2005 TOYOTA AVENSIS heater







I35837
w/o Hot gas heater:
w/ Hot gas heater:
±
HEATER & AIR CONDITIONER W/RECEIVER CONDENSER ASSY
55±99
AVENSIS REPAIR MANUAL (RM1018E)
(d) Install the cooler refrigerant discharge hose No.1 on the
w/ receiver condenser assy with the bolt.
Torque: 5.4 N
m (55 kgf
cm, 47 in.
lbf)
27.INSTALL FRONT BUMPER COVER (See page 76±3)
28.CHARGE REFRIGERANT (See page 55±38) SST 07110±58060 (07117±58060, 07117±58070, 07117±58080, 07117±58090, 07117±78050, 07117±88060, 07117±88070, 07117±88080), 07117±48130, 07117±48140
Specified amount: 440
30 g (15.51
1.06 oz.)
29.WARM UP ENGINE (See page 55±38)
30.INSPECT LEAKAGE OF REFRIGERANT (See page 55±38)

550ZA±01
I35278
N
m (kgf
cm, ft
lbf) : Specified torque
Non±reusable part

Compressor oil ND±OIL 8 or equivalentw/ receiver Condenser Assy
Liquid Tube Sub±assy A
Cooler Refrigerant Discharge Hose No.1
Cooler Dryer
Cap
1AZ±FSE: O±ring

O±ring

5.4 (55, 47 in.
lbf)
5.4 (55, 47 in.
lbf)
2.9 (30, 25 in.
lbf)
w/o Hot gas heater:




± HEATER & AIR CONDITIONERW/RECEIVER CONDENSER ASSY
55±91
AVENSIS REPAIR MANUAL (RM1018E)
COMPONENTS

I35279
N
m (kgf
cm, ft
lbf) : Specified torque
Non±reusable part

Compressor oil ND±OIL 8 or equivalentw/ receiver Condenser Assy
Liquid Tube Sub±assy A
Cooler Refrigerant Discharge Hose No.1O±ring
O±ring

w/ Hot gas heater:
5.4 (55, 47 in.
lbf)
O±ring

O±ring


5.4 (55, 47 in.
lbf)
O±ring

5.4 (55, 47 in.
lbf)
5.4 (55, 47 in.
lbf)5.4 (55, 47 in.
lbf)
O±ring

Discharge Tube Sub±assy
5.4 (55, 47 in.
lbf)
3.4 (35, 30 in.
lbf)
3.4 (35, 30 in.
lbf)
Discharge Tube
Discharge Tube
Refrigerant Filter
Magnet Valve Assy
55±92
± HEATER & AIR CONDITIONERW/RECEIVER CONDENSER ASSY
AVENSIS REPAIR MANUAL (RM1018E)

550Z9±01
55±90
± HEATER & AIR CONDITIONERW/RECEIVER CONDENSER ASSY
AVENSIS REPAIR MANUAL (RM1018E)
W/RECEIVER CONDENSER ASSY
ON±VEHICLE INSPECTION
1. INSPECT W/RECEIVER CONDENSER ASSY
(a) If the fin of the w/receiver condenser assy is dirty, clean it with water and dry it with compressed air.
NOTICE:
Do not damage the fin of the condenser assy.
(b) If the fin of the w/receiver condenser assy is bent, straighten it using a screwdriver or pliers.
2. INSPECT CONDENSER FOR LEAKAGE OF REFRIGERANT
(a) Using a halogen leak detector, check pipe joints for gas leakage.
(b) If gas leakage is detected in a joint, check the torque of the joint.

700TB±01
B67064
LHD Models
Defogger Wire
Liftback
Wagon
Defogger Wire
Defogger Wire
Hazard Warning Signal Switch Assy w/ Deicer:
FR DEICER Relay
Fuse Block Assy
w/ Deicer:
FR DIC Fuse
w/ Mirror Heater:
MIR HTR Fuse
Passenger Side R/B Assy
w/ Mirror Heater:
Outer Rear View Mirror Assy RH
w/ Mirror Heater:
Outer Rear View
Mirror Assy LH
Rear Window
Defogger Relay
70±46
± WINDSHIELD/WINDOWGLASS/MIRRORWINDOW DEFOGGER SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
WINDOW DEFOGGER SYSTEM
LOCATION

B67246
RHD Models
Defogger Wire
Liftback
Wagon
Defogger Wire Defogger Wire
Hazard Warning Signal Switch Assy
Passenger Side R/B Assy
w/ Deicer:
FR DEICER Relay
Fuse Block Assy
w/ Deicer:
FR DIC Fuse w/ Mirror Heater:
Outer Rear View Mirror Assy RH
w/ Mirror Heater:
Outer Rear View Mirror Assy LH
w/ Mirror Heater:
MIR HTR Fuse
Rear Window
Defogger Relay
± WINDSHIELD/WINDOWGLASS/MIRRORWINDOW DEFOGGER SYSTEM
70±47
AVENSIS REPAIR MANUAL (RM1018E)

I35213
B66044
A/T Only:
M/T Only:





B66033
± INSTRUMENT PANEL/METERINSTRUMENT PANEL SUB±ASSY LOWER
71±17
AVENSIS REPAIR MANUAL (RM1018E)
34. REMOVE CONSOLE BOX ASSY RR
(a) Disconnect the connector.
(b) Remove the 2 bolts , 4 screws and the console
box assy RR.
35. REMOVE HEATER TO REGISTER DUCT NO.2
(a) Remove the screw , clip and the heater to register duct
No.2.