2006 LAND ROVER FRELANDER 2 airbag disable

35
Introduction
R
IntroductionSYMBOLS GLOSSARY
Warnings
Cautions
Symbols
This recycling symbol identifies
those items that mu st be disposed
of safely in order to prevent
unnecessary damage to the environment.
This symbol identifies those
features that can be adjusted,
disabled or enabled by a Land
Rover Dealer/Authorised Repairer.
LABEL LOCATIONS
Warning labels attached to your
vehicle bearing this symbol mean:
Do not touch or adjust components
until you have re ad the relevant
instructions in the handbook.
Labels showing this symbol
indicate that the ignition system
utilises very high voltages. Do not
touch any ignition components
while the starter switch is turned on.
Warning labels
Labels are attached to your vehicle at several
positions. These are ap plied to draw your
attention to important subjects, e.g. tyre
pressures, tow bar use, airbags, roll-over risk,
engine compartment hazards, etc.
Additional information labels may also be
found at these locations.
WARNING
Safety warnings ar e included in this
handbook. These indicate either a
procedure which must be followed
precisely, or information that should be
considered with great care in order to avoid
the possibility of personal injury.
CAUTION
Cautions are included in this handbook.
These indicate either a procedure which
must be followed precisely, or
information that should be considered with
great care in order to avoid the possibility of
damage to your vehicle.
E83651
E83652

Supplementary restraints system
62
L
DISABLING THE PASSENGER AIRBAG
Note: The passenger airbag should be disabled
only when a rearward fa cing child restraint if
fitted to the front passenger seat.
To disable the passenger airbag :-
1. Remove the emergency key from the
remote control. See USING THE KEY
(page 40).
2. Insert the end of the key blade into the slot
in the switch and rotate the switch to the
off position.
WARNINGS
Crash test data and statistics, show
that the safest place for a child to be
restrained, is in a child seat correctly
fitted to the vehicle's rear seat.
Do not use a child restraint on a seat
protected by an ope rational airbag in
front of it. Doing so presents a high
risk of death or serious injury to the child in the
event of an accident.
Do not fit a child restraint to the front
passenger seat if the SRS warning
light illuminates co ntinuously with the
ignition on.
E82699
WARNING
As soon as the child seat is removed
from the front passenger seat the
airbag must be turned on. Failure to do
so will put any front seat passengers at greater
risk of death or serious injury in the event of a
frontal impact.
E83596

63
Supplementary restraints system
R
Operational status indicator
The passenger airbag operational status
indicator illuminates yellow when the airbag
has been disabled.
Note: The indicator will on ly illuminate when
the ignition is turned on, or the engine is
running.
AIRBAG SERVICE INFORMATION
All of the following opera tions should only be
carried out by a Land Rover Dealer/Authorised
Repairer, or suitably qualified person :-
• Removal or repair of any wiring or
component in the vicinity of any SRS
components.
• Installation of electr ical, or electronic,
equipment and accessories.
• Modification to the front or sides of the
vehicle exterior.
• Attachment of accessor ies to the front or
sides of the vehicle.
WARNING
When checking the operational status
of the front passenger airbag, ensure
that the ignition is switched on.
E82785
WARNINGS
Do not attempt to service, repair,
replace, modify, or tamper with, any
part of the SRS. Thi s includes wiring or
components in the vicinity of SRS
components. Doing so may cause the system
to trigger, or render the system inoperative,
either of which may resu lt in death or serious
injuries.
Do not use any electrical test
equipment, or devices in the vicinity of
SRS components or wiring. Doing so
may cause the system to trigger, or render the
system inoperative , either of which may result
in death or serious injuries.

Child safety
64
L
Child safetyCHILD SEATS
It is very important for all infants and children
under 12 years of age to be restrained in a
suitable child safety seat appropriate to their
age and size. If it is essential that a child travels in the front
passenger seat, Land Ro ver recommends that
the following preparations are made before
fitting the child restraint.
• Disable the front pass enger airbag. See
DISABLING THE PASSENGER AIRBAG
(page 62).
• Adjust the front passenger seat fully
rearwards.
• Adjust the lumbar support to its minimum
support position.
• Adjust the seat cushion to its highest
position. If cushion rake adjustment is
possible, adjust it to its lowest position.
• Adjust the seat be lt adjustable upper
anchorage to its lowest position.
