INSTALLATION
(1) Position the mirror and install the (3) power
fold-away mirror retaining nuts (Fig. 9). Torque the
nuts to 20 N´m (177 in. lbs.).(2) Connect the power fold-away mirror electrical
connector and secure wire harness pushpin (Fig. 9).
(3) Verify mirror operation.
(4) Install the front door trim panel. Refer to
Group 23, BODY for the procedure.
(5) Connect the negative battery cable.
Fig. 9 Power Fold-Away Mirror Mounting - Right
Side
1 ± POWER MIRROR RETAINING NUTS
2 ± RIGHT FRONT DOOR
3 ± POWER MIRROR ELECTRICAL CONNECTOR
4 ± WIRE HARNESS PUSHPIN
8T - 4 POWER MIRRORSPL
REMOVAL AND INSTALLATION (Continued)
WIRING DIAGRAMS
TABLE OF CONTENTS
page page
AIR CONDITIONING-HEATER........... 8W-42-1
AIRBAG SYSTEM.................... 8W-43-1
ANTI-LOCK BRAKES.................. 8W-35-1
AUDIO SYSTEM..................... 8W-47-1
CHARGING SYSTEM.................. 8W-20-1
COMPONENT INDEX.................. 8W-02-1
CONNECTOR PIN-OUTS............... 8W-80-1
CONNECTOR/GROUND LOCATIONS...... 8W-90-1
FRONT LIGHTING.................... 8W-50-1
FUEL/IGNITION SYSTEM.............. 8W-30-1
FUSE BLOCK........................ 8W-11-1
GENERAL INFORMATION.............. 8W-01-1
GROUND DISTRIBUTION.............. 8W-15-1
HORN/CIGAR LIGHTER/POWER OUTLET . . 8W-41-1
INSTRUMENT CLUSTER............... 8W-40-1INTERIOR LIGHTING.................. 8W-44-1
POWER DISTRIBUTION............... 8W-10-1
POWER DOOR LOCKS................ 8W-61-1
POWER MIRRORS................... 8W-62-1
POWER SUNROOF................... 8W-64-1
POWER WINDOWS................... 8W-60-1
REAR LIGHTING..................... 8W-51-1
REAR WINDOW DEFOGGER............ 8W-48-1
SPLICE INFORMATION................ 8W-70-1
SPLICE LOCATIONS.................. 8W-95-1
STARTING SYSTEM.................. 8W-21-1
TURN SIGNALS...................... 8W-52-1
VEHICLE THEFT SECURITY SYSTEM..... 8W-39-1
WIPERS............................ 8W-53-1
PLWIRING DIAGRAMS 8W - 1
(2) Connect the other lead of the voltmeter to the
other side of the switch or component.
(3) Operate the item.
(4) The voltmeter will show the difference in volt-
age between the two points.
TROUBLESHOOTING WIRING PROBLEMS
When troubleshooting wiring problems there are
six steps which can aid in the procedure. The steps
are listed and explained below. Always check for non-
factory items added to the vehicle before doing any
diagnosis. If the vehicle is equipped with these items,
disconnect them to verify these add-on items are not
the cause of the problem.
(1) Verify the problem.
(2) Verify any related symptoms. Do this by per-
forming operational checks on components that are
in the same circuit. Refer to the wiring diagrams.
(3) Analyze the symptoms. Use the wiring dia-
grams to determine what the circuit is doing, where
the problem most likely is occurring and where the
diagnosis will continue.
(4) Isolate the problem area.
(5) Repair the problem.
(6) Verify proper operation. For this step check for
proper operation of all items on the repaired circuit.
Refer to the wiring diagrams.
SERVICE PROCEDURES
WIRING REPAIR
When replacing or repairing a wire, it is important
that the correct gage be used as shown in the wiring
diagrams. The wires must also be held securely in
place to prevent damage to the insulation.
(1) Disconnect battery negative cable.
(2) Remove 1 inch of insulation from each end of
the wire.
(3) Place a piece of heat shrink tubing over one
side of the wire. Make sure the tubing will be long
enough to cover and seal the entire repair area.
(4) Spread the strands of the wire apart on each
part of the exposed wire (example 1) (Fig. 7).
(5) Push the two ends of wire together until the
strands of wire are close to the insulation (example
2) (Fig. 7).
(6) Twist the wires together (example 3) (Fig. 7).
(7) Solder the connection together using rosin core
type solder only.Do not use acid core solder.
(8) Center the heat shrink tubing over the joint,
and heat using a heat gun. Heat the joint until the
tubing is tightly sealed and sealant comes out of both
ends of the tubing.
