1989 MITSUBISHI GALANT door lock

GENERAL - Vehicle Identification
OOA0192
Theft protection label
For
orIgInal parts
OOK619
For replacement parts
OOK621
VEHICLE SAFETY CERTIFICATION LABEL MWCF-
1.The vehicle safety certification label is attached to face of left door pillar.
2. This label indicates Gross Vehicle Weight Rating
(G.V.
W.R.), Gross Axle Weight Rating (G.A.W.R.) front, rear and
Vehicle Identification Number
(V.I.N.).
ENGINE MODEL STAMPINGM6ocG-.
1.The engine model number is stamped at the front side on the top edge of the cylinder block as shown in the
following.
Engine model Engine displacement 4G63
2.0
dm3 (122 cu.in.)
2. The engine serial number is stamped near the engine
model number, and the serial number cycles, as shown
below.
THEFT PROTECTION
MwclA9
In order to protect against theft, a Vehicle ldentificatlon
Number
(VIN) is stamped in, or attached as a label to, the
following major parts of the engine and transaxle. as
well as
main outer panels:
Engine cylinder block, Transaxle housing, Fender, Door, Quar-
ter panel, Hood, Trunk lid, Bumpers
In addition, a theft-protection label is attached to replacement
parts for the body outer panel main components, and the same
data are stamped into replacement parts for the engine and the
transaxle.
Cautions regarding panel repairs
1. When repainting original parts, do so after first mask-
ing the theft-protection label, and, after painting, be
sure to peel off the masking tape.
2. The theft-protection label for replacement parts is
covered by masking tape, so such parts can be painted
as is. The masking tape should be removed after
painting is finished.
3.The theft-protection label should not be removed from
original parts or replacement par-&

GENERAL -Lubrication and Maintenance/Recommended Lubricants and Lubricant Capacities Table00-35
If premium unleaded gasoltne IS not available,
MATERIALS ADDED TO FUEL
unleaded gasoline having a octane rating of 87 or
91 RON (Research Octane Number) may be used. Indiscriminate use of fuel system cleaning agents
In this case, the performance and fuel consumption should be avoided. Many of these materials
in-
WIII suffer a little degradatron.tended for gum and varnish removal may contain
highly active
solvents or similar ingredients that can
be harmful to gasket and diaphragm materials used
in fuel system component parts.
Gasolines containing alcohol
Some gasolrnes sold at service stations contain
alcohol, although they may not be SC identified. Use
of fuels containing alcohol is not recommended
unless the nature of the blend can be
determrned
as being satisfactory.
Gasohol
- A mixture of 10% ethanol (grain alcohol)
and 90% unleaded gasoline may be used
In your
car. If
driveability problems are experienced as a
result of using gasohol, it IS recommended that the
car be operated on gasoline. Methanol
- Do not use gasolines containing
methanol (wood alcohol). Use of this type of
alcohol can result in vehicle performance deteriora-
tion and damage critical parts in the fuel system
components. Fuel system damage and performance
problems, resulting from the use of gasolines
containing methanol, may not be covered by the
new car warranty.
Gasolines containing MTBE (Methyl Tertiary Butyl
Ether)
Unleaded gasolrne containrng
15% or less MTBE
may be used in your car. (Fuel containing MTBE
over 15% vol. may cause reduced engine per-
formance and produce vapor lock or hard starting.) RECOMMENDED

LUBRICANTS AND
LUBRICANT CAPACITIES TAB,&-
RECOMMENDED LUBRICANTS
Items
Engine Oil
Recommended lubricants
API classification SG or SGKD (For further details, refer to SAEviscosity number)
Manual Transaxle, Transfer

Rear Axle
API classification GL-4 or higher, SAE 75W-85W
Refer to P.OO-37.
Automatic Transaxle
Power Steering
Brake and Clutch
Engine Coolant DIAMOND ATF SP or equivalent
Automatic transmission fluid “DEXRON II” Conforming to
DOT3 or DOT4
DIA-QUEEN LONG-LIFE COOLANT (Part No. 0103044) or High
qualitv ethvlene-qlvcol
antifreeze coolant
Door HingesEngine oil
1 TSB Revision

