1999 DODGE NEON Service Repair Manual

8W-80 CONNECTOR PIN-OUTS
Component Page
A/C Compressor Clutch.................8W-80-4
A/C Cycling Switch....................8W-80-4
A/C Heater Blower Motor...............8W-80-4
A/C Heater Control....................8W-80-4
A/C High Pressure Switch..............8W-80-4
A/C Low Pressure Switch...............8W-80-5
Airbag Control Module.................8W-80-5
Ash Receiver Lamp....................8W-80-6
Back-Up Lamp Switch.................8W-80-6
Battery Temperature Sensor.............8W-80-6
Blower Motor Resistor Block.............8W-80-6
Brake Warning Lamp Switch............8W-80-6
C101...............................8W-80-7
C102...............................8W-80-7
C103...............................8W-80-7
C104...............................8W-80-8
C105...............................8W-80-8
C108...............................8W-80-8
C160...............................8W-80-8
C161...............................8W-80-8
C170...............................8W-80-9
C205...............................8W-80-9
C206..............................8W-80-10
C225..............................8W-80-10
C230..............................8W-80-10
C231..............................8W-80-11
C241..............................8W-80-12
C242..............................8W-80-12
C301..............................8W-80-12
C303..............................8W-80-12
C309..............................8W-80-12
C340..............................8W-80-13
C341..............................8W-80-13
Camshaft Position Sensor..............8W-80-14
Center High Mounted Stop Lamp........8W-80-14
Cigar Lighter/Power Outlet.............8W-80-14
Clockspring.........................8W-80-14
Clutch Pedal Position Switch...........8W-80-15
Controller Anti-Lock Brake.............8W-80-15
Crankshaft Position Sensor.............8W-80-16
Data Link Connector..................8W-80-1
Daytime Running Lamp Module.........8W-80-16Component Page
Dome Lamp........................8W-80-17
Downstream Heated Oxygen Sensor......8W-80-17
Driver Door Lock Motor...............8W-80-17
Driver Door Lock Switch...............8W-80-17
Driver Power Window Motor............8W-80-17
Driver Power Window Switch...........8W-80-18
Driver Side Airbag...................8W-80-18
Duty Cycle Evap/Purge Solenoid.........8W-80-18
EGR Transducer Solenoid..............8W-80-19
Engine Coolant Temperature Sensor......8W-80-18
Engine Oil Pressure Switch............8W-80-19
Fog Lamp Switch....................8W-80-19
Front Fog Lamp Switch...............8W-80-19
Fuel Injector No. 1...................8W-80-19
Fuel Injector No. 2...................8W-80-19
Fuel Injector No. 3...................8W-80-20
Fuel Injector No. 4...................8W-80-20
Fuel Pump Module...................8W-80-20
Generator..........................8W-80-20
Glove Box Lamp And Switch............8W-80-20
Halo Lamp.........................8W-80-21
Headlamp Dimmer And Optical
Horn Switch......................8W-80-21
Headlamp Leveling Switch.............8W-80-21
Headlamp Switch....................8W-80-21
Heater Blower Motor.................8W-80-21
High Speed Warning Module...........8W-80-22
Horn..............................8W-80-22
Horn No. 1.........................8W-80-22
Horn No. 2.........................8W-80-22
IAT/Map Sensor.....................8W-80-25
Idle Air Control Motor.................8W-80-22
Ignition Coil Pack....................8W-80-22
Ignition Switch......................8W-80-23
Immobilizer.........................8W-80-23
Immobilizer Engine Sensor.............8W-80-23
Instrument Cluster-C1................8W-80-24
Instrument Cluster-C2................8W-80-24
Intermittent Wipe/Wash Switch.........8W-80-25
Key-In Switch.......................8W-80-25
Knock Sensor.......................8W-80-25
PL8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 1

