1996 CHRYSLER VOYAGER Service Manual

service interval seats oil pressure tire pressure bluetooth brake

Load previous 8 pages

Page 873 of 1938

CHRYSLER VOYAGER 1996 Service Manual DB/WT22 C34
5P30
J01D
HVAC
CONTROL
C1
CONTROL A/C
12
1
ACTUATOR DOOR
MODE
JS03
C34
20
DB/WT
DB/WT20 C34DB/WT20 C34
BLEND
DOOR
ACTUATOR
5
C34
20
DB/WT
RECIRCULATION
DOOR
ACTUATOR
1
K7
18
OR
1
OR18 K7
O

Page 874 of 1938

CHRYSLER VOYAGER 1996 Service Manual SENSOR TEMPERATURE
EVAPORATOR
24
ACTUATOR
DOOR
MODE
BLEND
DOOR
ACTUATOR
42
ACTUATOR DOOR
ZONE
DB/GY20 C57
C57
20
DB/GY
DB/GY20 C57DB/GY20 C57
JS01B
ACTUATOR DOOR
BLEND
MODE
DOOR
ACTUATOR
224
C57
20
DB

Page 875 of 1938

CHRYSLER VOYAGER 1996 Service Manual BK/LB20 K4BK/LB20 K4BK/LB20 K4
BK/LB18 K4
BK/LB20 K4
33
MODULE CONTROL
POWERTRAIN
SENSOR
POSITION
PEDAL
ACCELERATOR
3
A/C
PRESSURE
TRANSDUCER
1
(DIESEL) BS34
6E97
B106
2
SENSOR SPEED
VEHICLE
ENGINE
CO

Page 876 of 1938

Page 877 of 1938

CHRYSLER VOYAGER 1996 Service Manual 8W-80 CONNECTOR PIN-OUTS
Component Page
A/C Heater Control - C1................8W-80-5
A/C Heater Control - C2................8W-80-5
A/C Compressor Clutch.................8W-80-5
A/C Pressure Transdu

8W-80 CONNECTOR PIN-OUTS
Component Page
A/C Heater Control - C1................8W-80-5
A/C Heater Control - C2................8W-80-5
A/C Compressor Clutch.................8W-80-5
A/C Pressure Transducer (Gas)...........8W-80-6
A/C Pressure Transducer (Diesel).........8W-80-6
A/C Zone Door Actuator.................8W-80-6
Accelerator Pedal Position Sensor (Diesel) . .8W-80-6
Airbag Control Module - C1.............8W-80-6
Airbag Control Module - C2.............8W-80-7
All Wheel Drive Solenoid - C1............8W-80-7
All Wheel Drive Solenoid - C2............8W-80-7
Ambient Air Temperature Sensor.........8W-80-7
Ash Receiver Lamp (LHD)...............8W-80-8
Ash Receiver Lamp (RHD)..............8W-80-8
Automatic Day/Night Mirror.............8W-80-8
B09 HS5D...........................8W-80-9
B09S02.............................8W-80-9
B13AW4............................8W-80-9
B17 LJ01............................8W-80-9
B23P18............................8W-80-10
B23P34............................8W-80-11
B33 E120...........................8W-80-12
B33E36............................8W-80-12
B56 HS5P..........................8W-80-12
B56S02............................8W-80-12
B70E43............................8W-80-13
B75C20............................8W-80-13
B98T08............................8W-80-14
B99T05............................8W-80-14
Back-Up Switch......................8W-80-14
Blend Door Actuator..................8W-80-14
Body Control Module - C1..............8W-80-15
Body Control Module - C2..............8W-80-16
Brake Pressure Switch................8W-80-16
C19EC1 ...........................8W-80-17
Camshaft Position Sensor..............8W-80-17
Center Dome Lamp...................8W-80-17
Center High Mounted Stop Lamp........8W-80-17
Clockspring - C1.....................8W-80-18
Clockspring - C2.....................8W-80-18
