2001 TOYOTA PRIUS brake light

[O]
[P]
[Q]
[R]
[S]
[T]
[U]
[V]
2001 PRIUS (EWD414U)
B HOW TO USE THIS MANUAL
Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop light SW.
When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows
through the rear lights warning light to TERMINAL 4 of the light failure sensor.
STOP LIGHT DISCONNECTION WARNING
When the ignition SW is turned on and the brake pedal is pressed (Stop light SW on), if the stop light circuit is open, the current
flowing from TERMINAL 7 of the light failure sensor to TERMINALS 1, 2 changes, so the light failure sensor detects the
disconnection and the warning circuit of the light failure sensor is activated.
As a result, the current flows from TERMINAL 4 of the light failure sensor to TERMINAL 11 to GROUND and turns the rear lights
warning light on. By pressing the brake pedal, the current flowing to TERMINAL 8 of the light failure sensor keeps the warning
circuit on and holds the warning light on until the ignition SW is turned off.
S6 STOP LIGHT SW
2±1 : Closed with the brake pedal depressed
L4 LIGHT FAILURE SENSOR
1, 2, 7±GROUND : Approx. 12 volts with the stop light SW on
4, 8±GROUND : Approx. 12 volts with the ignition SW at ON position
11±GROUND : Always continuity
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
C734L436R737
H1736R637S635
: RELAY BLOCKS
CodeSee PageRelay Blocks (Relay Block Location)
118R/B No.1 (Instrument Panel Left)

@@@ @@@ @@@
€€€ €€€ €€€
ÀÀÀ ÀÀÀ ÀÀÀ
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CodeSee PageJunction Block and Wire Harness (Connector Location)
IB20Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
3C22Instrument Panel Wire and J/B No.3 (Instrument Panel Left Side)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CodeSee PageJoining Wire Harness and Wire Harness (Connector Location)
IE142Floor Wire and Instrument Panel Wire (Left Kick Panel)
BV150Luggage Room Wire and Floor Wire (Luggage Compartment Left)
: GROUND POINTS
CodeSee PageGround Points Location
BL50Under the Left Quarter Pillar
BO50Back Panel Center
: SPLICE POINTS
CodeSee PageWire Harness with Splice PointsCodeSee PageWire Harness with Splice Points
I544Cowl WireB1850Luggage Room Wire
SYSTEM OUTLINE
SERVICE HINTS

2001 PRIUS (EWD414U)
B HOW TO USE THIS MANUAL
The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points (
EA, IB and IC shown below) can also be
checked this way.

