1999 NISSAN PRIMERA trunk

BODY & TRIM
SECTION
BT
CONTENTS
PRECAUTIONS............................................................. 2
Service Notice............................................................ 2
Supplemental Restraint System (SRS)²AIR
BAG²and²SEAT BELT PRE-TENSIONER²............. 2
GENERAL SERVICING................................................. 3
Clip and Fastener ...................................................... 3
BODY END.................................................................... 5
Body Front End.......................................................... 5
Body Rear End and Opener ...................................... 7
DOOR........................................................................... 13
Front Door................................................................ 13
Rear Door ................................................................ 14
INSTRUMENT PANEL................................................. 15
INTERIOR TRIM.......................................................... 18
Side and Floor Trim ................................................. 18
Door Trim ................................................................. 24
Roof Trim ................................................................. 25
Trunk Room Trim ..................................................... 28
Luggage Room Trim ................................................ 29Back Door Trim ........................................................ 30
EXTERIOR................................................................... 31
SEAT............................................................................ 40
Front Seat ................................................................ 40
Heated Seat ............................................................. 42
Rear Seat................................................................. 43
SUNROOF.................................................................... 46
Trouble Diagnoses................................................... 49
WINDSHIELD AND WINDOWS.................................. 53
Windshield and Rear Window ................................. 54
Side Window ............................................................ 55
Back Door Window .................................................. 56
MIRROR....................................................................... 58
Door Mirror............................................................... 58
Rearview Mirror ....................................................... 59
BODY ALIGNMENT..................................................... 60
Engine Compartment ............................................... 60
Underbody ............................................................... 62
BT

Body Rear End and Opener
4-DOOR SEDAN
lWhen removing or installing trunk lid, place a cloth or other padding on rear fender panels. This pre-
vents vehicle body from being scratched.
lBumper fascia is made of plastic. Do not use excessive force and be sure to keep oil away from it.
lTrunk lid adjustment: Adjust at hinge-trunk lid portion for proper trunk lid fit.
lTrunk lid lock system adjustment: Adjust striker so that it is in the center of the lock. After adjustment,
check trunk lid lock operation.
WARNING:
lBe careful not to scratch trunk lid stay when installing trunk lid.
A scratched stay may cause gas leakage.
lThe contents of the trunk lid stay are under pressure. Do not take apart puncture, apply heat or
allow fire near it.
lOpener cable: Do not attempt to bend cable using excessive force.
lAfter installation, make sure that trunk lid and fuel filler lid open smoothly.
NBT034
5.1 - 6.37
(0.52 - 0.65,
45.1 - 56.4)
Upper
Spring holder
LowerOpener handle
Opener cable
Lock nut
Fuel filler lid opener & control
Trunk lid striker
.5.1 - 6.37
(0.52 - 0.65,
45.1 - 56.4)
: N´m (kg-m, ft-lb)
20.6 - 26.5
(2.1 - 2.7,
15 - 20)
: N´m (kg-m, in-lb) Cloth
Actuator
.Trunk lid lock
key cylinder
.Trunk lid lock
.5.1 - 6.37
(0.52 - 0.65, 45.1 - 56.4)
BODY END
BT-7

Trunk Room Trim
YBT018 Metal clipFrontMetal clip
SEC. 849
INTERIOR TRIM
BT-28

p12Side guard molding
lWith a vehicle coated with Hard Clear Coat,
use double-faced 3M adhesive tape Product
No. 5572 or equivalent, after priming with
3M primer Product No. N-200 or C-100 or
equivalent.
p13Rear window upper molding
Basically the same as windshield upper molding.
Refer to
p6Windshield upper molding.
p14Rear window lower molding
p15Trunk lid weatherstrip
p16Back door window molding
5-door hatchback
Wagon
See ªBack door windowº. Refer to BT-57.
YBT026
SEC. 766
Locating pins
: Double-faced adhesive tape
Heat gun
YBT027 Rear window glass
Rear window lower
molding
Removal: Remove molding by cutting around its perimeter.
Installation: Refer to ªRear windowº.
SBT069
SEC. 843
Marking at vehicle center
Vehicle center
Bonding portion
YBT050 300 (11.81)
60
(2.36)
Unit: mm (in)
Glass Back door moldingBack door molding GlassBack door molding Double side adhesive tapeGlass Back door molding
Back door molding
Glass
EXTERIOR
BT-35