00-46GENERAL - Table of Main Sealants and Adhesives
TABLEOF MAINSEALANTS
AND
ADHESIVES
MONA--
Application Recommended brand
1. Sealing for engine accessory parts 3M
ATD Part No.8660
or equivalent
(1) Sealing
for semi-circular packing of rocker cover and
cylinder head
(2) l
Sealrng for semi-circular packing and rocker cover, 3M
ATD Part No.8660
or equivalent
cylinder head
l Oil pressure switch
(3) l Engine coolant temperature switch l Engine coolant temperature sensor
l Thermal vacuum valvel Therm0
switch
l Engine coolant temperature gauge unit
l Joint 3M
Nut Locking Part
No.4171 or equivalent
(4) Oil pan MITSUBISHI GENUINE Part No.MD997110
or
equivalent
2. Sealing for weatherstrip
(1) l Sealing of tempered glass and weatherstrip 3M
ATD Part No. 8513 or equivalent
l Sealing
of body flange and weatherstrip 3M
ATD Part No.8509
or equivalent
(2) Sealing of laminated glass and weatherstrip 3M
ATD Part No.8509
or equivalent
3. Gluing with ribbon sealer l Door waterproof film
l Fender panel
l Splash shield
l Mud guard 3M
ATD Part No.8625
or equivalent
l Rear combination light TSB Revision

2ALPHABETICAL INDEX
BRAKE LINING ThicknessCheck

.., ..,............
Drum, Rear, Maintenanc
e
BRAKE LINING AND BRAKE DRUM, Connection Check..
BRAKE PAD
Drsc, Front, Check and Replacemen
t
Disc, Rear, Check and Replacement BRAKEPEDAL..
BRAKE PEDAL, Inspection and Adjustment
BUMPER..... 35-67-l
00-44-l
35-67-l
35-59-l
35-65-l
35-76-l
35-53-l
51-7-I
C
CABLEAccelerator, Inspection and Adjustment
13-398-l
Accelerator, Inspection and Adjustment Control> 13-329-I
High
Tensron, Spark Test ........
.
16-42-11Parking Brake................................

.
36-5-l
Spark
Plug, Tes
t
........................
16-42-11Speedometer, Replacement ...............
.
23-93-l
Speedometer, Replacement
.........
.
22-19-I
Speedometer, Replacement
............
.
22-5-l
CAMSHAFTDOH

C
...................
1 l-68-lSOHC.................................

.
11-19-I
CAMSHAFT OIL SEALS
DOHC
...................................
.
11-68-I
SOHC........................................

.
11-19-I
CAMSHAFT POSITION SENSOR
On-vehrcle Inspection
..................
.
13-277-l
On-vehicle Inspection
............
.
13-69-l
On-vehicle Inspection
........
.
13-165-I
CANISTER,
Evaporatjve Emission.................

.
17-21-l
CATALYTIC CONVERTER............................

.
17-24-l
CENTERMEMBER...................

.
....... 32-8-l
CENTRAL DOOR LOCKING SYSTEM..................

.
42-101-I
CHARGE AIR COOLER...............................

.
15-l

2-l
CHARGING..................
.
..... 55-17-I
CHARGING SYSTEM....................

.
...........
16-2-11CHARGING SYSTEM, Inspection.......................
.
16-5-11CHECK VALVE, Operation Check......................

.
35-54-l
CIGARETTE LIGHTER..........................

.
54-106-11
CLOCK........................................
.
54-109-11CLOSED THROTTLE POSITION SWITCHAdjustment GVALVE>
.................. 13-136-I
Frxed SAS, Adjustment
..................
.
13-250-I
On-vehicle inspection .................. 13-274-l
On-vehicle Inspection
............
.
13-61-I
On-vehicle Inspection

.........
. 13-160-I
CLUTCH CONTROL.................................