I GROUND POINT
FAN MAIN RELAY
FAN MAIN RELAY
A/C FAN RELAY NO.2
A/C FAN RELAY NO.3
RADIATOR FAN MOTOR
RETRACT CONTROL
RELAY
RETRACT MOTOR RH
RETRACT MOTOR LH
FRONT TURN SIGNAL
LIGHT RH
PARKING LIGHT RH
FRONT TURN SIGNAL
LIGHT LH
PARKING LIGHT LH
DOOR LOCK CONTROL
SW RH
DOOR KEY LOCK
SW RH
DOOR LOCK MOTOR
RH
BLOWER RESISTOR
A/C AMPLIFIER
RADIO AND PLAYER
HEATER RELAY
AUTO ANTENNA
MOTOR
BLOWER SW
PARKING BRAKE SW
COMBINATION METER
HORN SW [COMB. SW]
TURN SIGNAL FLASHER
DOOR KEY LOCK SW LH
DOOR LOCK MOTOR LH
FUEL CONTROL SW
WOOFER AMPLIFIER
COMBINATION METER
COMBINATION METER
FUEL SENDER
CIGARETTE LIGHTER
O/D MAIN SW
CLOCK
5
5
5
5
4
4
4
4
4BA15
IB18
EA2 10
3E5
3E
6 3G
13 3F
3 3D
1 3B
7
ID115
IC33
IA12
E 3
A
A AW±B
W±BW±B W±B
W±B W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B W±BW±B W±B W±B W±B
W±B W±B
W±BW±B
W±B
W±B
W±B W±B
W±B
BR
W±B
BR BRW±BW±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B W±B
W±B
W±B
W±B
W±B
BR W±B
BR BR
BR W±B W±BW±B
W±BW±BBR W±B (4A±GZE)
W±B A A A
I 6
I 6
I 2
I 2
I 2
B 5I 5
I 5
I 5
B 5
B 5
B 5
I 5
I 5
I 3I 3
E 3
E 3
E 3
E 2
E 4
E 5
E 4
E 5
E 6E 4
E 4
B 4
EAI 4
B 4
B 4
I 4I 8
IBIC
3C7
4
JUNCTION
CONNECTOR J 1
4
DOOR LOCK CONTROL
RELAY
ELECTRICAL IDLE-UP
CUT RELAY (M/T)FRONT SIDE MARKER
LIGHT RH
FRONT SIDE MARKER
LIGHT LH
BRAKE FLUID LEVEL
WARNING SW
UNLOCK WARNING
SW WIPER AND WASHER
SW [COMB. SW] LIGHT CONTROL SW
[COMB. SW] HEATER CONTROL
ASSEMBLY
HEATER SERVO
MOTOR AMPLIFIER
DIMMER SW
[COMB. SW]
CRUISE CONTROL
MIRROR SW
REAR WINDOW
DEFOGGER SW
POWER WINDOW
MASTER SW
POWER WINDOW
CONTROL RELAY
DOOR LOCK CONTROL
SW
REMOTE CONTROL
MIRROR SW
*The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.

2001 PRIUS (EWD414U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
A 1 A/C Condenser Fan Motor
A 2 A/C Magnetic Clutch and Lock Sensor
A 3 A/C Triple Pressure SW
(A/C Dual and Single Pressure SW)
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Ambient Temp. Sensor
B 1 Brake Actuator
B 2 Brake Actuator
B 3 Brake Actuator
B 4 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Circuit Breaker Sensor
C 4 Converter
C 5 Converter
C 6 Crankshaft Position Sensor
D 1 DC Motor
E 1 Engine Coolant Temp. Sensor
E 2 Engine Hood Courtesy SWF 1 Front Airbag Sensor LH
F 2 Front Airbag Sensor RH
F 3 Front Parking Light LH
F 4 Front Parking Light RH
F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light RH
F 9 Front Wiper Motor
F 10 Fusible Link Block No.1
F 11 Fusible Link Block No.1
F 12 Fusible Link Block No.1
F 13 Fusible Link Block No.1
H 1 Headlight LH
H 2 Headlight RH
H 3 Heated Oxygen Sensor (Bank 1 Sensor1)
H 4 Horn
H 5 Hydraulic Booster
H 6 Hydraulic Booster

2001 PRIUS (EWD414U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
A 7 A/C Amplifier
A 8 A/C Amplifier
A 9 A/C Amplifier
A 10 A/C Room Temp. Sensor
A 11 A/C Solar Sensor
A 12 A/C Thermistor
A 13 Accel Position Sensor
A 14 Air Inlet Control Servo Motor
A 15 Air Mix Control Servo Motor
A 16 Air Vent Mode Control Servo Motor
A 17 Airbag Sensor Assembly
A 18 Airbag Sensor Assembly
A 19 Airbag Sensor Assembly
A 20 Airbag Squib (Front Passenger Airbag Assembly)
A 21 Airbag Squib (Steering Wheel Pad)
A 22 Ashtray Illumination
B 5 Back±Up Light Relay
B 6 Blower Motor
B 7 Blower Motor Linear Controller
B 8 Body ECU
B 9 Body ECU
B 10 Brake ECU
B 11 Brake ECU
B 12 Brake ECU
B 13 Brake ECU
B 14 Brake Warning BuzzerC 7 Center Cluster SW
C 8 Cigarette Lighter
C 9 Cigarette Lighter Illumination
C 10 Combination Meter
C 11 Combination Meter
C 12 Combination SW
C 13 Combination SW
C 14 Combination SW
D 2 Data Link Connector 3
D 3 Daytime Running Light Relay
D 4 Diode (Door Courtesy)
D 5 Diode (Daytime Running Light)
E 3 EMPS ECU
E 4 EMPS ECU
E 5 EMPS ECU
E 6 EMPS ECU
E 7 Engine Control Module
E 8 Engine Control Module
E 9 Engine Control Module
E 10 Engine Control Module