This symbol is affixed to the end of the facia on
the passenger side. Its purpose is to warn
against the use of a rear facing child seat when
the front passenger ai rbag is fitted and
operational.
WARNINGS
Do not use a child restraint on a seat
with an operational airbag in front of
it. There is a risk of death or serious injury
when the airbag deploys.
Crash statistics show that children are
safest when properly restrained on
the rear seat.
Do not use a forward facing child seat
until the child using it is above the
minimum weight of 9 kg (20 lb.) and able to
sit up unaided. Up to the age of two, a child's
spine and neck are not sufficiently developed
to avoid injury in a frontal impact.
Do not allow a baby or infant to be
held or carried on the lap. The force of
a crash can increase effective body weight by
as much as thirty times, making it
impossible to hold onto the child. Children
typically require the use of a booster seat
appropriate to their age and size, thereby
enabling the seat belts to be properly fitted,
reducing the risk of injury in a crash.
Children could be enda ngered in a crash if
their child restraints are not properly secured
in the vehicle.
Do not use a child seat that hooks
over the seat back. This type of seat
cannot be satisfactorily secured and is
unlikely to be safe for your child.
WARNING
Original text according to ECE R94.
01. Extreme hazard! Do not use a
rearward facing child restraint on a seat
protected by an operational airbag in front of
it!
E79258

Child safety
66
L
Child safety seating and positions
• U = Suitable for universal category
restraints approved for this mass group.
• UF = Suitable for Forward-facing universal
category restraints approved for this mass
group.
* Always ensure that the passenger airbag has
been disabled before us ing a child restraint in
this seating position. The seat back needs to be
adjusted to the fully upright position. See
DISABLING THE PASSENGER AIRBAG
(page 62).
Note: The legislation whic h governs how and
where children should be carried when
travelling in a vehicle, is subject to change. It is
the responsibility of the driver to comply with
all regulations in force.
BOOSTER CUSHIONS
In a situation where a child is too large to fit
into a child safety seat, but is still too small to
safely fit the three point belt properly, a booster
seat is recommended for maximum safety.
Follow the manufacturer's instructions for
fitting and use, then adjust the seat belt to suit.
Mass
group. 0 = Up
to 10 kg
(22 lb). 0+ = Up
to 13 kg
(29 lb). I = 9-18 kg
(20-40 lb). II = 15-25 kg (40-67
lb). III = 25-36 kg (67-80 lb).
Seating
positions.
Front
passenger.
* UF* UF* U* U* U*
Rear
outboard. UU U U U
Rear
centre. UU U U U
CAUTION
Information given within the table is
correct at the time of going to press.
However, availability of child restraints may
change. Please cons ult your Land Rover
Dealer/Authorised Repairer for the latest
recommendation.

414-01 BATTERY, MOUNTING AND CABLES
Central junction box
FREELANDER 2 - LR2 - VIN: 000201 onwards (LHD) (02 / 06) 54
VT,0.5,385
VT,0.5,2030
VT,0.75,280
VT,0.5,2021
GN-VT,0.75,2345VT-GN,0.5,2345BN-WH,0.5,2345WH,0.5,2345YE-GN,0.5,2345GY-OG,0.5,2345BU-WH,0.5,2345BN-BU,0.5,5855YE-GN,0.5,2345GN-OG,0.5,4575YE-OG,0.5,4575VT-GN,0.5,4575BN,0.75,5855