Component Page
Left Airbag Impact Sensor.............8W-80-25
Left Back-Up Lamp................8W-80-25, 26
Left Fog Lamp......................8W-80-26
Left Front Door Speaker...............8W-80-26
Left Front Side Marker Lamp...........8W-80-27
Left Front Wheel Speed Sensor..........8W-80-27
Left Headlamp......................8W-80-27
Left Headlamp Leveling Motor..........8W-80-27
Left Instrument Panel Speaker..........8W-80-28
Left License Lamp...................8W-80-28
Left Park/Turn Signal Lamp............8W-80-28
Left Power Mirror....................8W-80-29
Left Rear Door Lock Motor.............8W-80-29
Left Rear Fog Lamp..................8W-80-29
Left Rear Speaker....................8W-80-29
Left Rear Wheel Speed Sensor..........8W-80-30
Left Repeater Lamp..................8W-80-30
Left Tail/Stop Lamp..................8W-80-30
Left Tail/Stop/Turn Lamp..............8W-80-30
Left Turn Signal Lamp................8W-80-30
License Lamp.......................8W-80-31
Map/Reading Lamps..................8W-80-31
Park/Neutral Position Switch...........8W-80-31
Passenger Power Window Motor.........8W-80-31
Passenger Power Window Switch........8W-80-31
Passenger Side Airbag................8W-80-31
Power Folding Mirror Relay............8W-80-32Component Page
Power Mirror Switch..................8W-80-32
Power Mirror Switch-C1...............8W-80-32
Power Mirror Switch-C2...............8W-80-32
Power Steering Pressure Switch.........8W-80-32
Power Sunroof Motor.................8W-80-33
Powertrain Control Module-C1..........8W-80-33
Powertrain Control Module-C2..........8W-80-34
PRNDL Lamp.......................8W-80-35
Radiator Fan Motor..................8W-80-35
Radio-C1...........................8W-80-35
Radio-C2...........................8W-80-35
Rear Fog Lamp Switch................8W-80-36
Rear Window Defogger Switch..........8W-80-36
Remote Keyless Entry Module-C1........8W-80-36
Remote Keyless Entry Module-C2........8W-80-36
Right Airbag Impact Sensor............8W-80-37
Right Back-Up Lamp.................8W-80-37
Right Fog Lamp.....................8W-80-37
Right Front Door Speaker..............8W-80-38
Right Front Side Marker Lamp.........8W-80-38
Right Front Wheel Speed Sensor........8W-80-38
Right Headlamp.....................8W-80-38
Right Headlamp Leveling Motor.........8W-80-38
Right Instrument Panel Speaker........8W-80-39
Right License Lamp..................8W-80-39
Right Park/Turn Signal Lamp...........8W-80-39
8W - 80 - 2 8W - 80 CONNECTOR PIN-OUTSPL

Component Page
Right Power Mirror...................8W-80-39
Right Rear Door Lock Motor............8W-80-40
Right Rear Fog Lamp.................8W-80-40
Right Rear Speaker...................8W-80-40
Right Rear Wheel Speed Sensor.........8W-80-40
Right Repeater Lamp.................8W-80-40
Right Tail/Stop Lamp.................8W-80-40
Right Tail/Stop/Turn Signal Lamp.......8W-80-41
Right Turn Signal Lamp...............8W-80-41
Seat Belt Switch.....................8W-80-41
Solid State Fan Relay.................8W-80-41
Stop Lamp Switch....................8W-80-42
Sunroof Slide Switch..................8W-80-42Component Page
Sunroof Vent Switch..................8W-80-42
Throttle Position Sensor...............8W-80-42
Torque Converter Clutch Solenoid........8W-80-43
Trunk Lamp........................8W-80-43
Turn Signal/Hazard Switch.............8W-80-43
Underhood Lamp....................8W-80-43
Upstream Heated Oxygen Sensor........8W-80-43
Vapor Canister Leak Detector...........8W-80-43
Vehicle Speed Control Servo............8W-80-44
Vehicle Speed Sensor.................8W-80-44
Windshield Washer Pump Motor.........8W-80-44
Wipe/Wash Switch....................8W-80-44
Wiper Motor........................8W-80-44
PL8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 3