Clutch Interlock Switch................8W-80-18
Clutch Interlock Switch Jumper.........8W-80-18
Clutch Switch.......................8W-80-18
Controller Anti-Lock Brake.............8W-80-19
Crank Case Heater...................8W-80-19
Crankshaft Position Sensor.............8W-80-19
D01D B02..........................8W-80-20
D01P B03..........................8W-80-20
D02B01 ...........................8W-80-20
D02 B120 (LHD).....................8W-80-21
D02 B120 (RHD).....................8W-80-21
Data Link Connector..................8W-80-22Component Page
Downstream Heated Oxygen Sensor......8W-80-22
Driver Door Arm/Disarm Switch.........8W-80-22
Driver Door Courtesy Lamp............8W-80-22
Driver Door Lock Motor................8W-80-23
Driver Door Lock Switch...............8W-80-23
Driver Heated Seat Back...............8W-80-23
Driver Heated Seat Cushion............8W-80-23
Driver Heated Seat Module.............8W-80-23
Driver Heated Seat Switch.............8W-80-24
Driver Power Mirror - C1..............8W-80-24
Driver Power Mirror - C2..............8W-80-24
Driver Power Seat Switch..............8W-80-25
Driver Power Window Switch...........8W-80-25
Driver Seat Front Vertical Motor.........8W-80-25
Driver Seat Horizontal Motor...........8W-80-25
Driver Seat Rear Vertical Motor.........8W-80-26
Driver Seat Recliner Motor.............8W-80-26
Driver Window Motor.................8W-80-26
E40RF3 ...........................8W-80-26
E69F09............................8W-80-27
E78F02............................8W-80-27
E95 B107...........................8W-80-27
E96 B108...........................8W-80-28
E97 B106...........................8W-80-28
EGR Solenoid (2.4L MTX/3.3L/3.8L)......8W-80-28
EGR Solenoid (Diesel).................8W-80-28
Electric Wiper De-Icer - C1.............8W-80-29
Electric Wiper De-Icer - C2.............8W-80-29
Engine Coolant Temperature Sensor
(Diesel)..........................8W-80-29
Engine Coolant Temperature Sensor
(Gas)............................8W-80-29
Engine Oil Pressure Switch.............8W-80-29
Engine Speed Sensor (Diesel)...........8W-80-30
Evap Leak Detection Pump
(Except Built-Up-Export).............8W-80-30
Evap/Purge Solenoid..................8W-80-30
Evaporator Temperature Sensor.........8W-80-30
Flexible Fuel Sensor..................8W-80-30
Front Blower Motor...................8W-80-31
Front Blower Motor Resistor Block.......8W-80-31
Front Cigar Lighter/Power Outlet........8W-80-31
Front Reading Lamps/Switch...........8W-80-32
Front Reading Lamps/Switch
(Overhead Console).................8W-80-32
Front Washer Motor..................8W-80-32
Fuel Heater.........................8W-80-32
Fuel Injector No. 1 (2.0L/2.4L)...........8W-80-33
Fuel Injector No. 1 (3.3L/3.8L)...........8W-80-33
Fuel Injector No. 2 (2.0L/2.4L)...........8W-80-33
Fuel Injector No. 2 (3.3L/3.8L)...........8W-80-33
Fuel Injector No. 3 (2.0L/2.4L)...........8W-80-33
NS/GS8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 1