VT,0.5,2030VT,0.75,2325
VT,0.5,4575
BU,4.0,2345
VT,0.35,2280VT,0.5,2051
VT,1.0,110
YE-VT,1.5,340YE-VT,1.5,340
BN-BU,0.75,1970BK-VT,0.75,2255GY-RD,0.5,3210GY-RD,0.5,3670WH-BN,0.75,2553GN,0.75,225BN,0.5,215GN,0.75,295
GN,0.75,2290
GN-VT,0.5,4263BU-OG,0.5,345
BU-OG,0.5,3870
GN,0.5D,450
GN,0.75,2433BN,0.5,2728
GY,0.5,1740YE-VT,1.5,5515YE-VT,1.5,1525
YE-VT,1.5,2160
Central junction-box (P101)
KL15-1
Sheet6
Heater-PTC (H137)Junction-box engine (P108)Auxiliary junction box (P107)RJB1
C23F-10 C23E-10C22D-6 C22C-6
switch (D183)
Module-Lighting-Auxiliary junction box (P107)RJB2Accelerator pedal (T113)
Sensor-Position-optimisation (S380)
Switch-Terrain-Electrochromic (B179)
Mirror-
FS4
5.0 Amps
Battery junction-box (P147)Instrument cluster (D107)indicator (J214)
airbag disable
Passenger
Not installed (Y371)
FS5
FS21
5.0 AmpsFS20
15.0 AmpsFS3
5.0 AmpsFS2
10.0 Amps
Windscreen (M105)
Motor-Wiper-
Module (CEM) (D316)
Central Electronics
BATTA (2)
Sheet3
BATT SAVER-1
Sheet6
gear inhibit (N182)
Solenoid-ReverseModule-Intrusion detection (T388)frequency (RF) (T203)
Receiver-Radio-
C23F-13 C23E-13
C23E-9 C23F-9
detector (T221)
Sensor-Occupancy-Switch-Clutch-TOT (S472)Switch-Clutch-BOT (S471)
C33P-18
C2363-2
Auxiliary junction box (P107)Module (RCM) (D171)
Restraints Control
C44N-7 C44M-7
BATTA (1)
Sheet1
Rear screen (M106)
Motor-Wiper-ABS module (D423)
C1BB01A-38C1BB01A-86C1BB01A-81C1BB01A-96C1BB01A-106C1BB01A-110C1BB01A-69C1BB01A-35C4BR02A-29
C1BP02A-48 COMFORT RLYC1BP02A-43 WIPER RLY ON/OFFC1BP02A-6 WIPER RLY FAST/SLOWC1BP02A-47 H/L WASH-LEFTC1BP02A-5 HFS RLYC1BP02A-46 HORN RLYC1BP02A-45 IGN RLYC1BP02A-3 H/L WASH-RIGHTC1BP02B-26 REAR DEFROST RLY
C2LF23D-2C2E901-2C4BR02B-29C2E901-3C2E901-6C2E901-1C9PM05A-1C3CA15-7C2HP01E-1
C1BP02B-29 ACCL SIGNALC1BP02B-45 IGN RELAYC1BP02B-47 ACCL GNDC1BP02B-11 ACCL SUPPLYC1BP02B-55
C1BB01A-98
IGNC9R116-1C2MC01A-2
C1BP02B-69
NOT USED (V101)C1BP02A-64
NOT USED (V101)
S2BP04
C1BP02H-18C1BP02A-65 IGNC1BP02C-68
C1RW01A-3
C1BP02A-29
FR PARK SW SIGC1BP02C-43C1BP02A-54
ELECTRONIC GNDC1BP02H-16C1BP02H-15
C3ET58-1C3RT12-3C3PL56-3
G1D132B-1
C1BP02B-27
CLUTCH SW75%C1BP02B-33
CLUTCH SW25%C1BP02B-1
ITO CRASH SRS SIGC1BP02C-66
S3E903
C2E903-1C2E904-2C0962-1
S2BP02
C2R114C-24C2R114C-23C4BR02A-32C4BR02A-28
C1BP02A-55
S4BP20
C1BP02B-74C1BP02B-58
NOT USED (V101)
C4RW02-2VBATTC1CA01A-8

501-20 SUPPLEMENTAL RESTRAINT SYSTEMFREELANDER 2 - LR2 - VIN: 000201 onwards (LHD) (01 / 02) 109
501-20 SUPPLEMENTAL RESTRAINT SYSTEM
BU-OG,0.5
BU,4.0GN-VT,0.75RD,6.0
BN-YE,0.5VT,0.35GN,0.75
YE-OG,0.35
GN,0.75
GY-YE,0.5GN-BU,0.5
YE-OG,0.35GN,0.75GY-YE,0.5GN-BU,0.5BU-OG,0.5WH,0.5WH-BU,0.5GN,0.35YE,0.35
GN,0.75
BK-VT,0.5
BK-VT,1.5
BN,0.5YE,0.5VT-WH,0.5
BN,0.5
RD,25.0
BK,35.0
YE-GN,0.5
YE-OG,0.5VT-GY,0.5GY-VT,0.5
YE-OG,0.5VT-GY,0.5GY-VT,0.5BU-GN,0.5BN-BU,0.5WH,0.5BU,0.5YE-VT,0.5BN-WH,0.5VT-BN,0.5
OG-GN,0.5
OG-GN,0.5
OG,0.5
OG,0.5
WH-BU,0.5YE-GY,0.5VT-GN,0.5GY-BU,0.5
Module (RCM) (D171)
Restraints Control
Module (CEM) (D316)
Central Electronics
Central junction-box (P101)
FS2
10.0 AmpsFS4
5.0 Amps
C4B2-2Air bag disable (S426)
Switch-Passenger-
C22C-9 C22D-9
fixings (E110)
Earth via-
C33N-6
C4B2-1
C33N-5C33N-9
C4B4-1
indicator (J214)
airbag disable
Passenger
C23E-9 C23F-9
D
Sheet?C
Sheet?