CAV CIRCUIT FUNCTION
1 C3 16DB/BK A/C COMPRESSOR CLUTCH RELAY OUTPUT
2 Z1 18BK GROUND
CAV CIRCUIT FUNCTION
1 C21 22DB/OR A/C CYCLING SWITCH OUTPUT
2 F20 22WT FUSED IGNITION SWITCH OUTPUT (RUN)
3 C2 22DB/YL MODE SWITCH OUTPUT
BLACK
31
CAV CIRCUIT FUNCTION
1 C1 14DG FUSED IGNITION (RUN)
2 C7 14BK/TN HIGH BLOWER MOTOR DRIVER
BLACK
71
CAV CIRCUIT FUNCTION
1Z8 14BK/VT GROUND
Z8 18BK/VT GROUND
2 C7 14BK/TN HIGH BLOWER MOTOR DRIVER
3 C6 14LB M2 BLOWER MOTOR DRIVER
4 C5 14LG M1 BLOWER MOTOR DRIVER
5 C4 14TN LOW BLOWER MOTOR DRIVER
6 C2 22DB/YL* MODE SWITCH OUTPUT
7E2 20OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
* A/C
CAV CIRCUIT FUNCTION
1 C20 20BR/OR A/C SWITCH SENSE
2 C22 20DB/WT LOW PRESSURE SWITCH OUTPUT BLACK211
BLACK
2
EXCEPT BUILT-UP-EXPORT
21
A/C COMPRESSOR
CLUTCH
A/C CYCLING
SWITCH
A/C - HEATER
BLOWER MOTOR
A/C - HEATER
CONTROL
A/C HIGH
PRESSURE
SWITCH
BUILT-UP-EXPORT E2 20OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
8W - 80 - 4 8W-80 CONNECTOR PIN-OUTSPL
J988W-1PL008004

CAV CIRCUIT FUNCTION
1 C22 20DB/WT LOW PRESSURE SWITCH OUTPUT
2 C21 20DB/OR A/C CYCLING SWITCH OUTPUT
BLACK
12
CAV CIRCUIT FUNCTION
1 R45 18DG/LB DRIVER AIRBAG SQUIB LINE 2
2 R43 18BK/LB DRIVER AIRBAG SQUIB LINE 1
3- -
4- -
5 R42 18BK/YL PASSENGER AIRBAG SQUIB LINE 1
6 R44 18DG/YL PASSENGER AIRBAG SQUIB LINE 2
7- -
8- -
9 R41 18BK/TN AIRBAG WARNING LAMP DRIVER
10 Z6 18BK/PK GROUND
11
12
17 F15 18DB/WT FUSED IGNITION (ST-RUN)
18 D2 20WT/BK CCD BUS (-)
19 D1 20VT/BR CCD BUS (+)
20 F25 18TN/LG FUSED IGNITION SWITCH OUTPUT (RUN)
11 1
22 12
YELLOW
- -
- -
- -
13
14--
- -
15
16--
A/C LOW
PRESSURE SWITCH
AIRBAG CONTROL
MODULE
PL8W-80 CONNECTOR PIN-OUTS 8W - 80 - 5
PL008005J988W-1