DRAIN HOSES
1. Remove headlining to access drain hose connections. (Refer
to ªREMOVAL Ð Headliningº in ªINTERIOR TRIMº, BT-25,
BT-26, BT-27 for detail).
2. Check visually for proper connections, damage or deteriora-
tion.
(The figure shows only the front side.)
3. If leakage occur around trunk room, remove trunk room side
trim and check connecting area. Check for proper
connection, damage or tear.
4. Pour water into drain hoses and find damaged portion.
lIf any damaged portion is found at each step, replace the
damaged part.
WEATHERSTRIP
lIn the case of leakage around lid, close lid and pour water
over lid to find damaged or gap portion.
1. Remove lid assembly. (Refer to removal procedures, BT-47,
for details).
2. Visually check weatherstrip for proper installation. If a gap
exists between lid and weatherstrip, check for sufficient
amount of butyl seal. If required, remove weatherstrip and
apply butyl seal.
Refer to ªEXTERIORº BT-31 for details.
SBT335 Drain hose
SBT333 Sunroof frame
assembly
Drain hose
SBT334
.Sunroof drain
hose
Front
Grommet
Rear wheel
house inner LH
Rear fender inner LH
SUNROOF
Trouble Diagnoses (Cont'd)
BT-51

GROUND CONNECT TO CONN. CELL CODE
B18/B27 AUTO LEVEL CONTROL UNIT B123 EL-H/AIM
BACK-UP LAMP (Sedan) (LHD) T13 EL-BACK/L
BACK-UP LAMP (Sedan) (RHD) T8 EL-BACK/L
CD AUTO CHANGER B47 EL-AUDIO
CENTRAL UNLOCK/TRUNK OR BACK DOOR RELEASE
SWITCHB121 EL-S/LOCK, EL-D/LOCK
DOOR LOCK ACTUATOR ASSEMBLY (DRIVER’S SIDE)
(UNLOCK SENSOR) (With super lock)D7 EL-S/LOCK, EL-MULTI, EL-THEFT
DOOR LOCK ACTUATOR ASSEMBLY (DRIVER’S SIDE)
(UNLOCK SENSOR) (With power door lock)D26 EL-D/LOCK, EL-MULTI, EL-THEFT
DOOR LOCK ACTUATOR ASSEMBLY (PASSENGER SIDE)
(UNLOCK SENSOR) (With super lock)D16 EL-S/LOCK, EL-MULTI, EL-THEFT
DOOR LOCK ACTUATOR ASSEMBLY (PASSENGER SIDE)
(UNLOCK SENSOR) (With power door lock)D27 EL-D/LOCK, EL-MULTI, EL-THEFT
DOOR LOCK ACTUATOR ASSEMBLY REAR LH (UNLOCK SEN-
SOR) (With super lock)D21 EL-THEFT, EL-MULTI
DOOR LOCK ACTUATOR ASSEMBLY REAR LH (UNLOCK SEN-
SOR) (With power door lock)D28 EL-MULTI, EL-THEFT
DOOR LOCK ACTUATOR ASSEMBLY REAR RH (UNLOCK SEN-
SOR) (With super lock)D25 EL-THEFT, EL-MULTI
DOOR LOCK ACTUATOR ASSEMBLY REAR RH (UNLOCK SEN-
SOR) (With power door lock)D29 EL-MULTI, EL-THEFT
DOOR MIRROR HEATER (DRIVER’S SIDE) (Type-1) D4 EL-DEF
DOOR MIRROR HEATER (DRIVER’S SIDE) (Type-2) D31 EL-DEF
DOOR MIRROR HEATER (PASSENGER SIDE) (Type-1) D13 EL-DEF
DOOR MIRROR HEATER (PASSENGER SIDE) (Type-2) D30 EL-DEF
EXTERNAL TRUNK RELEASE SWITCH (Sedan) T20 EL-S/LOCK, EL-D/LOCK
FUEL PUMP (GA16, QG18, SR20 engine) B30 EC-F/PUMP
FUEL LEVEL SENSOR UNIT B31 EL-METER, EL-WARN
HEADLAMP AIMING SWITCH (Type-1) B106 EL-H/AIM, EL-ILL
HEADLAMP AIMING SWITCH (Type-2) E129 EL-H/AIM, EL-ILL
HEATED SEAT LH B21 EL-HSEAT
HEATED SEAT RH B61 EL-HSEAT
HEATED SEAT SWITCH LH B104 EL-HSEAT
HEATED SEAT SWITCH RH B105 EL-HSEAT
KEY CYLINDER SWITCH (DRIVER’S SIDE) D9 EL-S/LOCK, EL-THEFT, EL-D/LOCK
KEY CYLINDER SWITCH (PASSENGER SIDE) D17 EL-S/LOCK, EL-D/LOCK
POWER SEAT B22 EL-SEAT
POWER SOCKET (Wagon) B86 EL-HORN
POWER WINDOW MAIN SWITCH D5 EL-WINDOW
REAR FOG LAMP (LHD) (Sedan with type-1) T8 EL-R/FOG
REAR FOG LAMP (RHD) (Sedan with type-1) T13 EL-R/FOG
REAR WIPER MOTOR (Sedan) B52 EL-WIP/R
SIDE AIR BAG MODULE LH B142 RS-SRS
SIDE AIR BAG MODULE RH B143 RS-SRS
TRUNK ROOM LAMP SWITCH (Sedan) T10EL-INT/L, EL-WARN, EL-THEFT, EL-
MULTI
ULTRA SONIC CANCEL SWITCH B102 EL-THEFT
GROUND DISTRIBUTION
EL-26

