Page 2257 of 3229
Publi s hed: 11-May-2011
Glass, Frames and Mechanisms - Rear Door Fixed Window Glass
Removal and Inst all ati on
Removal
Lower the door glas s t o the bot tom of the door.1.
Di sconnect t he bat t ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -General Informat ion, Specificati ons).
2.
Remove t he rear door t rim panel.
Refer t o: Rear Door Tri m Panel (501-05 Int erior Tri m andOrnament ati on, Removal and Ins tal lat ion).
3.
Remove t he rear door frame trim.4.
Remove t he 2 nuts .Remove t he 2 Torx screws .Releas e t he glas s channel lini ng.
5.
Page 2258 of 3229
Installation
Inst all t he rear door window fixed glas s and t ighten t he nuts and
Torx screws evenly.
T orque: 5 Nm 1.
Inst all t he door frame trim.
2.
Inst all t he rear door t rim panel.
Refer t o: Rear Door Tri m Panel (501-05 Int erior Tri m and
Ornament ati on, Removal and Ins tal lat ion).
3.
Connect t he batt ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -
General Informat ion, Specificati ons).
4.
Page 2320 of 3229

Publi s hed: 22-Nov-2011
Handles, Locks, Latches and Entry Systems - Locks, Latches and Entry
Systems
Diagnosi s and Tes ti ng
Principle of Operation
For a detail ed descripti on of the locks , lat ches and ent ry s ys tems and operat ion, refer to the relevant Des cri pt ion andOperat ion s ect ion of t he works hop manual. REFER to: Handles , Locks , Lat ches and Ent ry Sys tems (501-14 Handles , Locks ,Latches and Ent ry Sys t ems, Des cri pt ion and Operati on).
Inspection and Verification
CAUTION: Di agnos is by s ubs ti tut ion from a donor vehicle is NO T acceptabl e. Subs ti tut ion of cont rol modules doesnot guarant ee confirmat ion of a faul t and may al so caus e addit ional fault s in the vehicle bei ng checked and/or the donorvehi cl e.
• NOTE: Check and recti fy bas ic faul ts before beginni ng diagnos t ic rout ines i nvol vi ng pinpoint t es t s.
1. Verify t he cus t omer concern.1.
2. Vis ually ins pect for obvious s igns of mechani cal or electrical damage.2.
Visual Inspection
MechanicalElectricalIncorrectl y aligned door(s ), hood or tai lgateFuel fil ler door lock act uat orHood rel ease handleHood rel ease cablesHood l at ch(es )Exterior door handle(s)Interi or door handle(s )Cable(s)Tail gat e release swit chRear window release s wit ch
Fus esW i ri ng harnessW i ri ng connect or(s )Door l ock act uat or(s )Remote trans mi tt er (key-fob or smart key)Cent ral l ocking s wi tchesCont rol ler Area Net work (CAN) circui tsRadi o frequency (RF) recei verCent ral junct ion box (CJB)Loos e or corroded connect ions
3. If an obvious cause for an obs erved or report ed concern is found, correct t he caus e (if pos s ible) beforeproceeding t o t he next s t ep.3.
4. If t he caus e is not vis ually evi dent , verify t he sympt om and refer t o t he Sympt om Chart, al ternat ively check forDi agnos ti c Trouble Codes (DTCs) and refer t o t he DTC Index.4.
Symptom Chart
SymptomPossible causesActionDoor(s ) wil l not openfrom out s ideExt erior door handl econdit ion/i nst all at ionExt erior release cabl edi s connect ed from ext eriordoor handl e or door l atchDoor l at ch fai lure
Check the ext eri or door handl e condi ti on andi nst all at ionCheck the condit ion and s ecurit y of t he ext eri orreleas e cabl eCheck the operat ion of t he l at ch GO to Pi npoi nt Tes tA.
Door(s ) wil l not openfrom ins ideChi ld l ock(s) engagedInt erior door handlecondit ion/i nst all at ionInt erior rel ease cabledi s connect ed from interiordoor handl e or door l atchDoor l at ch fai lure
Check that t he chi ld locks are dis engagedCheck the interior door handle condit ion andi nst all at ionCheck the condit ion and s ecurit y of t he int eriorreleas e cabl eCheck the operat ion of t he l at ch. GO t o Pinpoint Tes tA.