Airbag-Side-Driver (U119)
fixings (E110)
Earth via-
FE17
60.0 Amps
Ignition (R211) Relay-
Battery junction-box (P147)column-Collapse (M345)
Actuator-Steering
C23F-13 C23E-13
Battery (P100)12.0 Volts
FE41
20.0 Amps
Clock spring (S227)
Air bag-Driver (U106)
curtain-Driver (U125)
Air bag-Sidecurtain-Passenger (U126)
Air bag-SideC5B2-1
C33P-5C33P-6
C5B2-2
C33P-9
C5B4-1
ACCELEROMETER CENTRAL
A
Sheet?
fixings (E110)
Earth via-
C4B4-2
C33N-10
Driver (S394)
Switch-Buckle-
B
Sheet?
Airbag-Side-Passenger (U118)
fixings (E110)
Earth via-
fixings (E110)
Earth via-
C33P-10
C5B4-2
Passenger (S395)
Switch-Buckle-
fixings (E110)
Earth via-
SENSOR-ROLL OVER
Air bag-Passenger (U102)
fixings (E110)
Earth via-
C1BP02A-65
C1BP02B-23
C1BP02G-1C1BP02A-45
C1BP02H-18C1BP02C-66C1BP02A-49C1BP02A-50
SBR PASSENGERBATT AMS CAN LMS CAN HIGN
C2R114C-17
PAD INDICATORC2R114C-24
IGN
S2BP02
C3R114-25
BELT LOCK DRIVERC3R114-20
SIDE AIRBAG DRIVER +C3R114-19
SIDE AIRBAG DRIVER -C2R114C-19
HS CAN HC2R114C-20
HS CAN LC2R114C-21
PAC0S B +C2R114C-18
PAC0S A +
S2DB04HS2DB05HC2R224B-2C2R224B-1
C9R116-1
C9R116-2C3R105-2C3R105-1
C2R224B-5
S2D134A
G3D134-1
C1BB01A-106
C1BP02B-1
CRASH SRS SIG
C2R168A-2C2R168A-1
C1BB07G-1
C1BB01B-1C1DC02A-1
C1BB01A-98
C1D134B-1
G1D108A-1
C2R115D-7
C68-1
C2R114C-3
AIRBAG STAGE 1 DRIV +C3R114-17
CURTAIN DRIVER +C3R114-18
CURTAIN DRIVER -C3R114-8
SIDE AIRBAG PASS -C3R114-7
SIDE AIRBAG PASS +C3R114-30
BELT LOCK-PASS
C2R114C-11 STEERING COLUMN -C2R114C-23EVENT SIGNAL
C5R109-2C5R109-1
C2R114C-2
AIRBAG STAGE 2 DRIV +C2R114C-1
AIRBAG STAGE 2 DRIV -C3R114-10
CURTAIN PASS +C3R114-9
CURTAIN PASS -C2R114C-4
AIRBAG STAGE 1 DRIV -
C2R114C-12
STEERING COLUMN +
C6R111-1C6R111-2C2R115D-2C2R115D-1C2R115D-8
C3R201-2C3R201-1C3R106-2C3R106-1C68C-2C68C-1C3R203-2C3R203-1C68-2
C2R114C-7
AIRBAG STAGE 2 PASS -C2R114C-8
AIRBAG STAGE 2 PASS +C2R114C-10
AIRBAG STAGE 1 PASS -C2R114C-9
AIRBAG STAGE 1 PASS +
C2R103A-2C2R103A-1C2R103-2C2R103-1

414-01 BATTERY, MOUNTING AND CABLES
Central junction box
FREELANDER 2 - LR2 - VIN: 000201 onwards (RHD) (02 / 06) 54
VT,0.5,385
VT,0.5,2030
VT,0.75,280
VT,0.5,2021
GN-VT,0.75,2345VT-GN,0.5,2345BN-WH,0.5,2345WH,0.5,2345YE-GN,0.5,2345GY-OG,0.5,2345BU-WH,0.5,2345BN-BU,0.5,5855YE-GN,0.5,2345GN-OG,0.5,4575YE-OG,0.5,4575VT-GN,0.5,4575BN,0.75,5855
VT,0.5,2030VT,0.75,2325
