2007 VOLKSWAGEN GOLF PLUS Owners Manual

Charging, replacing, disconnecting and connecting the
first rea d and no te the introductory
o n p age 257.
the vehicle batte ry
Vehicl e batteries should be c harged by your rized Volk swagen deale r or an authorize d
Replacing the ve hicle battery
Th e batt ery in
your vehicl e is s pecially deve loped
f o r it s locati o n, w ith sp eci al dim ensio ns and safe ty
featu res. Befo re buy in g a new battery, ask an th ori ze d Volkswage n deale r o r authorize d swagen Facility w ha t batt eries are suit abl e
w ith r egard to e lectro-m agnetic compatibility, mension s, requir ed m aintenan ce, perfor man ce,
and safety sp ec ifications. H ave th e battery place d by an auth ori ze d Volkswage n deale r o r an authori zed Volk swage n Facility.
use m aint ena nce-free vehicl e ba tt eries m ee tin g standards T L 825
hicle's elec tri cal sys te m , note the following:
off all electrical syste ms and dev ices
and th e ign ition.
Fir st di sconnec t the negative cabl e and th en the positive
the vehicl e battery
to reconnecting the ba tt ery , switch off all elec trical sys te m s and dev ices and the ig niti on .
Con nec t th e positive cable fir st a n d then th e
n ega tive
ta n ce at mph (15-20 km /h).lf the in dica to r ligh ts do not go out, contact an auth orized swage n dealer or a n au th orize d Volkswagen v ice Facility and have the vehicle c hec ked.
If th e battery was discon necte d f or a long tim e, the
n ext scheduled se rvice may no t be correct ly la te d and page 16 The maximum per-
an d nance booklet.
Vehicles with
h icle battery, lock an d unloc k th e ve hicl e from th e outs id e. Th en try to sta rt the ig niti on again. If th e
ig niti on canno t b e switch ed on , ge t expe rt ta n ce.
Automatic electrical
load deactivation
I f t
he ve hicle battery drain is hig h, t he intelligent
o n board electrical sys te m m anage ment cally takes steps to help p reve nt b attery d rain.
The id le speed i s in creased so that the n ato r provides more powe r.
The power to dev ices that co nsume lot of e lec tricity is cut bac k or switched off com ple te ly.
W hen the en gine is s ta rt ed , p owe r supply oft h e
1 2-vo lt socke ts and t he c igare tte lighter is ra ril y int errupted.
T he on
board elec trica l sys tem man age men t
canno t always keep th e battery fro m being drained. For example, th e battery will drain if th e
e n g in e is not running, but th e ig ni tio n i s switc he d
o n for a lo ng tim e or th e parkin g lights a re left o n for a lo ng time.
What drain s th e battery?
Long period s w hen th e engine is no t running, especially w hen th e ig niti on is on.
Fa ilur e to use the proper batte ry with prop er mounting and connecti ons may ca use short seriou s personal injurie s.
Always use only mainten ance- free or leak-pro of batteries with the same
ment battery. Specification s are liste d on the
b attery ho using.
Wh en th e battery is charged, it produces hi ghly explosive hydroge n gas.
Charge ve hicl e batte ries only in w ell-ve nti-
l a te d areas.

Never charge a frozen or thawed battery. A
disch arged battery can freeze at temperatures around +32
Note
Never disconnect t11evehicle battery when the ignition is s witched on or the engine is running, as the electrica l system or electronic components can be damaged.
Note
Never connect power-generating equipment,
such as a solar panel or battery charger, to the 12-volt s ocket or the c igar ette light er in order to
charge the vehicle battery. This can damage the vehicle's electrical system.
Battery acid can pollute th e e nvironment. Operating mu st be collecte d and posed of properly, following all applicable
261

