2010 FIAT LINEA RHD Owners Manual

CHECKING FLUID
fig. 1 - 1.4 16V version
Never smoke while working
in the engine compartment.
Flammable gases may be present.
Risk of fire.
WARNING
Be careful not to confuse the
various types of fluids while
topping up: they are all reci-
procally incompatible and
may severely damage your car.
1.Engine coolant
2.Battery
3.Windscreen washer fluid
4.Brake fluid
5.Engine oil
6.Power steering fluid
F0R0243m
144
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 144LINEA Owner HAND BOOK RHD.pdf 1448/21/09 2:16:22 PM8/21/09 2:16:22 PM

fig. 2 - 1 .3 Multijet version
6
F0R0235m
1.Engine oil
2.
Engine coolant
3.Windscreen washer fluid
4.Brake fluid
5.Battery
6.Power steering fluid.
5
3 2 4
1
145
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 145LINEA Owner HAND BOOK RHD.pdf 1458/21/09 2:16:27 PM8/21/09 2:16:27 PM

If the oil level is near or even under the
MINline, add oil through the filler Ato
reach the MAXline.
Oil level shall never exceed the MAXline.ENGINE OIL CONSUMPTION
The maximum
engine oil consumption is
usually 400 grams every 1,000 km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption
can only be considered stabilised
after the first 5,000 - 6,000 km.
IMPORTANT
The oil consumption de-
pends on driving style and the conditions
under which the car is used.
IMPORTANT
After adding or changing
the oil, let the engine turn over for a few
seconds
and wait a few minutes after turn-
ing it off before you check the level. ENGINE OIL fig. 3-4
Check the oil level a few minutes (about
5) after the engine has stopped, with the
car parked on level ground.
The oil level shall be included between the
MINand MAXmarks on the dipstick B.
The range between the MINand MAX
levels corresponds to approximately
one litre of oil.
fig. 3 - 1 .4 version F0R0134mfig. 4 - 1 .3 Multijet versionF0R0135m
Proceed very carefully inside
the engine compartment
when the engine is hot: risk of burns.
Remember that the fan may start up
if the engine is hot: risk of injury.
Pay
attention to scarves, ties and other
loose fitting garments: they could get
dragged by the moving parts.
WARNING
146
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 146LINEA Owner HAND BOOK RHD.pdf 1468/21/09 2:16:34 PM8/21/09 2:16:34 PM

WINDSCREEN WASHING
FLUID fig. 6
To top up, remove the cap A.
Pour a mixture of 10% of fluid SC 35 &
90% of distil led water and check level
through the reservoir.
ENGINE COOLANT fig. 5
The coolant level must be checked when
the engine is cold and must be between
the MINand MAXlines on the vessel.
fig. 5F0R0136mfig. 6
PARAFLU UP antifre eze is
used in the engine cooling sys-
tem .
Use fluid of the sam e
type contained in the cooling
system for top-ups. PARAFLU UP may
not be mixed with other types of fluids.
If this accidentally occurs, do not start
the engine and contact a Fiat Dealer-
ship.
The cooling system is pres-
surised. If required, replace
the cap with an original spare part so
as not to compromise system effi-
ciency. Do not remove the cap from
the vessel
when the engine is hot: risk
of burns.
WARNING
F0R0137m
If the level is low, slowly pour a mixture of
40% PARAFLU UP & 60% deminerali-
zed water through filler A of the vessel un-
til the level approaches the MAXline.
Waste engine oil and oil filters
contains substances which are
dangerous for the environ-
ment. It is advisable to have
oil and filte rs changed by a Fiat
Dealership where they will be dispos-
ed of according to the law.
Always top up using engine oil
of the same types as that al-
ready in the engine.
147
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 147LINEA Owner HAND BOOK RHD.pdf 1478/21/09 2:16:34 PM8/21/09 2:16:34 PM

NOTE Carefully clean the cap of reservoir
Aand the surrounding surface.
When opening the cap,
make sure that no
dirt gets into the reservoir.
For topping up always use a
funnel with
built in filter (mesh smaller than or equal
to 0.12 mm).
IMPORTANT Brake fluid absorbs
mois-
ture. For this reason, if the car is mainlyused in areas with a high degree of at-
mospheric humidity, the fluid should be
replaced at more frequent intervals than
specified in the “Service schedule”.
fig. 7F0R0138m
Do not travel with the wind-
screen washing reservoir
empty: the windscreen washer is fun-
damental to improve visibility.
WARNING
Some commercial wind-
screen washer additives are
flammable. The engine compartment
contains
hot parts which could start
a fire if they come into contact.
WARNING
Prevent brake fluid which is
highly corrosive from coming
into contact with painted
parts. Wash with water im-
mediately if this should happen.
Brake fluid is poisonous and
highly corrosive. In the case
of accidental contact, wash the parts
with water and mild soap and rinse
with plenty of water. Call a doctor
immediately if swallowed.
WARNING
Symbol on the contain in-
dicates a synthetic brake flu-
id, which is different from a mineral
fluid. Use of a mineral type fluid will
damage the special rubber seals of
the braking system beyond repair.
WARNINGBRAKE FLUID fig. 7
Release cap A: check that the liquid con-
tained in the tank
is at the maximum level.
Fluid level in the reservoir must not ex-
ceed the MAXmark.
Use the brake fluid shown in the “Fluids
and lubricants” table (see “Technical Spec-
ifications”).
148
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 148LINEA Owner HAND BOOK RHD.pdf 1488/21/09 2:16:35 PM8/21/09 2:16:35 PM