(9) Secure the wire to the existing ones to prevent
chafing or damage to the insulation.
(10) Connect battery and test all affected systems.
Fig. 6 Testing for Voltage Drop
Fig. 7 Wire Repair
1 ± EXAMPLE 1
2 ± EXAMPLE 2
3 ± EXAMPLE 3
8W - 01 - 10 8W - 01 GENERAL INFORMATIONPL
DIAGNOSIS AND TESTING (Continued)
8W-39 VEHICLE THEFT SECURITY SYSTEM
Component Page
Data Link Connector............8W-39-3, 10, 11
Decklid Solenoid.....................8W-39-5
Dome Lamp/Intrusion Sensor..........8W-39-14
Driver Cylinder Lock Switch...........8W-39-6
Driver Door Ajar Switch...............8W-39-4
Driver Door Lock Motor...............8W-39-7
Driver Door Lock Switch..............8W-39-6
Fuse 10 (FB)......................8W-39-2, 3
Fuse 11 (FB)......................8W-39-2, 3
Fuse 13 (PDC)..................8W-39-2, 3, 14
Fuse 14 (FB)........................8W-39-2
Fuse 16 (FB)........................8W-39-2
Fuse 17 (FB)....................8W-39-12, 13
Fuse 18 (FB)....................8W-39-12, 13
Fuse 18 (PDC)...................8W-39-10, 11
Fuse Block..................8W-39-2, 3, 12, 13
G103......................8W-39-5, 10, 11, 14
G201............................8W-39-2, 3
G204..............................8W-39-2
G301..............................8W-39-5
G304..............................8W-39-5
High Note Horn..................8W-39-10, 11
Hood Ajar Switch....................8W-39-5
Horn Relay.....................8W-39-10, 11
Ignition Switch......................8W-39-4
Instrument Cluster............8W-39-4, 8, 9, 12
Instrument Panel Drivers..............8W-39-4
Left City Lamp......................8W-39-9
Left Front Side Marker Lamp..........8W-39-8Component Page
Left Headlamp...................8W-39-12, 13
Left License Lamp...................8W-39-9
Left Park/Turn Signal Lamp............8W-39-8
Left Rear Door Ajar Switch............8W-39-4
Left Rear Door Lock Motor.............8W-39-7
Left Tail/Stop Lamp..................8W-39-9
Left Tail/Stop/Turn Signal Lamp........8W-39-8
License Lamp.......................8W-39-8
Low Note Horn..................8W-39-10, 11
Passenger Cylinder Lock Switch.........8W-39-6
Passenger Door Ajar Switch............8W-39-4
Passenger Door Lock Motor............8W-39-7
Passenger Door Lock Switch............8W-39-6
Power Distribution Center . . .8W-39-2, 3, 10, 11, 14
Radio............................8W-39-8, 9
Remote Keyless Entry Module....8W-39-2, 4, 5, 6,
7, 8, 9, 10, 11, 12, 13, 14
Right City Lamp.....................8W-39-9
Right Front Side Marker Lamp.........8W-39-8
Right Headlamp.................8W-39-12, 13
Right License Lamp..................8W-39-9
Right Park/Turn Signal Lamp..........8W-39-8
Right Rear Door Ajar Switch...........8W-39-4
Right Rear Door Lock Motor............8W-39-7
Right Tail/Stop Lamp.................8W-39-9
Right Tail/Stop/Turn Signal Lamp.......8W-39-8
Sentry Key Immobilizer Module.........8W-39-3
