAPACITIES

\
\b\
\
\
\b\
\
\

Item Condition Specification (1)

\

\
\
\

\
\
\

Engine Oil Capacity, Upper Safe Mark 10 Qts. (9.5L)

\
\
\

\
\

Capacity, Lower Safe Mark 8 Qts. (7.5L)

Page 1072 of 1691

$DODGE RAM 1999 Service Repair Manual \ \ \ \ \ \ \ Engine Drained $

\

\
\
\

\
\
\

Engine Drained 26 Qts. (24.5L)

Coolant

\
\
\
\
\
\
\

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.
\f
\
\
\
\
\
\
\

42,000 MILE (67,000 KM) SEVERE DUTY SERVICE
42,000 MILE (67,000 KM) SEVERE DUTY SERVICE\
\
\
\
\
\
\

VERIFY

\b\
\
\
\
\
\
\

Last Major Service Was Performed.

\
\
\
\
\
\
\

INSPECT

\b\
\
\
\
\
\
\

Exhaust System

\
\
\
\
\
\
\

Brake Hoses

\
\
\
\
\
\
\

Engine Coolant Level, Hoses & Clamps

\
\
\
\
\
\
\

SERVICE

\b\
\
\
\
\
\
\

Rotate Tires

\
\
\
\
\
\
\

Lubricate Steering Linkage

\
\
\
\
\
\
\

Clean Fuel Strainer

\
\
\
\
\
\
\

REPLACE

\b\
\
\
\
\
\
\

Engine Oil

\
\
\
\
\
\
\

Engine Oil Filter

\
\
\
\
\
\
\

Fuel Filter

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS

\
\b\
\
\
\b\
\
\

Material Condition Specification

\

\
\
\

\
\
\

Engine Oil Ambient Temperature Above 10F SAE 15W-40

(
1) (-12C) To Over 30F (-1C)

\
\
\

\
\

Ambient Temperature Less Than SAE 10W-30

0F (-18C) To Over 30F(-1C)

\
\
\

\
\

Ambient Temperature Less Than With Block Heater:

-10F(-23C) Up To 0F (-18C) SAE 10W-30

Without Block Heater:

SAE 5W-30

\

\
\
\

\
\
\

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\

\
\
\

\
\
\

Brake Fluid All DOT 3

\

\
\
\

\
\
\

Steering All Mopar Multi-Mileage

Load next 8 pages

Page: < prev 1-10 ... 1033-1040 1041-1048 1049-1056 1057-1064 1065-1072 1073-1080 1081-1088 1089-1096 1097-1104 ... 1696 next >

hood open light fuel jump start airbag cruise control