.
21-10-I
CLUTCH MASTER CYLINDER.........................

.
21-12-l
CLUTCH PEDAL.....................................

.
21-7-l
CLUTCH PEDAL, Inspection and Adjustment ................
21-5-1CLUTCH RELAY, A/C Compressor, On-vehicle Inspection
>
....................................... 13-285-l
CLUTCH RELEASE CYLINDER.........................
21-13-lCOIL
Ignition, On-vehicle
Inspectron 13-302-I
Ignition, On-vehicle
InspectIon
......
. 13-96-l
Ignition. On-vehicle Inspection
13-186-l
COLUMN SWITCH............................

.
54-100-11COMBINATION LIGHT, Rear.
.........................
.
54-95-11COMPRESSION PRESSURE
Check
...............................
.
1
i-59-1Check
..................................
11-8-l
COMPRESSOR...................................
.
55-38-l
COMPRESSOR, Air.......

.
........................ 338-125-I
COMPRESSOR DRIVE BELT, Adjustment, ................. 55-17-l
COMPRESSOR NOISE, Adjustment ...................... 55-23-l
CONDENSER, ............ .......................... 55-48-l
CONDENSER FAN MOTOR...........................

.
55-48-l
CONSOLE, Floor....................................

.
52-29-l
CONTROL
Engine
........................................
.
13-328-l
Transaxle ............................... 23-94-l
Transaxle
..........................
.
22-19-I
Transaxle
...........................
.
22-6-l
CONTROL SYSTEM
Evaporative Emission
.............................
.
17-15-l
Intake Charge Pressure, Inspection.
....................
15-7-lMixture (MFI
)
.............................. 17-29-l
Purge, Inspection .................... 17-17-l
Purge, Inspection ....................... 17-18-l
CONTROL UNIT
ABS
........................................
.
35-134-l
Active-ECS ................................... 338-140-I
EPS.....................................

.
...37A-59-lCONTROL VALVE <4WS>..........................

.
378-12-I
COOLANT
Engine, Concentration Test ..........................
14-8-lEngine, Leak Check ................................
.
14-8-l
Engine, Maintenance. ............................ 00-44-I
Engine, Replacement ...........
................... 14-8-lCRANKCASE VENTILATION SYSTEM, inspection..........

.
17-14-l
CRANKSHAFT POSITION SENSOR
On-vehicle Inspection
..................
.
13-280-I
On-vehicle Inspection
............
.
13-73-l
On-vehicle Inspection
13-167-l
CROSSMEMBER....................................

.
32-8-l
CURB IDLE SPEED
Inspection
.......
.
.................... 13-245-l
Inspection
13-32-l
Inspection
....................
.
13-133-l
CYLINDER
Master
.........................................
.
35-81 -IPower
.........................................
.
378-9-I
Wheel,RearBrake...............................

. 35-111-l
Wheel, Rear, Maintenance .......................... 00-44-I
CYLINDER HEAD GASKET
DOHC
.......................................
.
11-73-l
SOHC.................: ......................... 11-25-l
D
DASH POT, Inspection and Adjustment
1 l-58-lDEFOGGER, Rear Window 64-156-11
DEFOGGER RELA
Y
.54-163-11DEFOGGER SWITCH, Rear Window. 54-163-11
DEFOGGER TIMER 54-164-11
DELAY VALVE, Check
35-74-l
DIAPHRAGM, Rolling, Check 33B-89-l
DIFFERENTIAL CARRIER
27-26-l
DISC
Brake, Front, Run-out Check
35-63-l
Brake, Front, Run-out Correction 35-64-l
Brake, Front.
Thichness Check 35-65-l
Brake, Rear, Run-out Check 35-66-l
Brake, Rear, Run-out Correction 35-66-l
Brake, Rear,
Thichness Chec
k
35-66-l