In this section information on th e fol­
l owing:
Washing the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 263
Washing with a power washer ................ .
Cleaning windows
and outside mirrors ......... .
Cleaning
and changing the winds hield wiper
b l
ades .......................
. . . . . . . 267
Cleaning wheel rims . . . . . . . . . . . . . . . . . . . . . . . . . 268
Care of rubber door and window seals . . . . . . . . . 268
De-icing door lock cylinders . . . . . . . . . . . . . . . . . . . 268
Undercoating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 268
Cleaning the engine comportment ....... -. . . . . 269
Regu l
ar and expert ca re helps to preserve the value of your vehicle. expert care may also be o ne of th e requirements of you r New Vehicle Lim ited if co rros ion re pair or repa intin g is neces­
s ary.
Veh icle care produc ts avai lable fro m your au­
th orized Volkswagen d eale r or A uthorized
Int erio r care and page
Preparations for work ing in the e ngine com­page 242
Parts. accessorie s. repair s and modifications
Vehicle care produc ts ca n be dangerous. Im­
proper usc c a n cause accid ents, burns, poi­sonin g, or oth er seri ous persona l injuries.
Alway s sto re vehicle care products only in o rigina l co ntainers that are securely closed.
Alway s read and heed all th e in structions and all o n the pac kag e.
To reduce the risk of poiso ning, never usc empty food or beverage containers that might m is lead someone int o frum
A lways keep vehicl e ca re products out of the reach of childre n .
Never usc fuel, turpentine, eng in e o il, nail poli sh r emov er or ot her vo la til e fluid s for ve­
hicl e ca re. They are po isonous and hi ghl y flam­
mable.
Improper care and cleaning of ve hicl e compo­nent s can impact the safe ty feature s of the ve­
hicl e and cause serio us personal injury.
A lways clea n and maintain vehicl e compo­nent s according to manufacturer's instructions.
use ap1>roved or recomm ended
clean ers.
Vehi cle care products containing s olvents can damage plastics and other ve hicl e th e material s.
Wash th e ve hicl e only des ig ­nated was h loca tio ns to preve nt wa ter con­
t a minated with oil. grease and fuel from enterin g the storm drain sewe r system. In some are a s it is
a gains t th e to wash motor ve hicles anywhere than other than sp ecified design ated car
was hing locatio n s.
choo se those that are no t harmful to the en­viron ment.
Never th row out ve hicl e care produ cts with ordina ry house ho ld waste. Always read and hee d all th e in structi ons and on the

Washing the
fir st read and note th e in formatio n and heed th e on page 262.
The lo nge r insect splaue r, b ird droppings. tree sap,
road din, indu strial depo sits, road and o ther aggressive materials sta y on your ve­
hicle , more damage they do sunlight ) crease the corros ive effects. The vehicle under­body sh o uld als o be was hed regularl y and thor­
o ughly.
to the information by the car wash operator. Before going through a
ca r wash , b e s ure
you have installed addition al accessorie s on the vehicle, su ch as a spoiler, a roof rack, or an ant enna, alway s
a sk th e car was h opera tor if thi s po se s problem
The paint finish is
dep end s a la rge exte nt on th e rype of ca r
was h. Volk swagen recommend s using brush le ss
ca r w as h faciliti es.
' l b
rem ove wax res idu e from th e windows and
avoi d jerky wind shi eld wip er move m ent , heed the
f ollow ing page 265, outsi de
w ith
on the roof and work down. Usc sp ec ia l shampoo only on hard-to -remove or grim e.
Hinsc
different sponge or wash mill.
edges under the vehicle
Always protect your hands
Alway s dry the brakes and clean off any icc
coatings with a few caref ul appli cations oftlte brake. Make sure not to endanger other motor­is ts or cyclists or disob ey lega l requirement s.
Note
The water temperature mus t not be more than
To help prevent damage to the paint, do not wash the vehicle in direct sunlight .
Do not use insect sponges, abrasive kitchen
s ponges or similar things to clean the ve hicle .
These can damage the paint finish.
Neve r clean headlight s with a dry cloth or sponge. Always use a
When washin g or rinsing the vehicle in cold
weather, do not let water get into the lock cylin ­ders or point the hose The water could freeze on the locks and seals and make it difficult to open the vehicle!
Note
To help prevent vehicle damage in a car wash:
the vehicle track width with the di­
men sion s of the guide rail s in the car wash to help prevent damage to wheel rims tires!
off the rain sensor before driving
through a wash .
Mak e sure there is enough clearan ce for the height and width of the ve hicle.
Fold the outside mirrors toward the vehicle
body. Do not fold power mirrors manually!
262 263