CAV CIRCUIT FUNCTION
1 E2 22OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
2 Z3 20BK/OR GROUND BLACK12
GRAY
CAV CIRCUIT FUNCTION
A L1 18VT/BK* REVERSE LAMP SENSE
B F20 18WT* FUSED IGNITION SWITCH OUTPUT (RUN)
AB AB
CAV CIRCUIT FUNCTION
1 K4 18BK/LB SENSOR GROUND
2 G31 18VT/LG AMBIENT TEMPERATURE SENSOR SIGNAL
2
1 54
3
CAV CIRCUIT FUNCTION
1 C5 14LG M1 BLOWER MOTOR DRIVER
2 C6 14LB M2 BLOWER MOTOR DRIVER
3- -
4 C7 14BK/TN HIGH MOTOR BLOWER DRIVER
5 C4 14TN LOW MOTOR BLOWER DRIVER
3 25 4
1NATURAL
CAV CIRCUIT FUNCTION
A G9 18GY/BK RED BRAKE WARNING LAMP DRIVER
B Z1 18BK GROUND
BLACK
AB12
BLACK
REVERSE LAMP SENSE 20VT/BK** L1 A
20WT** F20 B
FUSED IGNITION SWITCH OUTPUT (RUN)
GROUND 20BK Z1 BRED BRAKE WARNING LAMP DRIVER 20GY/BK G9 AFUNCTION CIRCUIT CAVAB
BLACK
* LHD
** RHD
ASH
RECIEVER
LAMP
BACK-UP LAMP
SWITCH (MTX)
BATTERY
TEMPERATURE
SENSOR
BLOWER MOTOR
RESISTOR
BLOCK
BRAKE WARNING
LAMP SWITCH (LHD)
BRAKE WARNING
LAMP SWITCH (RHD)
8W - 80 - 6 8W-80 CONNECTOR PIN-OUTSPL
J988W-1PL008006

CAV CIRCUIT
1 A1 14RD
2 A2 12PK/BK
3 A3 12RD/WT
4 A4 14BK/RDCAV CIRCUIT
1 A1 14RD
2 A2 12PK/BK
3 A3 12RD/WT
4 A4 14BK/RD BLACK
BLUE
BLACK
BLUE
12
3421
43
716
1816 7
81 CAV CIRCUIT
1 A41 14YL
2 C21 20DB/OR
3 L61 22LG
4 V10 18BR
5 X3 18BK/RD
6 F12 20DG/WT
7-
8-
9L39 20LB/WT
10
11D1 18VT/BR
12
D2 20WT/BK
13L50 20WT/TN
14 L3 16RD/OR
15 -
16 -CAV CIRCUIT
1 A41 14YL
2 C21 22DB/OR
3 L61 22LG
4 V10 18BR
5X3 20BK/RD
X3 20BK/RD
6 F12 20DG/WT
7-
8-
9 L39 22LB/BK
10
11 D1 20VT/BR
12 D2 20WT/BK
13 L50 20WT/TN
14 L3 14RD/OR
15 -
16 - BROWN
BROWN
716
1816 7
81
CAV CIRCUIT
1
2 G9 18GY/BK*
3F20 18WT**
4 G6 20GY
5G7 20WT/OR
G7 20WT/OR
6 G12 20TN/BK
7 G20 20VT/YL
8 G21 20GY/LB
9 L60 22TN
10 V37 20RD/LG
11 G3 20BK/PK
12
13M1 18PK
M1 20PK
14 L9 18BK/WT
15 L44 18VT/BK
16 L43 18VTCAV CIRCUIT
1 G19 22LG/OR
2 G9 22GY/BK
3 F20 20WT
4 G6 22GY
5 G7 22WT/OR
6 G12 22TN/BK
7 G20 22VT/YL
8 G21 22GY/LB
9 L60 22TN
10 V37 22RD/LG
11 G3 22BK/PK
12
13 M1 22PK
14 L9 22BK/WT
15 L44 20VT/RD
16L43 18VT
C101 C101
C102
C102
C103
C103
18WT/BK D2 20VT/BR D1
G19 20LG/BR~
20BR/RD L35
22BR/YL L13
22BR/YL** L13
22WT/TN L50
20BR/RD L35
L13 20BR/YL
G9 20GY/BK**
F20 20WT*
**
F61 18WT/OR
F61 18WT/OR
L43 20VT * LHD
** RHD
EXCEPT BUILT-UP-EXPORT
BUILT-UP-EXPORT
ATX
MTX
ABS
9
139
2
F20 20WT
22WT/OR G7
22PK M1
PL8W-80 CONNECTOR PIN-OUTS 8W - 80 - 7
PLI08007J988W-1