2015 SUZUKI NEXA Owners Manual

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
&RRODQW/HYHO&KHFNCheck the coolant level at the reservoir
tank, not at the radiator. With the engine
cool, the coolant level should be between
the “FULL” and “LOW” marks.$GGLQJ&RRODQW
61MM0A125
NOTICE
7R DYRLG GDPDJLQJ \RXU FRROLQJ V\V
WHP

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
If the coolant level is below the “LOW”
mark, more coolant should be added.
When the engine is cool, remove the
degassing tank cap by turning it anticlock-
wise slowly to release any pressure. And
add coolant until the degassing tank level
reaches the “FULL” mark. Never fill the
degassing tank above the “FULL” mark.&RRODQW5HSODFHPHQWSince special procedures are required, we
recommend you take your vehicle to your
DXWKRULVHG 0DUXWL 6X]XNL ZRUNVKRSfor
coolantreplacement.
$LU&OHDQHUIf the air cleaner is clogged with dust, there
will be greater intake resistance, resulting
in decreased power output and increased
fuel consumption.
61MM0A126
Unclamp the side clamps and remove the
element from the air cleaner case. If it
appears to be dirty, replace it with a new
one.
Clamp the side clamps securely.
*HDU2LO0DQXDO7UDQVD[OH2LOWhen adding gear oil, use gear oil with the
appropriate viscosity and grade as shown
in the chart below.
We highly recommend you use:
“MARUTI *(18,1( GEAR OIL :”
formanual transaxle gear oil.
0DQXDOWUDQVD[OHRLO
68LM728
*HDU2LO/HYHO&KHFNVSHHGPDQXDOWUDQVD[OH
52LM021
:$ 5 1 , 1 *
,W LV KD]DUGRXV WR UHPRYH WKH UHVHU
YRLUWDQNFDSGHJDVVLQJWDQNFDSIRU
D GLHVHO HQJLQH ZKHQ WKH ZDWHU WHP
SHUDWXUH LV KLJK EHFDXVH VFDOGLQJ
IOXLG DQG VWHDP PD\ EH EORZQ RXW
XQGHUSUHVVXUH:DLWXQWLOWKHFRRODQW
WHPSHUDWXUH KDV ORZHUHG EHIRUH
UHPRYLQJWKHFDS
(;$03/(
C
Fo o-30
-22-20
-4-10
14 32 50 68 86 104010203040
75W-80
(1)(;$03/(

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
VSHHGPDQXDOWUDQVD[OH
71LS10701
7R FKHFN WKH JHDU RLO OHYHO XVH WKH IRO
ORZLQJSURFHGXUH1) Park the vehicle on a level surface with
the parking brake applied. Then, stop
the engine.
2) Remove the oil filler and level plug.
3) If gear oil flows from the plug hole, the oil
level is correct. Reinstall the plug. If gear
oil does not flow from the plug hole, add
oil through the filler plug hole until oil
flows a little from the plug hole.7LJKWHQLQJ WRUTXH IRU RLO ILOOHU DQG OHYHO
SOXJ
0DQXDOWUDQVD[OHRU
1PNJPOEIW
*HDU2LO&KDQJHSince special procedures, materials and
tools are required, it is recommended that
you trust this job to your DXWKRULVHG0DUXWL
6X]XNLZRUNVKRS.
&$87,21
$IWHU GULYLQJ WKH YHKLFOH WKH JHDU RLO
WHPSHUDWXUH PD\ EH KLJK HQRXJK WR
EXUQ \RX :DLW XQWLO WKH RLO ILOOHU DQG
OHYHO SOXJ LV FRRO HQRXJK WR WRXFK
ZLWK \RXU EDUH KDQGV EHIRUH LQVSHFW
LQJJHDURLOOHYHO
(2)
(;$03/(
NOTICE
:KHQ WLJKWHQLQJ WKH SOXJ DSSO\ WKH
IROORZLQJ VHDOLQJ FRPSRXQG RU
HTXLYDOHQWWRWKHSOXJWKUHDGVWRSUH
YHQWRLOOHDNDJH
0$587,68=8.,%RQG1R