To he lp prev ent paint damage to the engine
hood , place wiper blades against th e winds hie ld
after they have dried . Do not le t them snap back
in to p lace.
Washing with a power washer
first r ead and note the introdu ctory information and heed the on pagc262.
A lways follow the instr u ctions
th ere is enoug h dis tan ce to soft ma te­
ria ls s uch as rubb er h ose s or insulatin g material as
well a s th e s en so rs of the Dis tance Co ntrol
sys te m . Th e
Never usc conce ntrated jet nozz les or dirt bla sters
Imp rope r usc of power washers can cause se­
rious invisibl e permanent d a m age leading to
ti re failur e and loss of ve hicle cont rol. This can cause accide nts and se riou s person al injury.
Keep sufficient di stance b e tween wate r je t
and tir es. Never wash tir es with a no zzle that sprays th e wa ter out in a direct stream re g ard­
l ess of th e di stance to the tir e and even for a very
short time .
Neve r u sc b lasters ." to clean tires. Even
a relatively long spraying dista nce and very
s hort applicatio n tim e can do visi ble or inv is ibl e damage to tire s.
Core, maintenance
Lock the hatc h to prevent unintentional ope ning in the car
the ve hicl e has been wash ed , th e wet
b ra kes or, in winter, brake discs or pads coated
w ith icc, rea ct slowe r and need l onger stopping
dista nces.
A lways dry the brakes and clean off any ic e
coa ting s with a few care ful applicatio ns of th e
bra ke. Make sure no t to endan ge r ot11er motor­
i sts or c yclists or disobey legal requi rements.
Note
Wate r temperature should not be m ore tha n
To he lp prevent damag e to paint, do not was h th e ve hicl e in dir ect sunli ght.
In order for and Assis t to work correctly, the sensors in the rear bumper must b e kept clean and clear of snow and ice. When using a pow er was her or steam clean er,
onl y spray the se n so rs directly for a short peri od
o f tim e and always keep the nozzle at l eas t4
in ch es em) from the sensor.
D o not clea n icy or snow- covere d w indow s
w ith
When washin g or rinsin g the vehicle in cold
weather, do no t let wate r ge t into the lock cylin ­
d
ers or po int the hose at gaps around th e doo rs ,
hood or rea r hatcl1. The w ate r could freeze on t11c
locks and sea ls and mak e it difficu lt to open th e

Please first read and n o te the introduc tory informa tion and heed the on page 262.
Cleaning windows
and outside mirrors
windows and outside mirror s with a mercially available alcohol-based window cleaner.
Dry windows
and mirrors with a clean chamois or a lint -free cloth. Do no t use a ch amoi s that has
b ee n used to wip e painted surfaces because it have absorbed an oily res idue that will smear the
g lass surf aces .
Usc window cleaner
or a silicone remover move rubb er, oil, gre ase a nd silico ne depos its
Removing wax residue
A utomat ic ca r was hes an d ve hicl e c
are produ cts
ca n leave a wax res idu e on all glass s u rfaces. These
wax residues can only be re m ove d with special clea ne rs o r cleani ng cloths. Wax re sidue left on t h e
windshield can cause the windshield w ipe rs to
g rab and squeak instead of glidin g smoothly. We recommend that after every car wash you remove
any wax resid ue left on th e w indsh ield w ith a
clea ning cloth.
W ind shi eld w ip
er squeak and grab can be red uced
b y the windshi eld was her fluid tank with a
w ip er fluid containin g wax-remov ing ag ents. Make sur e to maint ain the proper mixing ratio
w hen movin g cleaning cannot remove wax
mova l of wax residu e, Volkswagen recomme nds th e follow ing clean ers :
For the warme r months, Scheib cnklar Sommer
G 184 A I or equival ent. Mixing ratio parts wa te r) in the shi eld was her reservoir.
All-seaso n Scheib en kla r G 164 A2 or ale nt. Mixing ratio in winter
erwise mixing ratio 1:4 in winds hield washe r
Window cleaning cloths 522 AI or equivalent f o r all w ind ows and side mirrors.
Removing snow
Hemove
snow from all wind ows and outsid e
rec tion, never back and forth. Dirt can scratch the
w indow when m ov ing th e sc raper backwa rd.
Dirt y or fogged up window s re duce visibility and in cre ase the ri sk of accidents and seriou s sonal injury.
Don't drive until you have clear visibility through all windows.
Note
Never mix recomm ended cleaning agents wit h
o th er cleaning agents in the windshield washer reservoir.lfyou thi s co uld cause sediments or o th er by-produ cts that ca n clog the windshield wiper nozzles.
Neve r use warm or ho t water to remove snow and ice from windows and mirror s. This could cause the glass to crack!
Antennas installed on th e insides of windows can be damaged b y abrasive objects or by sive or acidic cleaning agents or other ch emicals. Do not plac e any stick ers on the
2 64 265