ALPHABETICAL INDEX5
Fuel, Maintenance.
.
Power Steering
Transaxle
011 Cooler
Vacuum
..,...,..,.......
Water >
Water
Water
HUB
End Play inspection
End Play, Inspection
Front Axl
e
Rear Axle

Rear Axle

>
HYDRAULIC UNIT
HYDRAULIC UNIT, Inspection
I 00-39-I
37A-58-I
23-l
00-l
17-4-I
14-26-I
14-28-l
14-23-l
338-86-I
26-5-l
26-l-l
27-8-l
27-6-1
35-121-l
35-70-t
IAC VALVE POSITION SENSOR, On-vehicle Inspection........................

.
13-162-l
IDLE AIR CONTROL MOTOR
DC Motor,
On-vehicle
Inspection
13-184-I
Stepper Motor, On-vehicle Inspection ....... 13-298-l
IDLE SPEED
Basic, Adjustment
.....................
.
13-245-l
Basic, Adjustment
...............
.
13-33-l
Basrc. Adjustment ...........

.
13-133-l
Curb, Inspection ................
...... 13-245-I
Curb, Inspection
..
.
...
...........
.
13-32-I
Curb, Inspection
.............
.
13-133-I
IDLE SPEED CONTROL MOTOR (DC Motor),
On-vehrcle Inspectron .............
.
13-93-l
IDLE SPEED CONTROL MOTOR POSITION SENSOR,On-vehicle Inspection ..............

.
13-64-I
IDLE-UP OPERATION, Check ....................... 55-24-l
IGNITION COIL
On-vehtcle
Inspection ................. 13-302-I
On-vehicle
Inspectron .........
.
13-96-l
On-vehicle
Inspection
.......
.
13-186-I
IGNITION POWER TRANSISTOR
On-vehrcle
Inspection ................ 13-302-I
On-vehicle Inspection
............. 13-96-l
On-vehicle
inspection .........
.
13-186-l
IGNITION SWITCH
Chassis Electrical.
...........................
.
.....
54-6-11
On-vehicle Inspection ..................
.
13-284-l
On-vehicle Inspection A/T>....
... 13-78-l
On-vehicle Inspection M/T>........ 13-77-l
On-vehicle Inspection A/T>....... 13-172-l
On-vehicle inspection GVALVE. M/T> ......
.
13-171 -IIGNITION SYSTEM...........................

.
16-32-11.....

.
IGNITION TIMING Adjustment ...........................
16-40-11
Adjustment 16-39-11.......
.
....................
INDICATOR...........................
.
.......... 33B-140-l
INDIVIDUAL PARTS, Auto-cruise Control, Inspection .......
13-401 -I
INFLATION PRESSURE, Tire, Check......................
.
31-4-l
INJECTORS
On-vehicle Inspection
..................
.
13-295-I
On-vehicle Inspection
...........
.
13-90-I
On-vehicle Inspection
........... 13-l
81-l
INSTRUMENT PANEL ................................. 52-22-l
INTAKE AIR TEMPERATURE SENSOR
Emission Control
..............................
.
17-21 -I
On-vehicle inspection
.................
.
13-263-l
On-vehicle Inspection
............
.
13-51-IOn-vehicle Inspection

INTAKE CHARGE PRESSURE CONTROL SYSTEM,Inspection . . . . . . . . . . . . . . .
INTAKE MANIFOLD
DOHC
,.. . . . . . . . . . . ,,... SOHC-WALVE
SOHC-l
GVALVE
K
KEY INTERLOCK MECHANISM, Check

.
KICKDOWN SERVO, Adjustment
KNOCK SENSOR, On-vehicle Inspection
KNUCKL
E
L
LASH ADJUSTERS
Check
>
Check
LATCHDoor, Fron
t
Door, Rear
LATERAL ROD
Active-EC
S
Rear Suspesion