Page 878 of 1938

CHRYSLER VOYAGER 1996 Service Manual Component Page
Fuel Injector No. 3 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 4 (2.0L/2.4L)...........8W-80-34
Fuel Injector No. 4 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 5 (3.3L/3.8L).

Component Page
Fuel Injector No. 3 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 4 (2.0L/2.4L)...........8W-80-34
Fuel Injector No. 4 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 5 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 6 (3.3L/3.8L)...........8W-80-34
Fuel Pump Module...................8W-80-35
Fuel Tank Module....................8W-80-35
G200..............................8W-80-35
G300..............................8W-80-36
G301 (Diesel)........................8W-80-37
G301 (Gas).........................8W-80-37
G302..............................8W-80-38
G400..............................8W-80-38
Generator..........................8W-80-38
Glove Box Lamp.....................8W-80-39
Glow Plug Relay.....................8W-80-39
HS6D S02..........................8W-80-39
HS6P S02..........................8W-80-39
Headlamp Switch - C1.................8W-80-39
Headlamp Switch - C2.................8W-80-40
Headlamp Washer....................8W-80-40
High Note Horn......................8W-80-40
Hood Ajar Switch.....................8W-80-41
Horn/Speed Control Switch.............8W-80-41
Idle Air Control Motor.................8W-80-41
Ignition Coil Pack (2.0L/2.4L)...........8W-80-41
Ignition Coil Pack (3.3L/3.8L)...........8W-80-41
Ignition Switch - C1..................8W-80-42
Ignition Switch - C2..................8W-80-42
Ignition Switch - C3..................8W-80-42
Instrument Cluster...................8W-80-42
Intake Air Temperature Sensor..........8W-80-43
Intake Air Temperature/Manifold
Absolute Pressure Sensor............8W-80-43
J02A L15...........................8W-80-43
J03A L16...........................8W-80-43
Junction Block - C1...................8W-80-44
Junction Block - C2...................8W-80-45
Junction Block - C3...................8W-80-46
Junction Block - C4...................8W-80-47
Key-In Halo Lamp....................8W-80-48
Key-In Switch.......................8W-80-48
Knock Sensor........................8W-80-48
Left Combination Relay................8W-80-48
Left Door Speaker....................8W-80-48
Left Fog Lamp (Built-Up-Export)........8W-80-49
Left Fog Lamp (Except Built-Up-Export). . .8W-80-49
Left Front Panel Speaker..............8W-80-49
Left Front Park/Turn Signal Lamp
(Built-Up-Export)..................8W-80-49
Left Front Park/Turn Signal Lamp
(Except Built-Up-Export)............8W-80-49
Left Front Speaker...................8W-80-49
Left Front Wheel Speed Sensor..........8W-80-50Component Page
Left Headlamp (Built-Up-Export)........8W-80-50
Left Headlamp (Except Built-Up-Export) . .8W-80-50
Left Headlamp Leveling Motor
(Built-Up-Export)..................8W-80-50
Left High Headlamp (Chrysler)
(Except Built-Up-Export).............8W-80-50
Left Liftgate Flood Lamp...............8W-80-51
Left Low Headlamp (Chrysler)
(Except Built-Up-Export).............8W-80-51
Left Mid Reading Lamp................8W-80-51
Left Rear Door Ajar Switch.............8W-80-51
Left Rear Lamp Assembly
(Built-Up-Export)..................8W-80-51
Left Rear Lamp Assembly
(Except Built-Up-Export).............8W-80-51
Left Rear Pillar Speaker...............8W-80-52
Left Rear Reading Lamp...............8W-80-52
Left Rear Sliding Door Contacts.........8W-80-52
Left Rear Speaker....................8W-80-52
Left Rear Vent Motor (LHD)............8W-80-52
Left Rear Vent Motor (RHD)............8W-80-53
Left Rear Wheel Speed Sensor..........8W-80-53
Left Repeater Lamp...................8W-80-53
Left Stop/Turn Signal Relay............8W-80-53
Left Visor/Vanity Mirror Lamps.........8W-80-53
License Lamp.......................8W-80-54
Liftgate Ajar Switch..................8W-80-54
Liftgate Arm/Disarm Switch............8W-80-54
Liftgate Lock Motor...................8W-80-54
Low Coolant Level Switch..............8W-80-54
Low Note Horn......................8W-80-54
Low Washer Fluid Switch..............8W-80-54
Manifold Absolute Pressure Sensor.......8W-80-55
Memory Power Seat Switch.............8W-80-55
Memory Seat Front Vertical Motor.......8W-80-55
Memory Seat Front Vertical
Position Sensor....................8W-80-55
Memory Seat Horizontal Motor..........8W-80-55
Memory Seat Horizontal Position Sensor . .8W-80-56
Memory Seat Rear Vertical Motor........8W-80-56
Memory Seat Rear Vertical
Position Sensor....................8W-80-56
Memory Seat Recliner Motor............8W-80-56
Memory Seat Recliner Position Sensor. . . .8W-80-56
Memory Seat/Mirror Module - C1........8W-80-57
Memory Seat/Mirror Module - C2........8W-80-57
Memory Seat/Mirror Module - C3........8W-80-58
Memory Set Switch...................8W-80-58
Message Center (LHD)................8W-80-58
Message Center (RHD)................8W-80-59
Mode Door Actuator...................8W-80-59
Multi-Function Switch.................8W-80-59
Needle Movement Sensor..............8W-80-60
Output Shaft Speed Sensor.............8W-80-60
Overhead Console....................8W-80-60
8W - 80 - 2 8W - 80 CONNECTOR PIN-OUTSNS/GS

Page 879 of 1938

CHRYSLER VOYAGER 1996 Service Manual Component Page
P30 J01D...........................8W-80-60
P50 ...............................8W-80-61
Park/Neutral Position Switch (EATX).....8W-80-61
Park/Neutral Position Switch (MTX)......8W-80-61