2001 PRIUS (EWD414U)
G
Position of Parts in Instrument Panel
G 1 Gateway ECU
H 7 Hazard Warning SW
H 8 Hazard Warning SW
H 9 Heated Oxygen Sensor (Bank 1 Sensor 2)
H 10 Hybrid Vehicle Control ECU
H 11 Hybrid Vehicle Control ECU
H 12 Hybrid Vehicle Control ECU
H 13 Hybrid Vehicle Control ECU
H 14 Hybrid Vehicle Control ECU
I 15 Ignition SW
J 1 Junction Connector
J 2 Junction Connector
J 3 Junction Connector
J 4 Junction Connector
J 5 Junction Connector
J 6 Junction Connector
J 7 Junction Connector
J 8 Junction Connector
J 9 Junction Connector
J 10 Junction Connector
J 11 Junction Connector
J 12 Junction Connector
J 13 Junction Connector
J 14 Junction Connector
J 15 Junction Connector
J 16 Junction Connector
J 17 Junction Connector
J 18 Junction Connector
J 19 Junction Connector
J 20 Junction Connector
J 21 Junction ConnectorJ 22 Junction Connector
J 23 Junction Connector
J 24 Junction Connector
J 25 Junction Connector
J 26 Junction Connector
J 27 Junction Connector
J 28 Junction Connector
J 29 Junction Connector
L 1 Light Control Rheostat
M 5 Multi Display
M 6 Multi Display
M 7 Multi Display
P 1 Park/Neutral Position SW
P 2 Parking Brake SW
P 3 PTC Heater
P 4 PTC Heater
R 2 Radio and Player
R 3 Radio and Player
R 4 Radio and Player
R 5 Remote Control Mirror SW
S 2 Shift Lock ECU
S 3 Stop Light SW
T 4 Transponder Key Computer
T 5 Turn Signal Flasher Relay
U 1 Unlock Warning SW and Key Interlock Solenoid
W 5 Wireless Door Control Receiver

2001 PRIUS (EWD414U)
POWER SOURCE
HEAD RELAY
2±1 : Closed with the light control SW at HEAD position or the dimmer SW at FLASH position
Closed with the engine running and the parking brake pedal released (Parking brake SW off) [w/ Daytime running light]
TAIL RELAY
5±3 : Closed with the light control SW at TAIL or HEAD position
I15 IGNITION SW
2±3 : Closed with the ignition key at ACC or ON position
2±4 : Closed with the ignition key at ON or ST position
7±6 : Closed with the ignition key at ON or ST position
7±8 : Closed with the ignition key at ST position
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
F10A34F13D34I1537
F11B34F17A38
F12C34F18B38
: RELAY BLOCKS
CodeSee PageRelay Blocks (Relay Block Location)
324Engine Room R/B No.3 (Engine Compartment Right)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CodeSee PageJunction Block and Wire Harness (Connector Location)
1B27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)1J27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
2B
2C30Instrument Panel Wire and Instrument Panel J/B (Cowl Side Panel LH)
2D
()
2G31Engine Room Main Wire and Instrument Panel J/B (Cowl Side Panel LH)2H31Engine Room Main Wire and Instrument Panel J/B (Cowl Side Panel LH)
SERVICE HINTS

