Page 457 of 933

80
BATTERY - FRONT HEADLIGHTS
80 - 8
HEADLAMPS ADJUSTMENT
FOG LAMPS ADJUSTMENT
The fog lamps adjustment is to be performed in the following conditions:
- the vehicle to be placed on a horizontal surface;
- the vehicle has not passengers inside the cockpit or weights in the trunk;
- the tires a re pressurized a t the manufacturer prescribed pressure.
Further on, proceed as follows:
Bring the vehicle at the working place.
Position the adjustment device (headlamp adjustment device – E) in front of an optical center
of a fog lamp.
Switch on the fog lamps.
Rotate the adjustment screw of the fog lamp (D), so that an adjustment of 2 % is obtained and
the separation between the lighted area and the dark one from the adjustment device is located
under the marked line (G).
This adjustment is performed in the same way as for the meeting lights adjustment.
Bring the adjustment device in front of the optical center of the second fog lamp.
Perform the fog lamp adjustment.
Switch off the fog lamps.
G
E
vnx.su
Page 458 of 933
81
REAR AND INTERIOR LIGHTING
81 - 1
BULBS REPLACEMENT
BULB REPLACEMENT OF THE REAR TURNING, PARKING AND BRAKE STOP LIGHT
Disconnect the battery.
Push towards interior the two attachment clips (1 ), then extract the plastic cap (2).
Disconnect the connector (6).
Push upwards the attachment clips (3) of the printed circuit plate (4), swing it and pull out the
plate from the attachment shoulders (5).
For remounting perform the dismounting operations in the reverse order.
FOG LAMP BULB REPLACEMENT
Di smount the attachment scre ws (1) of the
fog lamp glass and remove the glass;
Remove the burnt bulb and replace it.
REPLACEMENT OF THE LICENSE PLATE LAMP BULB
Dismount the lamp attachment screws.
Replace the burnt bulb.
For remounting, perform the dismounting operations in the reverse order.
vnx.su
Page 459 of 933
REAR AND INTERIOR LIGHTING
81
81 - 2
BULBS
Hugh/low beam lights Two phases bulb R2-12V-40/45 W
He adl a mp swith flange holder P45t41
Parking lights Bulb 12V-4W with holder BA 9s
Front turning lamp Bulb 12V-21W (colored) with holder BAU 15s
Fog lamps Halogen bulb H3, 12V-55W with holder Pk22s
Rear Parking, stop lights Bulb 12V-21/5W with holder BAY 15d
lamps Turning and reverse driving Bulb 12V-21W with holder BA15s
Rear fog lamps Bulb 12V-21W with holder BA 15s
Lamps: side signaling, trunk lighting Bulb 12V-5W with holder W2,1x9,5
License plate, ceiling, document compartment Bulb SOFIT 10 x 35 type AS02; 12 V-5W
lamps with holder Sv 8,5
Lamp STOP-S3 on the ceiling Bulb 12V-21W type C21W with holder Sv 8,5
Instrument panel Bulb 12V-1,2W holderW 2 x 4,6d BULBS
vnx.su
Page 460 of 933
81
REAR AND INTERIOR LIGHTING
THE REAR DRIVING LAMPS NOT WORKING81 - 3Check the contact supply.
The contact is supplied;
the lamps supplying wire is disconnected
or broken.
Check the F 01 fuse.
Fu se F01 is burnt; replace t he fuse .F
01 is good:
bridge across the c ontact plugs.
Lamps a re working; replace the contact. Lamps are not working.
The contact is not supplied;
the contact supply wire is disconnected
or broken.
DIAGNOSTIC
vnx.su
Page 461 of 933
REAR AND INTERIOR LIGHTING
81
81 - 4
FOG LAMPS NOT WORKING
F 10 fuse is burnt; replace the fuse.
The relay is supplied.
Ground wire broken. Check the fuse F 10.
F
10 fuse is good.
Check the supply of the R1 relay.
The relay is supplied.
Check the lamps supply. The relay i s not supplied. Is there + 12 V
at pole 4 of the fog lamps contact ?
Disconnected wiresor defect contact. Lights switch
device
defect or F05 fuse burnt.
Lamps are not supplied .Check the fog lamps control relay.
Relay defect.
Replace the relay. Relay good. Lamps supplying
wire
broken or disconnected.
Yes No
DIAGNOSTIC
vnx.su
Page 462 of 933
81
REAR AND INTERIOR LIGHTING
81 - 5
BRAKE STOP LIGHTS NOT WORKING
Check F 01 fuse.
F 01 fuse burnt ; replace it.Fuse is good.
Bridge across the brake stop contact.
Stop lamps are lighting. Replace the contact. Stop lamps are not lighting.
Check the contact supplying.
Wire is broken: replace the wire.Contact is supplied. Lamps supply
wi re is disconnected or broken.
DIAGNOSTIC
vnx.su
Page 463 of 933

REAR AND INTERIOR LIGHTING
81COCKPIT FUSE BOX81 - 6
DISMOUNTING
Disconnect the (-) plug of the battery.
Turning the button
(4) open, then carefully remove the access little door (1) to the fuse box,
placed under left side dashboard. Dismount the attaching screws (2) of the fuse box on back of the little door.
Rotate the fuse box in order to have access at the connectors of its back then carefully discon-
nect the wiring connectors. If it is necessary the replacement of the module (3 ) attached on the
fuse box, for the fuses F11 – F16, first note the position of the wires connected to these fuses,
then perform the wires disconnecting .
Remove the fuse box.
REMOUNTING
Connect the wiring connectors to the fuse box printed circuit. Observe the form correspon-
dence of each connector with its drawing, marked on the printed circuit of the fuse box. Connect the wires corresponding to the fuses F11 – F16, if those have been previously disconnected.
Position the wires appointed for the fuses F11- F16 and the module (3) of those fuses, then
attach the fuse box on the back of the access little door (1).
Carefully mount the fuse box access little door, then close it.
Connect the (-) battery plug.
Perform functional tests, noticing the correct operation of all consumers supplied by means of
the cockpit fuse box.
OBSERVAT ION
For vehicle equipped with radio-tape player, after battery reconnecting, the radio
code must be introduced, in order to make it again running.
1
4
vnx.su
Page 464 of 933
81
REAR AND INTERIOR LIGHTING
81 - 7
A.
FOR VEHICLES MANUFACTURED TILL 01.06.2001
The fuses are protecting the following electric circuits:
FUSE
NUMBER FUSE
TYPE
PROTECTED CIRCUIT
Clock, radio, STOP contact, climate blower relay control
Reverse driving contact
UCE decoder, speed transducer, instrument panel supply, diagnostic
socket, AC starting button, UCE anti intrusion
Turning and hazard lights
Front/rear parking lights, lighting: switches, instrument panel, climate
control, documents compartment, cigarette lighter, ashtray, radio
Cigarette lighter, instrument panel (anti-starting indicator), front right
ceiling lamp, UCE anti intrusion, anti intrusion indic
ator, diagnostic socket
Windscreen wiper-washing switch, windscreen wiper timer
Rear window defrosting
Climate blower
Left fo g lamp
F01
F02
F03
F04
F05
F06
F07
F08
F09
F10 15A
5A
15A
7,5A
5A
15A
15A
20A
15A
5A
COCKPIT FUSE BOX
vnx.su