1996 TOYOTA TERCEL door lock

N09348
ECUTOYOTA hand-held tester
TOYOTA Break-out-box
Interfece
Box DI-218
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
1996 TERCEL (RM440U)
4. CANCELLING OF THE THEFT DETERRENT SYSTEM IN OPERATING CONDITION
The theft deterrent operation can be canceled when any of the following conditions is met:
No.ConditionCanceling Operation
1Unlock left or right door with the key.

2Unlock doors with wireless door lock control system.

3Insert key into ignition key cylinder and turn it to ACC or ON
position.

4About 1 minute passes after theft deterrent operation be-
gins.Automatic stop *1
*1: In this case the theft deterrent system resets after about 2 seconds if all doors are closed.
5. ECU TERMINAL VOLTAGE MEASUREMENT BY US-
ING TOYOTA BREAK- OUT- BOX AND TOYOTA
HAND-HELD TESTER
(a) Hook up the TOYOTA break- out- box and TOYOTA
hand-held tester to the vehicle.
(b) Read the ECU input/output values by following the
prompts on the tester screen. Please refer to the TOYO-
TA break-out-box operator's manual.
HINT:
TOYOTA hand-held tester has a ºSnapshotº function. This re-
cords the measured data and is effective in the diagnosis of in-
termittent problems.

DI4N1-01
N12446N12538I10188
Engine Hood Courtesy Switch
Engine Room R/B
Starter Relay
Horn Relay
Headlight Control Relay
HAZ-HORN Fuse
HEAD LH Fuse
HEAD RH Fuse
Theft Deterrent Horn HORN
Door Lock Control Relay or
Theft Deterrent ECU
Combination Meter
Theft Deterrent Indicator
Ignition Switch
Light Control Switch Clutch Start Switch
I/P J/B
Taillight COntrol Relay
TAIL Fuse
CIG & RAD Fuse
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
DI-219
1996 TERCEL (RM440U)
PARTS LOCATION

I05902
Door Courtesy Switch
Door Lock Assembly

Door Lock Motor

Door Unlock
Detection Switch
Door Lock Assembly

Door Lock Motor

Door Unlock Detection SwitchLuggage Compartment
Door Key Lock and
Unlock SwitchDoor Courtesy Switch
Door Lock Assemblies

Door Lock Motor

Door Unlock
Detection Switch
Door Courtesy Switches
Luggage Compartment Door
Courtesy Switch
Park/Neutral Position Switch
DI-220
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
1996 TERCEL (RM440U)

DI4N2-02
I00302 I00303I00304
T4 T3
Theft Deterrent and Dor Lock Control ECU A
B
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
DI-221
1996 TERCEL (RM440U)
TERMINALS OF ECM
TerminalsSymbolsConditionSTD Value
A2 - A3ACT- eACT+Ignition switch ºOFFº.Below 50 W
A4 - GroundE e GroundAlways.Below 1 W
A4 - A8E e ACCIgnition switch ºACCº.10 - 14 V
A9 - Ground+B2 e GroundAlways.10 - 14 V
B1 - Ground+B1 e GroundAlways.10 - 14 V
B2A4LSWRE
Door unlock detection switch ºONº.
(Rear door)Below 1 W
B2 e A4LSWR e EDoor unlock detection switch ºOFFº.
(Rear door)1 MW or higher
B3A4CTYE
Door courtesy switch ºONº.
(Except driver's door opened)Below 1 W
B3 eA4CTY e EDoor courtesy switch ºOFFº.
(Except driver's door closed)1 MW or higher
B4A4DSWLELuggage compartment door courtesy switch ºONº.Below 1 WB4 e A4DSWL e ELuggage compartment door courtesy switch ºOFFº.1 MW or higher
B5A4L1EDoor lock control switch ºLOCKº.Below 1 WB5 e A4L1 e EDoor lock control switch ºOFFº or ºUNLOCKº.1 MW or higher
B6A4UL3E
Door key lock and unlock switch
driver's door ºUNLOCKº.Below 1 W
B6 e A4UL3 e EDoor key lock and unlock switch
driver's door ºOFFº or ºLOCKº.1 MW or higher
B7A4DSWDE
Door courtesy switch ºONº.
(Driver's door opened)Below 1 W
B7 eA4DSWD e EDoor courtesy switch ºOFFº.
(Driver's door closed)1 MW or higher
B8A4UL1EDoor lock control switch ºUNLOCKº.Below 1 WB8 e A4UL1 e EDoor lock control switch ºOFFº or ºLOCKº.1 MW or higher
B9A4LUGELuggage compartment door key lock and unlock switch ºONº.Below 1 WB9 e A4LUG eELuggage compartment door key lock and unlock switch ºOFFº.1 MW or higher
B10 - A4HEAD e ELight control switch other than ºHEADº.10 - 14 V
B11 - A4SH e EAlways.10 - 14 V
B12 - A4IND e EIndicator light circuit.Below 1 W
B14A4DSWHEEngine hood courtesy switch ºONº.Below 1 WB14 e A4DSWH e EEngine hood courtesy switch ºOFFº.1 MW or higher

