2003 Hyundai H-1 (Grand Starex) Owner's Manual

5-3
APPEARANCE CARE
APPEARANCE CARE APPEARANCE CARE
APPEARANCE CARE
APPEARANCE CARE
F010R01P-GAT Tire care
Tire care Tire care
Tire care
Tire care
For driving safely, and in order to obtain the
maximum useful life of the tires, the following points should be observed. For informationconcerning inspection, air pressure, and rota-tion of the tires, refer to the part which dealswith wheels in the section of this manual en-titled "Consumer Information".
F010S01P-GATTire air pressure
Tire air pressure Tire air pressure
Tire air pressure
Tire air pressure
The air pressure of the tires must always be
maintained in accordance with the specifica-tions, and should be measured when the tiresare cool.
If any changes in driving conditions(speed and/
or load weight) occur, the air pressure of thetires must meet the specifications which applyto the new driving conditions. If the vehicle isgoing to be driven under varying load weight,etc., the air pressure must be adjusted in orderto meet the highest specifications of the condi-tions under which the vehicle is driven (highspeeds and maximum load weight).
F010T01P-GATTire storage
Tire storage Tire storage
Tire storage
Tire storage
Storage of the tires should be in a dark, well-
ventilated place.
Tires not mounted on rims should be stored
vertically. Be sure that the tires are not incontact with fuel, oil grease, etc.

6-1
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
90 72RR R I
R R I
DESCRIPTION
ENGINE CONTROL SYSTEM MAINTENANCE (GASOLINE) ENGINE OIL/FILTER AIR CLEANER FILTER FUEL FILTERFUEL SYSTEM LEAKSSPARK PLUGVACUUM CRANKCASE VENTILATION HOSETIMING BELT DRIVE BELT (FOR WATER PUMP/ALTERNATOR)
G000A01P-GAT
6.6.
6.6.
6.
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
G010A01P-GAT SCHEDULED MAINTENANCE (EXCEPT EUROPEAN COMMUNITY)
SCHEDULED MAINTENANCE (EXCEPT EUROPEAN COMMUNITY) SCHEDULED MAINTENANCE (EXCEPT EUROPEAN COMMUNITY)
SCHEDULED MAINTENANCE (EXCEPT EUROPEAN COMMUNITY)
SCHEDULED MAINTENANCE (EXCEPT EUROPEAN COMMUNITY)
R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
The following maintenance services must be performed to assure good
vehicle control and performance. Keep receipts for all vehicle services to protect your warranty. Where both kilometers and time are shown, the frequency of service is
determined by whichever occurs first.
70 56R I I I 80 64
R I I II
NO.
1 2 34567 8 KILOMETERS X 1000 MONTHS
60 48
RRR I
R
II
R
5040
R I I I
40 32
R I I I I
30 24
RRR I
R
I
2016
R I I I I
10
8
R I I I
5 4
R
66
66
6

PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
6-2 90 72
RR R I I I
DESCRIPTION
ENGINE CONTROL SYSTEM MAINTENANCE (DIESEL) ENGINE OIL AND FILTER AIR CLEANER FILTERFUEL FILTERVALVE CLEARANCEINJECTION TIMINGTIMING BELT DRIVE BELT (FOR WATER PUMP/ALTERNATOR) ENGINE IDLE SPEEDFUEL SYSTEM LEAKSINJECTION NOZZLE (If exhaust gas includes black smoke)
G020A03P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
80 64
I I I I I I
KILOMETERS X 1000MONTHSNO.
1 23456 7 89
10
Note : (1) For every 6 months or 5,000 km, whichever occurs first : "R" 10
8
I I I 20 16
I I I I I I 3024
RR
I I I 4032
I I I I I I 5040
I I I 60 48
RR III
R III 7056
I I I
5 4
See Note (1)

6-3
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
DESCRIPTION
GENERAL MAINTENANCE ENGINE COOLANT *1 MANUAL TRANSMISSION OILAUTOMATIC TRANSMISSION OILTRANSFER CASE OIL *2REAR AXLE OILCLUTCH / BRAKE PEDAL FREE PLAY CLUTCH / BRAKE OIL RESERVOIR BRAKE HYDRAULIC FLUIDFRONT BRAKE PADSFRONT BRAKE CALIPERS / CYLINDERS / DISCREAR BRAKE DRUMS / LININGS / CYLINDERSHANDBRAKETIRE CONDITION / PRESSURE EXHAUST SYSTEM / MOUNTING STEERING JOINT / RACK / BOX OIL LEAKSSUSPENSION JOINT / SEALSFRONT WHEEL BEARINGENGINE COOLANT HOSESBRAKE PIPE CORROSION SEATBELTS / MOUNTINGS HEAD LAMPSAIR FILTER (For Evaporator and Blower unit) *3
NO.
123456 7 89
10111213 14 1516171819 20 2122
G030A04P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
70 56
I I I I I I III I I 80 64
I I
R II I IIII I I IIII I90 72
I I I III I I I I I II
20 16
I I I II I IIIII I IIII I 30 24
I I I III I III I II 40 32
I I
R II I III I I IIIII I 50 40
I I I I I I III I I 60 48
I I I IIIII I I I I IIIIIII
See below
KILOMETERS X 1000 MONTHS
54
R 10
8
I I I I I I III I I
See below
*1. For every 24 months or 40,000 km, whichever occurs first : "R"
*2. For every 24 months or 48,000 km, whichever occurs first : "R"
*3. For every 12 months or 20,000 km, whichever occurs first : "R" See below

PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
6-4 DESCRIPTION
ENGINE CONTROL SYSTEM MAINTENANCE (GASOLINE) ENGINE OIL AND FILTER (SG OR ABOVE)*AIR CLEANER FILTERFUEL FILTERFUEL SYSTEM LEAKSSPARK PLUG TIMING BELT DRIVE BELT (FOR WATER PUMP/ALTERNATOR)
G040A02P-GAT
SCHEDULED MAINTENANCE (FOR EUROPEAN COMMUNITY ONLY)
SCHEDULED MAINTENANCE (FOR EUROPEAN COMMUNITY ONLY) SCHEDULED MAINTENANCE (FOR EUROPEAN COMMUNITY ONLY)
SCHEDULED MAINTENANCE (FOR EUROPEAN COMMUNITY ONLY)
SCHEDULED MAINTENANCE (FOR EUROPEAN COMMUNITY ONLY)
Where both kilometers and time are shown, the frequency of service is determined by whichever occurs first.
The following maintenance services must be performed to assure goodvehicle control and performance. Keep receipts for all vehicle services toprotect your warranty. R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
NO.
1 2345 6 7KILOMETERS X 1000 MONTHS
* SF or LOWER : every 10,000 km or 6 months "R".
R
7.5 6 90 72
RRR I
RR I
15 12
R I I 30 24
RR I
R
I 4536
R I
R
I 6048
RR I
R I
R 7560
R I I

6-5
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
90 72R R I
R II
R II I
DESCRIPTION
ENGINE CONTROL SYSTEM MAINTENANCE ( EXCEPT 2.5 CRDi DIESEL )
ENGINE OIL AND FILTER
AIR CLEANER FILTER FUEL SYSTEM LEAKS FUEL FILTER VALVE CLEARANCEINJECTION TIMINGTIMING BELTDRIVE BELT (FOR WATER PUMP/ALTERNATOR) ENGINE IDLE SPEED
INJECTION NOZZLE (I f exhaust gas includes black smoke)
G050A03P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
NO.
1 23 4 5678 9
10KILOMETERS X 1000 MONTHS75 60
R I I I I
60 48
R R I
R III
R I I
4536
R I I I I
30 24
R R I
R II I I I
1512
R I I I I
7.5
6
R

PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
6-6 90 72
RRR I
RR I
DESCRIPTION
ENGINE CONTROL SYSTEM MAINTENANCE (2.5 CRD i DIESEL ONLY)
ENGINE OILENGINE OIL FILTERAIR CLEANER FILTERFUEL SYSTEM LEAKSFUEL FILTER DRIVE BELT (FOR WATER PUMP/ALTERNATOR)
INJECTION NOZZLE (I f exhaust gas includes black smoke)
G080A01P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
NO.
1 2345 6 7KILOMETERS X 1000 MONTHS75 60RR I
6048
RRR I
R I I
45 36
RR I
3024
RRR I
R
I I
15 12
RR I

6-7
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
DESCRIPTION
GENERAL MAINTENANCE ENGINE COOLANT *1 MANUAL TRANSMISSION OIL AUTOMATIC TRANSMISSION OIL TRANSFER CASE OIL *2 REAR AXLE OIL CLUTCH/BRAKE PEDAL FREEPLAY CLUTCH/BRAKE OIL RESERVOIR BRAKE HYDRAULIC FLUID FRONT BRAKE PAD FRONT BRAKE CALIPERS/CYLINDERS/DISC REAR BRAKE DRUMS/LININGS/CYLINDERS HAND BRAKE TIRE CONDITION/PRESSURE EXHAUST SYSTEM/MOUNTING STEERING JOINT/RACK/BOX/OIL LEAKS SUSPENSION JOINT/SEALS FRONT WHEEL BEARING ENGINE COOLANT HOSES BRAKE PIPE CORROSION
AIR FILTER (F o r Evapoerator and Blower unit) *3
NO.
12 3 4 5 6 7 8 9
1011 12 13 14 15 16 17 18 19 20KILOMETERS X 1000 MONTH90 72
I
R R I I I I I I I I I I I I I I
G060A04P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY15 12
II I I I I I I I 30 24
II I I I I I I I I I I I I I I I 4536
II
R II I I I I 60 48
II I I I I I I I I I I I I I I I 7560
II I I I I I I I7.5 6
R
See below See below
*1. For every 24 months or 45,000 km, whichever occurs first : "R" *2. For every 24 months or 48,000 km, whichever occurs first : "R"*3. For every 12 months or 20,000 km, whichever occurs first : "R"
See below