8. Remove the flat head screws.
Screw two 8x12 mm bolts into the disc to push it
away from the hub.
NOTE: Turn each bolt two turns at a time to pre-
vent cocking the disc excessively.
FLAT HEAD SCREW
6 x 1.0 mm
10 N .
m (1.0 kg-m, 7 Ib-ft)
BRAKE DISC
8x12 mm
BOLT
9. Remove the rear hub unit from the knuckle.
FLANGE BOLT
10 x
1.25
mm
65 N .
m (6.5 kg-m, 47 Ib-ft)
REAR HUB UNIT
Corrosion resistant bolt/nut
Rear Wheels Bearing Replacement:
1. Separate the wheel bearing from the hub using the special tools and a press.
CAUTION: Hold onto the hub to keep it from fall-
ing when pressed clear.
Press
HUB DIS/ASSEMBLY
BASE
07GAF—SD40700
HUB DIS/ASSEMBLY PIN
07GAF—SD40100
WHEEL BEARING
Replace.
HUB
2. Remove the wheel bearing inner race from the hub
using a commercially available bearing puller.
HUB DIS/ASSEMBLY PIN
07GAF—SD40100
INNER RACEReplace.
NOTE: Wash the bearing and hub thoroughly in
high flash point solvent before reassembly. (cont'd)ProCarManuals.com
Under-Dash Fuse Box
Removal/Installation
CAUTION;
Be sure to install the SRS wiring so that it is not
pinched or interfering with other car parts.
Always keep the short connector on the airbag con-
nector when the harness is disconnected.
Removal:
1. Disconnect both the negative cable and positive ca-
ble from the battery.
2. Remove the maintenance lid A below the airbag,
then remove the short connector.
SHORT CONNECTOR
MAINTENANCE LID A
3. Disconnect the connector between the airbag and
cable reel.
4. Connect the short connector to the airbag side of
the connector.
STEERING WHEEL
AIRBAG CONNECTOR
CABLE REEL CONNECTOR
SHORT CONNECTOR (RED)
5. Remove the door sill molding.
6. Remove the kick panel trim pieces, as necessary.
7. Remove the under-dash fuse box mounting bolts.
8. Disconnect the under-dash fuse box connectors.
NOTE: The SRS main harness connector is double
locked. To remove it, first lift the connector lid with
a thin screwdriver, then press the connector tab
down and pull the connector out.
9. Take out the under-dash fuse box.
TAB
SRS FUSE
No. 1 (10 A)
SRS MAIN HARNESS
KICK PANEL TRIM
LIDProCarManuals.com