2001 PRIUS (EWD414U)
6. MANUAL CANCEL CONTROL
When each of the following signals is input during driving with cruise control, the cruise control is released with turning the
cruise control requirement to 0. (The memorized speed is maintained when following signals except the signal, main switch
OFF is input.)
*Stop light switch ON (Pressing the brake pedal)
*Control switch's cancel switch ON
*Main switch OFF
7. AUTO CANCEL FUNCTION
A) The memorized speed is erased and the control is canceled if the following conditions occur. The power indicator blinks
at that time until the main switch is turned ON. The speed control is unavailable unless the main switch is turned ON
again.
*When the stop light switch breaks or short±circuits.
*When sudden change of the running speed signal occur.
B) The memorized speed is erased and the control is canceled if the following conditions occur.
*When the malfunction of the stop light switch input circuit occurs.
*When the running speed becomes slower than 40km/h.
*When the running speed becomes slower than the speed that 16 km/h subtracted from the memorized speed.
8. REGENERATIVE SYSTEM OPERATION
This system operates the motor as a generator to change the kinetic energy of the vehicle into the electricity when accel
pedal release or foot braking controls the vehicle, and store the electricity in the battery.
C14 CRUISE CONTROL SW [COMB. SW]
5±4 : Approx. 1540 W with CANCEL SW on
Approx. 240 W with RES/ACC SW on
Approx. 630 W with SET/COAST SW on
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
A736H10C37J18A37
A1336H11A37J19B37
A1836H12B37J2137
B836H13E37J22A37
B1136H14D37J23B37
B1538H16A38J24A37
B1638H17B38J25B37
B17A38I9D35J2637
B18B38I10C35J27A37
B1938I11A35J28B37
C334I12B35J3238
C4A34I13E35A38
C5B34I14F35J33B38
C10A36I1537M2A35
C11B36I1738M3B35
C1436J137M4C35
D236J2A37P137
E9C36J3B37S337
E10D36J737S8A39
F1034J8A37S9B39
F12C34J9B37S10C39
F13D34J1137S11D39
F1738J1637S12E39
F1838J1737T437
G137J1837W335
SERVICE HINTS

2001 PRIUS (EWD414U)
2B 62A 7 10 2A72I
ID OFF
TAIL
HEAD
LOW
HIGH
IG ID2 510A
GAUGE FROM POWER SOURCE SYSTEM (
SEE PAGE 50)
2K 10
B E
A E
1ID2 7 7. 5A
ECU±B
2C 5
ID1 8
IA2 16
DAYTIME RUNNING LIGHT RELAY D 3
JUNCTION
CONNECTOR J20JUNCTION
CONNECTOR J2 0
JUNCTION
CONNECTOR J17
JUNCTION
CONNECTOR J1 1
PARKING
BRAKE SW P 2
COMBINATION SW C13 DIODE
(
DAYTIME
RUNNING
LIGHT) D 5 1
EE46 3 12AC
87
A17 2
E17 8 11 92 5AC
14
R±W
R±G
R±L R±G R±G
R±L R±W RR±GR±G
L±O
R±Y
Y±B
W±B
R±G L Y±B R±Y
BRW±B
L
R±BL R±G R±W
R R±G R±G
R±W
W±B
EDRL HDIM H±LP +B IG
HI PKB CHG± IND
ID2 3
13 16
JUNCTION CONNECTORB J12 A , J13
B 2
B 17 A9 BODY ECUB B 8 , B 9A
Y±BA F
B HR±G
R±G
JUNCTION
CONNECTORB J27 A , J28
E
FLASH
LIGHT
CONTROL SW DIMMER SW
15A
DOME
1J 7
HIGH BEAM
HEAD
42A 22G
LL±Y
21
COMBINATION METER C10L±Y
H RDY HRLY
IH