DI-222
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
1996 TERCEL (RM440U)
B15A4LSWDE
Door unlock detection switch ºONº.
(Driver's)Below 1 W
B15 e A4LSWD e EDoor unlock detection switch ºOFFº.
(Driver's)1 MW or higher
B16A4UL2E
Door key lock and unlock switch ºUNLOCKº.
(Passenger's)Below 1 W
B16 e A4UL2 e EDoor key lock and unlock switch ºOFFº or ºLOCKº.
(Passenger's)1 MW or higher
B19A4DSWPEDoor courtesy switch ºONº. (Passenger's)Below 1 WB19 eA4DSWP e EDoor courtesy switch ºOFFº. (Passenger's)1 MW or higher
B20 eA4KSW e E
Key unlock warning switch ºONº.
(Key is inserted into key cylinder)Below 1 WB20 eA4KSW e E
Key unlock warning switch ºOFFº.1 MW or higher
B21A4LSWPEDoor unlock detection switch ºOFFº. (Passenger's)Below 1 WB21 e A4LSWP e EDoor unlock detection switch ºONº. (Passenger's)1 MW or higher
B22A4L2E
Door key lock and unlock switch ºLOCKº.
(Driver's)Below 1 W
B22 e A4L2 e EDoor key lock and unlock switch ºOFFº or ºUNLOCKº.
(Driver's)1 MW or higher
B23 - A4TALL e ELight control switch ºOFFº.10 - 14 V
B24 - A48HORN e EHorn switch ºOFFº.10 - 14 V
B25 - A4SRLY e EIgnition switch is turned to ºSTº.
(When park / neutral position switch ºPº position)10 - 14 V

DI4N3-01
Details of Problem
The theft deterrent system cannot be set
Inspecting Circuit*1See page
DI-224 1. Indicator light circuit
4. Door courtesy switch circuit
5. Door unlock detection switch circuit
6. Engine hood courtesy switch circuit
The indicator light does not blink when system is setIndicator light circuit
When the
system is
set
When the rear door is unlocked
When the luggage compartment door is opened
by a method other than the key2. Luggage compartment door key
lock and unlock switch circuit
3. Luggage compartment door
courtesy switch circuit
When the engine hood is opened
The system
does not
operateDoor unlock detection switch circuit
Luggage compartment door
courtesy switch circuit
Engine hood courtesy switch circuit
While the system is
in warning operation
Horns do not sound
Theft deterrent horn does not sound
Headlights do not flash
Taillights do not flash
The starter cut is not cut off
The rear door lock is not locked in unlock conditionHorn relay circuit
Theft deterrent horn circuit
Headlight control relay circuit
Taillight control relay circuit
Starter relay circuit
Door unlock detection switch circuit
It is not canceled when the ignition key is turned to
ACC or ON position
It still operates when the luggage compartment door is
opened with the key When the
system is
setIgnition switch circuit
Luggage compartment door key
lock and unlock switch circuit
System is still set even when a rear door is open Door courtesy switch circuit
Even when the
system is not
setHorns sound
Theft deterrent horn sounds
Headlights stay on
Taillights stay onHorn relay circuit
Theft deterrent horn circuit
Headlight control relay circuit
Taillight control relay circuit
DI-241
DI-239
DI-244
DI-213
DI-246
DI-224
DI-213
DI-239
DI-246
DI-231
DI-228
DI-233
DI-235
DI-226
DI-213
DI-237
DI-241
DI-244
DI-231
DI-228
DI-233
DI-235
*1: If numbers are given to the circuit, proceed with troubleshooting in the order indicated by those numbers.
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
DI-223
1996 TERCEL (RM440U)
PROBLEM SYMPTOMS TABLE
Proceed to the reference page shown in the matrix chart below for each malfunction symptom and trouble-
shoot for each circuit.
HINT:
Troubleshooting of the theft deterrent system is based on the premise that the door lock control system is
operating normally. Accordingly, before troubleshooting the theft deterrent system, first make certain that
the door lock control system is operating normally.

N20818
Battery MAIN FL B
EA21Engine Room Relay BlockMAIN AM2 22
Starter Relay
2
2B
EA17
S21
Starter B-R2
IC1B-R25
T4
SRLY
B-R
IC1
12 B-RIgnition Switch
78
IG2
7B
23
EA1
14A AJUNCTION
CONNECTOR
B-W
(A/T) Park/Neutral
Position Switch Clutch Start Switch
1
2
B-W3
IG2B-W
(M/T)Theft Deterrent ECU
C6
I10
P1J1
B-W
B-W
DI-226
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
1996 TERCEL (RM440U)
Starter Relay Circuit
CIRCUIT DESCRIPTION
When the theft deterrent system is activated, contact (a) in the ECU becomes open, creating an open circuit
in terminal SRLY circuit and making the starter inoperative (starter cut).
In this condition, if one of the following operations is done, the contact (a) in the ECU is grounded, thus can-
celing the starter cut:
(1) Unlock the front LH or RH door with key.
(2) Unlock the doors with the wireless door lock control system.
WIRING DIAGRAM
DI4N5-02

N20819
Theft Deterrent ECU
SH T411
V-W IC2
4
V-W
1
2
W
Engine Room
Relay Block
MAIN FL
Battery 2
1
EA2BB
Theft Deterrent Horn
HAZ-HORN
W
T1 DI-228
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
1996 TERCEL (RM440U)
Theft Deterrent Horn Circuit
CIRCUIT DESCRIPTION
When the theft deterrent system is activated, contact (a) and contact (b) in the ECU close alternately in cycles
of approximately 0.2 sec., causing the theft deterrent horn to blow (See the wiring diagram below).
In this condition, if any of the following operations is done, the contact (a) in the ECU opens, thus stopping
the theft deterrent horn from blowing:
(1) Unlock the front LH or RH door with key.
(2) Turn the ignition switch to ACC or ON position.
(3) Unlock the doors with the wireless door lock control system.
(4) Wait for approximately 60 seconds.
WIRING DIAGRAM
DI4N6-02