LEAK, Refrrgerant. Repair Procedure
LEVELFluid, Transaxle, Inspection
Oil, Transfer, Inspection.
LEVERParking Brak
e
Parking Brake, Stroke Check
Selector, Operation Check.
Shift

Shift
LIDTrunk ._, . . . . . . . . . . . . .
Trunk, Adjustmen
t
LIGHT
......
......
......
.....
......
......
.....
......
......
......
......
......
......
......
......
......
......
......
......
......
.......
........
.......
........
........
........
........
........
........
........
........
........
........
........
........
........
........
Alarm, Chec

k
Rear Combination
Stop, High Mounted
LIGHTING SYSTEM
LINEBrake
Fuel
Fuel
Fuel
Fuel
Refrigerant
.
Vapor

Vapor
Vapor
Vapor
LINE PRESSURE, Adjustment
LININGBrake, Thickness Check.
Rear Drum Brake, Maintenance
LOOSE PANE
L
LOWER ARMActive-KS
Front Suspensio

n
Rear Suspesion

........
...............
.......
........
........
........
........
........
........
........
........
.........
.........
.........
.........
.........
........ 13-152-I
15-7-l
15-21 -I
15-14-I
15-18-I
23-83-1
23-86-i
13-287-l
26-6-l
11-57-1
1 l-7-l
42-96-l
42-99-l
338-l 17-l
34-14-I
’
55-21-I
23-82-l
23-82-l
36-4-l
36-2-l
23-83-l
22-19-l
22-9-l
42-57-l
42-50-I
338-87-I
54-95-11
54-96-11
54-38-11
35-87-I
13-326-I
13-324-I
13-113-I
13-I
95-l
55-54-l
13-326-I
13-324-l
13-I 13-l
13-195-1
23-88-l
35-67-l
00-44-I
42-62-i
338-l
03-l
33A-10-I
34-28-l

8ALPHABETICAL INDEX
ACTIVE-KS
.............................
.
338-l
41-1
Defogger ................................
.54-163-11
Horn
,
...............
54-105-11
Lightrng System............................
.
54-97-l)
Power, Check .............................. 55-24-l
RELEASE CYLINDER, Clutch.......................

.
21-13-l
REMOTE CONTROLLED MIRROR SWITCH..............

.
51-34-l
RESERVE TANK ............... 338-122-I
RESISTANCE
Rotary-sliding. Rear Hub, Adjustment .....

. 27-5-l
fiotation
Sliding, Rear Wheel Bearing, Check
..
.
27-16-l
RESISTOR
Heater, Arr Conditioning and Ventilation
............
. 55-28-l
On-vehicle
Inspection ............ 13-298-t
RHEOSTAT.....

.
.........................
54-99-11
ROD
Lateral ......................
.
338-l 17-l
Lateral ..............

. 34-14-l
ROLLING DIAPHRAGM, Check .................. 338-89-I
ROLL STOPPER, Engine...........................

. 32-6-l
ROTARY-SLIDING RESISTANCE (TORQUE), Rear Hub,Adjustment ............................

. 27-5-l
ROTATION SLIDING RESISTANCE, Rear Wheel Bearing,Check....................................

. 27-16-l
RUNCHANNEL. Door
.............................
.
42-l 10-l
RUN-OUT
Front Brake Disc, Correction ...................
. 35-64-l
Rear Brake Disc, Check ......................... 35-66-l
Rear Brake Disc, Correction ...................... 35-66-i
WheeLCheck
................................. 31-4-I
S
SAFETY PRECAUTIONS
SEALS 55-12-l
Ball Joint, Maintenance
Steering Linkage, Maintenance
SEAT
Fron
t
.._........
Rear...