VT,0.5,4575
BU,4.0,2345
VT,0.35,2280VT,0.5,2051
VT,1.0,110
YE-VT,1.5,340YE-VT,1.5,340
BN-BU,0.75,1970BK-VT,0.75,2255GY-RD,0.5,3210GY-RD,0.5,3670WH-BN,0.75,2553GN,0.75,225BN,0.5,215GN,0.75,295
GN,0.75,2290
GN-VT,0.5,4263BU-OG,0.5,345
BU-OG,0.5,3870
GN,0.5D,450
GN,0.75,2433BN,0.5,2728
GY,0.5,1740YE-VT,1.5,5515YE-VT,1.5,1525
YE-VT,1.5,2160
Central junction-box (P101)
KL15-1
Sheet6
Heater-PTC (H137)Junction-box engine (P108)Auxiliary junction box (P107)RJB1
C23F-10 C23E-10C22D-6 C22C-6
switch (D183)
Module-Lighting-Auxiliary junction box (P107)RJB2Accelerator pedal (T113)
Sensor-Position-optimisation (S380)
Switch-Terrain-Electrochromic (B179)
Mirror-
FS4
5.0 Amps
Battery junction-box (P147)Instrument cluster (D107)indicator (J214)
airbag disable
Passenger
Not installed (Y371)
FS5
FS21
5.0 AmpsFS20
15.0 AmpsFS3
5.0 AmpsFS2
10.0 Amps
Windscreen (M105)
Motor-Wiper-
Module (CEM) (D316)
Central Electronics
BATTA (2)
Sheet3
BATT SAVER-1
Sheet6
gear inhibit (N182)
Solenoid-ReverseModule-Intrusion detection (T388)frequency (RF) (T203)
Receiver-Radio-
C23F-13 C23E-13
C23E-9 C23F-9
detector (T221)
Sensor-Occupancy-Switch-Clutch-TOT (S472)Switch-Clutch-BOT (S471)
C33P-18
C2363-2
Auxiliary junction box (P107)Module (RCM) (D171)
Restraints Control
C44N-7 C44M-7
BATTA (1)
Sheet1
Rear screen (M106)
Motor-Wiper-ABS module (D423)
C1BB01A-38C1BB01A-86C1BB01A-81C1BB01A-96C1BB01A-106C1BB01A-110C1BB01A-69C1BB01A-35C4BR02A-29
C1BP02A-48 COMFORT RLYC1BP02A-43 WIPER RLY ON/OFFC1BP02A-6 WIPER RLY FAST/SLOWC1BP02A-47 H/L WASH-LEFTC1BP02A-5 HFS RLYC1BP02A-46 HORN RLYC1BP02A-45 IGN RLYC1BP02A-3 H/L WASH-RIGHTC1BP02B-26 REAR DEFROST RLY
C2LF23D-2C2E901-2C4BR02B-29C2E901-3C2E901-6C2E901-1C9PM05A-1C3CA15-7C2HP01E-1
C1BP02B-29 ACCL SIGNALC1BP02B-45 IGN RELAYC1BP02B-47 ACCL GNDC1BP02B-11 ACCL SUPPLYC1BP02B-55
C1BB01A-98
IGNC9R116-1C2MC01A-2
C1BP02B-69
NOT USED (V101)C1BP02A-64
NOT USED (V101)
S2BP04
C1BP02H-18C1BP02A-65 IGNC1BP02C-68
C1RW01A-3
C1BP02A-29
FR PARK SW SIGC1BP02C-43C1BP02A-54
ELECTRONIC GNDC1BP02H-16C1BP02H-15
C3ET58-1C3RT12-3C3PL56-3
G1D132B-1
C1BP02B-27
CLUTCH SW75%C1BP02B-33
CLUTCH SW25%C1BP02B-1
ITO CRASH SRS SIGC1BP02C-66
S3E903
C2E903-1C2E904-2C0962-1
S2BP02
C2R114C-24C2R114C-23C4BR02A-32C4BR02A-28
C1BP02A-55
S4BP20
C1BP02B-74C1BP02B-58
NOT USED (V101)
C4RW02-2VBATTC1CA01A-8