Headlamp
Wattage (12 volt)
High/low (without xenon headlamp) 55/55
High/low (with xenon headlamp) 55/Discharge D2S type
Exterior Lamp
Wattage (12 volt)
Front combination lampParking 5
Turn signal 21
Front fog lamp 55 (H1)
Rear combination lampTurn signal 21
Stop/Tail 21/5
Back-up 21
Side turn signal lamp 5
License plate lamp 5
High-mounted stop lamp 21
Interior Lamp
Wattage (12 volt)
Interior lamp 10
Map lamp 3
Step lamp 3.4
Trunk room lamp 3.4
Luggage room lamp 5
BULB SPECIFICATIONS
EL-137

Warning Lamps/Schematic
MODELS BEFORE VIN - P11U0548750
YEL167C
GLOW
MALFUNCTION INDICA-
TOR LAMP
ABS
BRAKE
WASH
DOOR
CHARGE
OIL
FUELElectronic
speedometer
module
COMBINATION METER
IGNITION SWITCH
ON or START
FUSE
AIR BAG: M/T models
: CVT models
:H⋅CVT models
:H⋅CVT (M6) models
: With GA engine
: With SR engine or QG engine
: With diesel engine
TIME CON-
TROL UNIT
DIAGNOSIS
SENSOR
UNITFUEL
LEVEL
SENSOR
UNITOIL PRES-
SURE
SWITCHALTER-
NATORFRONT
DOOR
SWITCH
(DRIVER
SIDE)FRONT
DOOR
SWITCH
(PASSEN-
GER SIDE)REAR
DOOR
SWITCH
LHREAR
DOOR
SWITCH
RHWASHER
LEVEL
SWITCHBRAKE
FLUID
LEVEL
SWITCHPARKING
BRAKE
SWITCH
VACUUM
SWITCHSEDIMENTER
SENSOR
ABS
ACTUATOR
AND ELEC-
TRIC UNIT
(CONTROL
UNIT)TCM (TRANS-
MISSION CON-
TROL MODULE)
CVT WARNING LAMP
SPORT INDICATOR LAMP
TRUNK ROOM
LAMP SWITCH
OR
LUGGAGE
ROOM LAMP
SWITCH
ECM
WARNING LAMPS
EL-165