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
&OXWFK3HGDO)OXLG&RQWURO&OXWFK
64MS141
Check the clutch pedal for smooth opera-
tion and clutch fluid level from time to time.
If clutch dragging is felt with the pedal fully
depressed, have the clutch inspected by
DXWKRULVHG 0DUXWL 6X]XNL ZRUNVKRS. If the
clutch fluid level is near the “MIN” triangle
mark, fill it up to the “MAX” triangle mark
with MARUTI genuine brake fluid.
)XHO)LOWHU
64MS175
The fuel filter works as a water sedimentor
as well.
Drain water according to the Periodic
Maintenance Schedule. To drain water:
1) Place a pan or ample rag under the fuel
filter drain nozzle.
2) Loosen the drain screw (1). The water
will be drained.
3) Tighten the drain screw when the water
changes to the diesel fuel.
7LJKWHQLQJWRUTXHIRUGUDLQVFUHZ
1PNJPOEIW
%UDNHV%UDNH)OXLG
64MS141
Check the brake fluid level by looking at
the reservoir in the engine compartment.
Check that the fluid level is between the
“MAX” and “MIN” triangle mark. If the
brake fluid level is near the “MIN” triangle
mark, fill it up to the “MAX” triangle mark
with MARUTI GENUINE BRAKE FLUID.
MAX
MIN
(1)
(;$03/(
MAX
MIN

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
NOTE:With disc brakes, the fluid level can be
expected to gradually fall as the brake pads
wear.%UDNH3HGDOCheck if the brake pedal stops at the regular
height without spongy feeling when you
depress it. If not, have the brake system
inspected by your DXWKRULVHG 0DUXWL 6X]XNL
ZRUNVKRS. If you doubt the brake pedal for
theregular height, check it as follows:
54G108
3HGDOWRIORRUFDUSHWPLQLPXPGLV
WDQFH³D´PPLQWith the engine running, measure the dis-
tance between the brake pedal and floor
carpet when the pedal is depressed with
approximately 30 kg (66 lbs) of force. The
minimum distance required is as specified.
Since your vehicle’s brake system is self-
adjusting, there is no need for pedal adjust-
ment.
If the pedal to floor carpet distance as mea-
sured above is less than the minimum dis-
tance required, have your vehicle inspected
by your DXWKRULVHG0DUXWL6X]XNLZRUNVKRS.NOTE:When measuring the distance between the
brake pedal and floor wall, be sure not to
include the floor mat or rubber on the floor
wall in your measurement.
:$ 5 1 , 1 *
)DLOXUHWRIROORZWKHJXLGHOLQHVEHORZ
FDQ UHVXOW LQ SHUVRQDO LQMXU\ RU VHUL
RXVGDPDJHWRWKHEUDNHV\VWHP

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
3DUNLQJ%UDNH
54G109
5DWFKHWWRRWKVSHFLILFDWLRQ

Downloaded from www.Manualslib.com manuals search engine 
,163(&7,21$1'0$,17(1$1&(
06(
7LUHV
74LHT0704
The front and rear tire pressure specifica-
tions for your vehicle are listed on the Tire
Information Label. Both the front and rear
tires should have the specified tire pressure.
Note that the value does not apply to the
spare tire, if equipped.
7LUH,QVSHFWLRQInspect your vehicle’s tires at least once a
month by performing the following checks:1) Measure the tire pressure with a tire
gauge. Adjust the pressure if necessary.
Remember to check the spare tire, too.
54G136
(1) Tread wear indicator
(2) Indicator location mark2) Check that the depth of the tread groove
is more than 1.6 mm (0.06 in.). To help
you check this, the tires have molded-in
tread wear indicators in the grooves.
When the indicators appear on the tread
surface, the remaining depth of the tread
is 1.6 mm (0.06 in.) or less and the tire
should be replaced.
3)Check for abnormal wear, cracks and
damage. Any tires with cracks or other
damage should be replaced. If any tires
show abnormal wear, have them
inspected by your
DXWKRULVHG 0DUXWL
6X]XNLZRUNVKRS
.
(;$03/(
:$ 5 1 , 1 *

Downloaded from www.Manualslib.com manuals search engine ,163(&7,21$1'0$,17(1$1&(
06(
4) Check for loose wheel nuts.
5) Check that there are no nails, stones or
other objects sticking into the tires.
7LUH5RWDWLRQWLUHURWDWLRQ
80JK040
If your vehicle is equipped with a spare tire
which is a different wheel type than the
wheels on the vehicle, you must use a 4-
tire rotation as shown in the example
below.
WLUHURWDWLRQ
54G114
To avoid uneven wear of your tires and to
prolong their life, rotate the tires as illus-
trated. Tires should be rotated every 10000
km (6000 miles). After rotation, adjust front
and rear tire pressures to the specification
listed on your vehicle’s Tire Information
Label.
&$87,21
+LWWLQJ FXUEV DQG UXQQLQJ RYHU URFNV
FDQGDPDJHWLUHVDQGDIIHFWZKHHO
DOLJQPHQW %H VXUH WR KDYH WLUHV DQG
ZKHHODOLJQPHQWFKHFNHGSHULRGL
FDOO\E\\RXUDXWKRULVHG 0DUXWL
6X]XNLZRUNVKRS
:$ 5 1 , 1 *