Siren.............................8W-39-14
Trunk Key Cylinder Switch............8W-39-5
PL8W - 39 VEHICLE THEFT SECURITY SYSTEM 8W - 39 - 1
BLOCK FUSE BATT A3
10A
FUSE
10
10A
FUSE
11
5A
FUSE
16
20A
FUSE
14
LHD RHD
LHD RHD
S220
8 3
9
12 22
MODULE ENTRY
KEYLESS
REMOTE
S207
G201 G204S202
Z2
22
BK/LG
Z2
20
BK/LG
Z1
20
BK
Z1
16
BK
G5
20
DB/WT
G5
20
DB/WT
F9
20
RD/BKF35
18
RD/YLF35
18
RD
34 14
36 16
31 11
30 10
FUSED
B (+)FUSED
IGNITION
SWITCH
OUTPUT
(ST-RUN)
GROUND GROUND
ST-RUN A21
B (+) FUSED
21
CENTER
DISTRIBUTION
POWER
15A
FUSE
13
13
S103
S201
5C103B5M1
20
PK
M1
20
PK
FUSED
B (+)
LHD BUILT-UP-EXPORT
BATT A0
M1
20
PK
M1
20
PK
(8W-11-2)
(8W-11-3) (8W-10-9)
(8W-11-10) (8W-11-10) (8W-11-13)
(8W-11-14) (8W-11-13)
(8W-11-14)
(8W-11-10)
(8W-15-8)
(8W-15-8) (8W-15-11)(8W-15-11) (8W-10-10)
(8W-10-2)
(8W-10-3)
(8W-10-12)
(8W-10-12)
(8W-10-12)(8W-10-7)
8W - 39 - 2 8W-39 VEHICLE THEFT SECURITY SYSTEMPL
008W-10PLI03902
POWER
DISTRIBUTION
CENTER BLOCK FUSEST-RUN A21BATT A0
10A
FUSE
11
10A
FUSE
1013FUSE15A
30 10 11
3113
4
26
5
MODULE IMMOBILIZER
KEY
SENTRY
B5C1035
D25
20
VT/YL
D25
20
VT/YL
D25
22
VT/YL
D25
22
VT/YL
S217
C104
S104C20
20
2
CONNECTORLINK DATA
S207
G201
Z2
20
BK/LG
Z2
20
BK/LG
M1
20
PK
M1
20
PK
M1
20
PK
S220
S201 S103
G5
20
DB/WT
G5
20
DB/WT
LHD RHD
FUSED
IGNITION
SWITCH
OUTPUT
(ST-RUN)
PCI
BUS
GROUNDFUSED
B(+)
M1
20
PK
(8W-10-2)
(8W-10-3) (8W-11-2)
(8W-11-3) (8W-10-10)(8W-10-7)
(8W-11-10) (8W-11-10)(8W-10-12)
(8W-30-4)
(8W-30-4)
(8W-30-4)(8W-15-8)
(8W-15-8) (8W-11-10)
(8W-10-12) (8W-10-12)
PL8W-39 VEHICLE THEFT SECURITY SYSTEM 8W - 39 - 3
PLI03903008W-10
2324 13
5
KEY-IN
IGNITION
SWITCHSWITCH IGNITION
G26
22
LBG75
18
TNM9
20
DB/OR
CHIME RKE
ALARM
BK/OR20 G69
5
25177
MODULE ENTRY
KEYLESS
REMOTE
M9
20
LB/ORM9
20
LB/ORM9
20
LB/OR
M9
20
LB/OR
C30514 A14
DRIVER
DOOR
AJAR
SWITCHPASSENGER
DOOR
AJAR
SWITCHLEFT
REAR
DOOR
AJAR
SWITCHRIGHT
REAR
DOOR
AJAR
SWITCH
M9
20
DB/ORG75
18
TN
G75
18
TN
C305A18
18
S305 S221
S226CLUSTER INSTRUMENT
INSTRUMENT
PANEL
DRIVERS
DRIVER
DOOR
AJAR
SWITCH
SENSEVTSS
INDICATOR
DRIVERM9
20
LB/OR
G75
18
TN
SENSERKE AJAR/ DOOR PASSENGER (8W-10-8)
(8W-40-8)
(8W-40-8) (8W-40-8) (8W-40-8)(8W-40-8) (8W-40-8)
(8W-40-8)(8W-40-8)
8W - 39 - 4 8W-39 VEHICLE THEFT SECURITY SYSTEMPL
008W-10PLI03904
MODULE ENTRY
KEYLESS
REMOTE
16 24
1
2
SWITCH CYLINDER
KEY
TRUNK
DECKLID
SOLENOID
2C302
G301 S311 S312
C3052
C30246
21
G71
20
VT/YL
G71
20
VT/YL
G71
20
VT/YL
Q2
16
LG/BK
Q2
16
LG/BK
Q2
16
LG/BK
Z1
18
BKZ1
18
BK
Z1
16
BK
Z1
18
BK
23
1
2
G103
C1032
S117
B2
SWITCH AJAR
HOOD
G70
20
BR/TN
G70
18
BR/TN
Z1
18
BK
DECKLID
RELEASE
RELAY
OUTPUTDECKLID
SECURITY
SWITCH
SENSEHOOD
AJAR
SWITCH
SENSE
2
1A2
A21
Z1
18
BK
Z1
18
BK
G304
Z1
12
BK
(8W-15-12)
(8W-15-13) (8W-15-12)
(8W-15-13) (8W-15-12)
(8W-15-13)
(8W-15-7) (8W-15-7) (8W-61-6)
(8W-61-6)
(8W-15-12)
(8W-15-13)
PL8W-39 VEHICLE THEFT SECURITY SYSTEM 8W - 39 - 5
PLI03905008W-10
