2011 TOYOTA AYGO Owners Manual

OCCUPANT RESTRAINT SYSTEMS71
MS13081b
The SRS side airbag and curtain shield
airbag system consists mainly of the fol-
lowing components, and their locations are
shown in the illustration.
1. Airbag manual on−off switch
2. SRS warning light
3. Airbag sensor assembly
4. Curtain shield airbag modules
(airbag and inflator)
5. Side and curtain shield airbag sensors
(5−door models)
6. Side airbag modules
(airbag and inflator)
7. Side and curtain shield airbag sensors
(3−door models)
The SRS side airbag and curtain shield
airbag system is controlled by the airbag
sensor assembly. The airbag sensor as-
sembly consists of a safing sensor and
airbag sensor.
In a severe side impact, the side and
curtain shield airbag sensor triggers the
side airbag and curtain shield airbag inflat-
ors. At this time a chemical reaction in
the inflators quickly fills the airbags with
non−toxic gas to help restrain the lateral
motion of the occupants.When the airbags inflate, they produce a
fairly loud noise and release some smoke
and residue along with non−toxic gas. This
does not indicate a fire. This smoke may
remain inside the vehicle for some time,
and may cause some minor irritation to
the eyes, skin or breathing. Be sure to
wash off any residue as soon as possible
to prevent any potential skin irritation with
soap and water. If you can safely exit
from the vehicle, you should do so imme-
diately.
Deployment of the airbags happens in a
fraction of a second, so the airbags must
inflate with considerable force. While the
system is designed to reduce serious inju-
ries, it may also cause minor burns or
abrasions and swelling.
Front seats as well as parts of the front,
center and rear pillars, roof side rail and
roof headlining may be hot for several
minutes, but the airbags themselves will
not be hot. The airbags are designed to
inflate only once.
AYGO WE 99E37E11 02.18

72OCCUPANT RESTRAINT SYSTEMS
CAUTION
SRS side airbags and curtain shield
airbags inflate with considerable
force. To reduce the possibility of
death or serious injury when they in-
flate, the driver, front passenger and
rear passengers must:
DWear their seat belts properly.
DRemain properly seated with their
backs upright and against the seats
at all times.
MS13034
DDo not allow anyone to lean against
the side door when the vehicle is
in use, since the side airbag and
curtain shield airbag could inflate
with considerable speed and force.
Otherwise, he/she may be killed or
seriously injured. Special care
should be taken especially when
you have a small child in the ve-
hicle.
DSit up straight and well back in the
seat, distributing your weight evenly
in the seat. Do not apply excessive
weight to the outer side of the
seats with a side airbag, and to the
front pillar, rear pillar and roof side
rail with a curtain shield airbag.
AYGO WE 99E37E11 02.18

OCCUPANT RESTRAINT SYSTEMS73
MS13039a
DDo not allow anyone to get his/her
head closer to the area where the
side airbag and curtain shield air-
bag inflate, since these airbags
could inflate with considerable
speed and force. Otherwise, he/she
may be killed or seriously injured.
Special care should be taken espe-
cially when you have a small child
in the vehicle.
MS13040
DDo not allow anyone to kneel on
the passenger seat, facing the pas-
senger ’s side door, since the side
airbag and curtain shield airbag
could inflate with considerable
speed and force. Otherwise, he/she
may be killed or seriously injured.
Special care should be taken espe-
cially when you have a small child
in the vehicle.
AYGO WE 99E37E11 02.18

74OCCUPANT RESTRAINT SYSTEMS
MS13086
DDo not allow anyone to get his/her
head or hands out of windows
since the curtain shield airbags
could inflate with considerable
speed and force. Otherwise, he/she
may be killed or seriously injured.
Special care should be taken espe-
cially when you have a small child
in the vehicle.
MS13035
DDo not attach a cup holder or any
other device or object on or around
thedoor.Whenthesideairbagin-
flates, the cup holder or any other
device or object will be thrown with
great force or the side airbag may
not activate correctly, resulting in
death or serious injury. Likewise,
the driver and front passenger
should not hold objects in their
arms or on their knees.
AYGO WE 99E37E11 02.18

OCCUPANT RESTRAINT SYSTEMS75
MS13087
DDo not attach a microphone or any
other device or object around the
area where the curtain shield airbag
activates such as on the windshield
glass, side door glass, front, center
and rear pillars, roof side rail and
roof headlining. When the curtain
shield airbag inflates, the micro-
phone or other device or object will
be thrown away with great force or
the curtain shield airbag may not
activate correctly, resulting in death
or serious injury.
DDo not use seat accessories which
cover the parts where the side air-
bags inflate. Such accessories may
prevent the side airbags from acti-
vating correctly, causing death or
serious injury.
DDo not modify or replace the seats
or upholstery of the seats with side
airbags. Such changes may prevent
the side airbag system from activat-
ing correctly, disable the system or
cause the side airbags to inflate ac-
cidentally, resulting in death or seri-
ous injury.
DDo not disassemble or repair the
front, center and rear pillars, roof
side rail and roof headlining con-
taining the curtain shield airbags.
Such changes may disable the sys-
tem or cause the curtain shield air-
bags to inflate accidentally, result-
ing in death or serious injury.
Failure to follow these instructions
can result in death or serious injury.
Consult any authorized Toyota dealer
or repairer, or another duly qualified
and equipped professional, about any
repair and modification.
NOTICE
Do not perform any of the following
changes without consulting any autho-
rized Toyota dealer or repairer, or
another duly qualified and equipped
professional. Such changes can inter-
fere with proper operation of the SRS
side airbag and curtain shield airbag
system in some cases.
zInstallation of electronic devices
such as an RF−transmitter, cassette
tape player or compact disc player
zModification of the suspension sys-
tem
zModification of the side structure of
the passenger compartment
zRepairsmadeonornearthecon-
sole or front seat
AYGO WE 99E37E11 02.18