The mes s age cent eri ndi cat es that t he hood,t he tai lgate or a door i sopen when it appears t obe clos ed
Incorrect s trikeral ignment/adjus tmentAjar s wit ch ci rcuit s hortci rcuit t o groundAjar s wit ch fail ure
Check/adjus t the st ri kers as neces s aryCheck for DTCs i ndi cat ing an ajar swit ch fault . Refert o t he DTC i ndex
Vehicle indicates ami s s-lock when t hehood, t ail gat e and doorsappear t o be clos ed
Fuel flap does notl ock/unlockFuel fl ap cabl e detached frombodyFuel fl ap act uator detachedfrom mounti ng bracketFuel fl ap act uatordi s connect edFuel fl ap act uator fai lure
Check the condit ion and i nst all at ion of t he fuel flapcableCheck the securi ty of t he fuel flap actuat or andbracketCheck the securi ty of t he actuator elect ricalconnect orCheck for DTCs i ndi cat ing a fuel fl ap act uator faul t.Refer t o t he DTC i ndex
Page 2332 of 3229
Publi s hed: 11-May-2011
Handles, Locks, Latches and Entry Systems - Front Door Latch
Removal and Inst all ati on
Removal
Di sconnect t he bat t ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -General Informat ion, Specificati ons).
1.
Remove t he window mot or and regulat or as s embly.
Refer t o: Front Door W indow Regulat or and Mot or (501-11 Glas s,Frames and Mechanis ms , Removal and Inst all at ion).
2.
3. CAUTION: Releas e t he ext eri or door handl e and s crew covercli ps from i nsi de the door.
Remove t he front door exterior handl e.
Refer t o: Ext eri or Front Door Handle (501-14 Handles , Locks, Lat chesand Entry Syst ems , Removal and Inst all at ion).
3.
Releas e t he remot e cont rol cable.4.
Releas e t he door exterior handl e mechani s m.5.
Remove t he front door lat ch ass embl y.6.
Page 2334 of 3229
Set the ext eri or handle mechanis m. Rotat e t he lever.
Engage the retai ni ng t ang.4.
Inst all t he door l atch and t ighten the s crews .
T orque: 10 Nm 5.
Inst all t he door exterior handl e mechani s m.
6.
Pos it ion t he remot e control cable t o t he door.
7.
Inst all t he front door exterior handl e.
Refer t o: Ext eri or Front Door Handle (501-14 Handles , Locks, Lat ches
and Entry Syst ems , Removal and Inst all at ion).
8.
Inst all t he window mot or and regulat or as s embly.
Refer t o: Front Door W indow Regulat or and Mot or (501-11 Glas s,
Frames and Mechanis ms , Removal and Inst all at ion).
9.
Connect t he batt ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -
General Informat ion, Specificati ons).
10.
Page 2335 of 3229
Publi s hed: 11-May-2011
Handles, Locks, Latches and Entry Systems - Rear Door Latch
Removal and Inst all ati on
Removal
Di sconnect t he bat t ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -
General Informat ion, Specificati ons).
1.
Remove t he window mot or and regulat or as s embly.
Refer t o: Rear Door W i ndow Regul ator and Motor (501-11 Gl as s ,
Frames and Mechanis ms , Removal and Inst all at ion).
2.
3. CAUTION: Releas e t he ext eri or door handl e and s crew cover
cli ps from i nsi de the door.
Remove t he rear door ext erior handle.
Refer t o: Ext eri or Rear Door Handl e (501-14 Handl es, Locks , Latches
and Entry Syst ems , Removal and Inst all at ion).
3.
Releas e t he remot e cont rol cable.
4.
Releas e t he door exterior handl e mechani s m.
5. Remove t he rear door l atch as s embly.
6.
Page 2337 of 3229
Refer t o:
Ext eri or Rear Door Handl e (501-14 Handl es, Locks , Latches
and Entry Syst ems , Removal and Inst all at ion).
Inst all t he window mot or and regulat or as s embly.
Refer t o: Rear Door W i ndow Regul ator and Motor (501-11 Gl as s ,
Frames and Mechanis ms , Removal and Inst all at ion).
8.
Connect t he batt ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -
General Informat ion, Specificati ons).
9.
Page 2344 of 3229
Publi s hed: 11-May-2011
Wipers and Washers -
C apacitiesItemCapacity (liters/pints/US quarts)
Windscreen washer reservoir:
W it h headl amp was h5.8/10.2/6.1W it hout headl amp was h3.1/5.5/3.3
General SpecificationItemSpecification
Front wi per mot orVal eo
Power washer pump makeKaut ex Text ronRain sens orBonded t o i nner s urface of t he wi nds creen behind t he int eri or mirror
Rear wiper mot orVal eo
Torque Specifications
DescriptionNMlb-ftFront wi per arms t o li nkage nut4533
Rear window wi per motor nuts107
Rear wiper arm t o mot or nut75W iper linkage t o body bol ts86
W as her res ervoir and pump as s embly t o body bolt s64
W as her res ervoir and pump as s embly t o bumper armat ure bol ts64W as her res ervoir fil ler neck s upport bolt43
W indshi el d wi per mot or bolt s107