Oil consumption is extremely
low; if another top-up should
be required after only a short
period of time, have the system checked
for leakage at a Fiat Dealership.
BATTERY
The car fits a low-maint enan ce batter y.
Under normal condition it does not need
frequent top ups with distelled water.
POWER STEERING FLUID fig. 8
Check that the oil level with the car on flat
ground and the engine cold is between the
MINand MAXline s on the reser voir
body. The level may go over the MAX
line when the oil is hot.
If topping up is required, make sure the oil
you used has the same specific ations as
that already in the system.
AIR CLEANER
Have the air cleaner replaced by a Fiat
Dealership. (Refer Service schedule)
POLLEN FILTER
Have the pollen filter replaced by a Fiat
Dealership.
Prevent power steering flu-
id from coming into contact
with hot engine par ts: the liquid is
flammable.
WARNING
fig. 8F0R0139m
149
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 149LINEA Owner HAND BOOK RHD.pdf 1498/21/09 2:16:35 PM8/21/09 2:16:35 PM

IMPORTANT Check the battery charge
once a year, preferably before the begin-
ning to winter, to prevent freezing of the
electrolyte. Perform this inspection more
frequently if the car is mainly used for
short distances or if electrical devices run-
ning with the key off are installed, partic-
ularly after-market. CHANGING THE BATTERY
If required, replace the battery with one
having the same specifications.
If a battery with different specifications is
fitte d, the service intervals given in the
“Service schedule” in this section will no
longer apply.
Follow the battery manufacturer’s in-
structions for maintenance.Incorrect assembly of electric
and electronic devices may
cause severe damage to your
car. Go to a Fiat Dealership
if you want to install accessories (al-
gge st the most su itabl e devi ces and
advise you if a higher capacity battery
needs to be installed.
Batteries contain very dan-
gerous substances for the en-
vi ronm ent . You are recom-
mended to go to a Fiat
Dealership to have the battery rep-
laced where the old battery will be dis-
posed of respecting both the environm-
ent and the laws in force.
If the car is left for long peri-
ods in very cold environ-
ments, remove the battery and store it
in a warm place to prevent freezing.
WARNING
Battery liquid is poisonous
and corrosive. Avoid contact
with the skin and eyes. Keep naked
flames and sources of sparks away
from the battery: risk of fire and ex-
plosion.
WARNING
Running the battery with an
excessively low liquid level
will damage the battery beyond re-
pair and even cause an explosion.
WARNING
150
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
arms, mobile phone, etc.): they will su-
LINEA Owner HAND BOOK RHD.pdf 150LINEA Owner HAND BOOK RHD.pdf 1508/21/09 2:16:35 PM8/21/09 2:16:35 PM

The total intake of these systems (facto-
ry and after-market) must be less than 0.6
mA x Ah (of the battery) as shown in the
following table:
Battery Maximum
permissible
loadless
consumption
40 Ah 24 mA
50 Ah 30 mA
60 Ah 36 mA
If after buying the car, you want to install
electric accessories which require per-
manent electric supply (alarm, etc.) con-
tact Fiat Dealership whose qualified
personnel, in addition to suggesting the most
suitable devices, will evaluate the overall
electric absorption, checking whether the
car’s electric system is capable of with-
standing the load required, or whether it
should be integrated with a more power-
ful battery.
Since these devices continue absorbing en-
ergy even when the ignition key is off, they
gradually run down the battery. USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and length-
en its life, observe the following indica-
tions:
when you park the car, ensure the
doors, tailgate and bonnet are closed
properly;
switch off all lights inside the car: the
car is however equipped with a system
which switches all internal lights off au-
tomatically;
do not keep accessories (e.g. sound sys-
tem, hazard lights, etc.) switched on for
a long time when the engine is not run-
ning;
before performing any operation on the
electrical system, disconnect the bat-
tery negative cable;
make sure that battery terminals are al-
ways be perfectly tight.
Always wear the proper pro-
tective eyewear when work-
ing on the battery or near it.
WARNING
151
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 151LINEA Owner HAND BOOK RHD.pdf 1518/21/09 2:16:35 PM8/21/09 2:16:35 PM