76OCCUPANT RESTRAINT SYSTEMS
MS13089
This indicator comes on when the en-
gine switch is turned to the “ON” posi-
tion. It goes off after about 6 seconds.
This means the SRS side airbags and
curtain shield airbags are operating
properly.
This warning light system monitors the
airbag sensor assembly, side airbag
sensors, side and curtain shield airbag
sensors, airbag manual on−off switch, seat
belt pretensioner assemblies, inflators,
warning light, interconnecting wiring and
power sources. (For details, see “Service
reminder indicators and warning buzzers”
on page 127 in Section 1−6.)
If any of the following conditions occurs,
this indicates a malfunction of the airbags
or seat belt pretensioners. Contact any
authorized Toyota dealer or repairer, or
another duly qualified and equipped pro-
fessional, as soon as possible.
The airbag manual on−offswitchisinthe
“ON” position:
DWhen the engine switch is turned to
the “ON” position, the light comes on
for more than 6 seconds and then
flashes.
DWhen the engine switch is turned to
the “ON” position, the light either re-
mains off or flashes.
DWhile driving the vehicle, the light
flashes.The airbag manual on−offswitchisinthe
“OFF” position:
DWhen the engine switch is turned to
the “ON” position, the light comes on
for more than 6 seconds and then goes
off or flashes.
DWhen the engine switch is turned to
the “ON” position, the light remains off
or flashes without illuminating for more
than 6 seconds.
DWhile driving the vehicle, the light goes
off or flashes.
AYGO WE 99E37E11 02.18

OCCUPANT RESTRAINT SYSTEMS77
MS13042a
In the following cases, contact any autho-
rized Toyota dealer or repairer, or another
duly qualified and equipped professional,
as soon as possible:
DAny of the SRS side airbags and cur-
tain shield airbags have been inflated.
DThe portion of the doors (shaded in the
illustration) was involved in an accident
that was not severe enough to cause
the SRS side airbags and curtain
shield airbags to inflate.
DThe surface of the seats with the side
airbag (shaded in the illustration) is
scratched, cracked, or otherwise dam-
aged.
DThe portion of the front pillars, center
pillars, rear pillars, roof side rail or
roof headlining containing the curtain
shield airbags inside (shaded in the
illustration) is scratched, cracked, or
otherwise damaged.
AYGO WE 99E37E11 02.18

78OCCUPANT RESTRAINT SYSTEMS
MS13026
The airbag manual on−off system con-
sists of an airbag manual on−off switch
and SRS warning light. The switch can
disable the front airbag on the front
passenger side only. The SRS warning
light comes on when the airbag is dis-
abled. Disable the airbag only when
installing a rear−facing child restraint
system on the front passenger seat is
unavoidable.
The airbag manual on−off switch is lo-
cated on the driver side instrument panel
and the SRS warning light is located on
the instrument cluster panel.
Before operating the airbag manual on−off
switch, stop the vehicle and turn the en-
gine off. Insert the key into the key cylin-
der and turn it. To disable the airbag, turn
the key to the “OFF” position. The SRS
warning light will come on to tell you that
the airbag is off when the engine is turned
on. (For details about the indicator light,
see the following descriptions.) Be sure to
remove the key from the key cylinder.
Vehicles with side and curtain shield air-
bags—Thissystem cannot turn off the
side airbags and curtain shield airbags.
MS13043
SRS warning light
This light comes on when the engine
switch is turned to the “ON” position. It
goes off after about 6 seconds or remains
on when the airbag manual on−off switch
is in the “OFF” position. This means the
airbag manual on−off system isoperating
properly.
Contact any authorized Toyota dealer or
repairer, or another duly qualified and
equipped professional if any of the follow-
ing occur.
DThe key cylinder cannot be turned.
The airbag manual on−offswitchisinthe
“ON” position:
DWhen the engine switch is turned to
the “ON” position, the light comes on
for more than 6 seconds and then
flashes.
DWhen the engine switch is turned to
the “ON” position, the light either re-
mains off or flashes.
DWhile driving the vehicle, the light
flashes.
The airbag manual on−offswitchisinthe
“OFF” position:
DWhen the engine switch is turned to
the “ON” position, the light comes on
for more than 6 seconds and then goes
off or flashes.
AYGO WE 99E37E11 02.18
Airbag manual on−off system
(for front passenger)