.
SEAT BELT
SELECTOR LEVER, Operation Check
SENSOR
........ 00-45-I
...... 00-45-I
........
52-35-l
....... 52-37-l
.... 52-39-l
........ 23-83-l
ACTIVE-ECS Barometric Pressure, On-vehicle Inspection
. . . . . . . . . . . . . . . . . . . . . . . . 33B-138-i
13-266-l
Barometric Pressure, On-vehicle inspection
13-53-l
Barometric Pressure, On-vehicle Inspection
_. 13-154-l
Brake Fluld Level, Chec
k
35-54-l
Camshaft Position, On-vehicle inspection 13-277-l
Camshaft Position, On-vehicle Inspectron

13-69-l
Camshaft Position, On-vehicle Inspection
13-l
65-l
Crankshaft Position, On-vehicle Inspection 13-280-I
Crankshaft Position, On-vehicle Inspection
13-73-l
Crankshaft Position, On-vehicle Inspection
13-167-I
EGR Temperature California 17-28-l
EGR Temperature California, On-vehicle Inspection
13-288-l
EGR Temperature California, On-vehicle Inspection
13-85-l
EGR Temperature California, On-vehicle Inspection
13-177-l Engine Coolant Temperature 14-31-l
Engine Coolant Temperature 17-21-l
Engine Coolant Temperature, On-vehicle Inspection . 13-268-l
Engine Coolant Temperature, On-vehicle
Inspection
13-55-l
Engine Coolant Temperature, On-vehicle Inspection

13-l 55-l
G 35-132-l
Heated Oxygen, On-vehicle Inspection 13-290-I
Height 338-135-I
IAC Valve Position, On-vehicle Inspection
13-162-l
idle Speed Control Motor Position, On-vehicle Inspection
13-64-l
Intake Air Temperature 17-21-l
Intake Air Temperature, On-vehicle Inspection 13-263-l
Intake Air Temperature, On-vehicle Inspection
13-51-l
Intake Air Temperature, On-vehicle Inspection

13-l 52-l
Knock, On-vehicle Inspection (1992 From models)>
Oxygen, On-vehicle Inspection


Oxygen, On-vehicle Inspection
Throttle Position, Adjustment >
Throttle Position, Adjustment
Throttle
Position, Adjustment
Throttle Position, Adjustment
Throttle Position, On-vehicle Inspection
13-287-1 13-87-l
13-179-l
23-92-l
13-248-l
13-35-l
13-136-I
13-270-I
Throttle Position, On-vehicle Inspection
13-57-1
Throttle Position, On-vehicle Inspection...........................
. 13-157-l
Vehicle Speed, On-vehicle Inspection ....... 13-284-l
Vehicle Speed, On-vehicle Inspection
..............................
. 13-80-I
Vehicle Speed, On-vehicle Inspection
.............................
13-l 73-l
Volume Air Flow, Emission Control ...................
.
17-21
-I
Volume Air Flow, On-vehicle Inspection ....
. 13-261-l
Volume Air Flow, On-vehicle Inspection
..............................
. 13-49-l
Volume Air Flow, On-vehicle Inspection
............................
. 13-150-I
Wheel Speed
...........................
. 35-126-l
Wheel Speed, Output Voltage Measurement ............ 35-69-l
SERVO, Kickdown. Adjustment
.......................... 23-86-l
SHAFT
Axle ..................................

. 27-17-I
Drive........................................

. 26-12-I
Drive
.................................
. 27-20-I
Propeller.......................................

. 25-4-l
Steering.......................................

. 37A-25-l
SHIFT LEVER
AWD
.........................................
. 22-19-l
FWD
22-9-l
............................................
SHIFT LOCK MECHANISM, Check......................
. 23-84-l
SHOCK ABSORBER
Active-ECS
...................................
. 338-110-l
RearSuspension........................

. 34-35-l
Rear Suspension
........................
.
34-l 1-ISOLENOID VALVE
Active-ECS
.................................
.
..33B-127- I
EGR
...............................
. 17-28-l
EGR , On-vehicle Inspection 13-307-I
EGR , On-vehicle Inspection
.............................. 13-101-I