Component Page
P30 J01D...........................8W-80-60
P50 ...............................8W-80-61
Park/Neutral Position Switch (EATX).....8W-80-61
Park/Neutral Position Switch (MTX)......8W-80-61
Passenger Airbag Squib................8W-80-61
Passenger Door Arm/Disarm Switch......8W-80-61
Passenger Door Courtesy Lamp..........8W-80-62
Passenger Door Lock Motor.............8W-80-62
Passenger Door Lock Switch............8W-80-62
Passenger Heated Seat Back............8W-80-62
Passenger Heated Seat Cushion.........8W-80-62
Passenger Heated Seat Module..........8W-80-62
Passenger Heated Seat Switch..........8W-80-63
Passenger Power Mirror C1.............8W-80-63
Passenger Power Mirror C2.............8W-80-63
Passenger Power Seat Switch...........8W-80-64
Passenger Power Window Switch........8W-80-64
Passenger Seat Front Vertical Motor......8W-80-64
Passenger Seat Horizontal Motor........8W-80-64
Passenger Seat Rear Vertical Motor......8W-80-65
Passenger Seat Recliner Motor..........8W-80-65
Passenger Window Motor..............8W-80-65
Power Distribution Center - C1..........8W-80-65
Power Distribution Center - C2..........8W-80-66
Power Distribution Center - C3..........8W-80-66
Power Distribution Center - C4..........8W-80-67
Power Distribution Center - C5..........8W-80-67
Power Distribution Center - C6..........8W-80-67
Power Distribution Center - C7..........8W-80-68
Power Distribution Center - C8..........8W-80-68
Power Folding Mirror Switch...........8W-80-68
Power Mirror Switch..................8W-80-68
Power Seat Circuit Breaker.............8W-80-68
Powertrain Control Module (Diesel)......8W-80-69
Powertrain Control Module - C1.........8W-80-71
Powertrain Control Module - C2.........8W-80-72
PRNDL Feed........................8W-80-72
PRNDL Switch......................8W-80-73
Radiator Fan Disconnect...............8W-80-73
Radiator Fan No. 1...................8W-80-73
Radiator Fan No. 2...................8W-80-73
Radiator Fan Relay (Gas)..............8W-80-73
Radiator Fan Relay No. 1 (Diesel)........8W-80-74
Radiator Fan Relay No. 2 (Diesel)........8W-80-74
Radiator Fan Relay No. 3 (Diesel)........8W-80-74
Radio - C1..........................8W-80-74
Radio - C2..........................8W-80-75Component Page
Radio - C3..........................8W-80-75
Radio Choke........................8W-80-75
Rear A/C Heater Unit.................8W-80-75
Rear Blower Front Control Switch.......8W-80-76
Rear Blower Rear Control Switch........8W-80-76
Rear Cigar Lighter/Power Outlet.........8W-80-76
Rear Dome Lamp....................8W-80-77
Rear Washer Motor...................8W-80-77
Rear Wiper Motor....................8W-80-77
Recirculation Door Actuator............8W-80-77
Remote Keyless Entry Module...........8W-80-77
Right Combination Relay...............8W-80-78
Right Door Speaker...................8W-80-78
Right Fog Lamp (Built-Up-Export).......8W-80-78
Right Fog Lamp (Except Built-Up-Export) .8W-80-78
Right Front Panel Speaker.............8W-80-78
Right Front Park/Turn Signal Lamp
(Built-Up-Export)..................8W-80-79
Right Front Park/Turn Signal Lamp
(Except Built-Up-Export)............8W-80-79
Right Front Speaker..................8W-80-79
Right Front Wheel Speed Sensor.........8W-80-79
Right Headlamp (Built-Up-Export).......8W-80-79
Right Headlamp (Except Built-Up-Export) .8W-80-80
Right Headlamp Leveling Motor
(Built-Up-Export)..................8W-80-80
Right High Headlamp (Chrysler)
(Except Built-Up-Export)............8W-80-80
Right Liftgate Flood Lamp.............8W-80-80
Right Low Headlamp (Chrysler)
(Except Built-Up-Export).............8W-80-80
Right Mid Reading Lamp..............8W-80-81
Right Rear Door Ajar Switch............8W-80-81
Right Rear Lamp Assembly
(Built-Up-Export)..................8W-80-81
Right Rear Lamp Assembly
(Except Built-Up-Export).............8W-80-81
Right Rear Pillar Speaker..............8W-80-81
Right Rear Reading Lamp..............8W-80-81
Right Rear Sliding Door Contacts........8W-80-82
Right Rear Speaker...................8W-80-82
Right Rear Vent Motor (LHD)...........8W-80-82
Right Rear Vent Motor (RHD)...........8W-80-82
Right Rear Wheel Speed Sensor.........8W-80-82
Right Repeater Lamp.................8W-80-82
Right Stop/Turn Signal Relay...........8W-80-83
Right Visor/Vanity Mirror Lamps........8W-80-83
NS/GS8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 3

Page 880 of 1938

CHRYSLER VOYAGER 1996 Service Manual Component Page
Seat Belt Switch.....................8W-80-83
Sentry Key Immobilizer Module.........8W-80-83
Speed Control Dimming Module.........8W-80-83
Stop Lamp Switch....................8W-80-83
T

Load next 8 pages

Page: < prev 1-10 ... 841-848 849-856 857-864 865-872 873-880 881-888 889-896 897-904 905-912 ... 1944 next >

height fuel filter navigation brake pads height adjustment fuel pressure