first r ead and not e th e introdu cto ry in fo rmati on and heed th e on page 262.
wip er b lades have a g raphit e
coating. Th e gra phit e coating le ts th e w ip er b la d es
g lid e smoothl y over the w ind shi eld.lfthis coating
i s worn or d am age d, the w ipers m ay grab or squ eak.
wip er bla d es regularly. Wiper blades that grab and squeak m ust b e re placed if worn or
Replace wo m or damaged wip er b lades ate ly. R ep lac em ent may be purch ased fro m
a ny authorize d Se rv ic e Faci lity
Lifting and windshield wiper arms
W he n lift in g o r re plac ing a w iper b la d e o n grip it onl y b y its m ounting and not by
th e blad e itself.
For windshi eld wipe rs p lease note: M ove the
w ip er a rm s in to th e serv ice pos ition prior to lifting
th em awa y fro m the page 128.
Cleaning th e wiper blades
Lift and the wip er arm(s) awa y from the
w ind shi eld I rea r w indow.
Usin g a soft cloth, care full y re m ove dust a nd dirt fro m th e wiper bla d es.
clean th em
w ith a sp onge or
Changing the w ip er blades on th e windshi eld
Lift and th e wipe r arm(s ) awa y from th e
w in dsh ie ld I re a r w ind ow .
maintenanc e
Fig. 159 Changing the rear windo w wip e r b lades.
and h o ld th e re le a se 15 8 and th e w iper blade off in the direc tio n of th e
a rro w.
a
Lo we r th e arm b ack onto the w in d shield .
Changing the rear window w iper
Lift and tilt th e w iper a rm aw ay fro m the
w ind ow.
and ho ld t he re lease 1 5 9
W hile th e w iper b lade in the direc tio n of th e w ip e r !59 (arro w off th e
wip er blade in the dir ection of th e This
m ay require moderat ely
a new wiper bl ade o f th e same length and type onto th e w ip er a rm b y pu shin g in the pos ite dir ectio n of th e arrow ® until it l atc h es.
Th e w ip e r b lade must b e in the fo ld ed -aw ay
Low er th e arm bac k onto the rea r w indow.
Worn
or d ir ty wiper blades reduce visibilit y and increase the ri sk of accidents and se riou s so n al in jury.
Always change wip er blades if th ey are or if they cannot clea n the
Note
Damag ed or dirty w ip er blades can sc ra tch the window.
graphit e coating on th e
wiper blades.

Note (cont inued)
Do not clean the window s with nail poli sh re mover, paint thinner or simil ar
Waxing and polishing vehicle paint
first r ead an d note th e introducwry information an d heed th e on page 262.
Waxing
A
good coat of w ax help s no lo nger form s drop s and runs when th e pa int is ap pl y a new coat of goo d hard wax protect th e ve hicle again.
E ve n
if a wax solution is use d regularly
firs t read a n d note th e int rod uctory informa ti on an d heed th e on page 262.
chrome parts w ith a dam p clot h. swage n recommends re mov ing surface spots or
res id u e w ith a c hrome care product. ch ro me
p an s w ith a
first read a n d note the introd uctory info rmation and heed th e on page 262.
is d iff ere n tia te between o d ized surfaces an d alumin um , s uch as an fram e. The s urfaces sh o ul d not
b e treated a lu mi num, however. Never use insect re movin g sponges, ro ugh kit ch e n
s ponges or similar abra sive ite m s.
anodized surfaces w ith a clean, damp,
lint-free clo th.
If t he surfaces are ve ry dirty, use sp ecia l
care and maint enance
Polishing
your ve hicle if the pailll has lo st its s hin e
a nd the gloss cannot be brou gh t back wax .
T
he v ehicle must be waxe d afte r pol ishing if the
seal th e paint.
Note
To help prevent da mage, do no t use hard w ax or
Do no t w ax or your vehicle if it is dirty, or in a sandy or dusty place.
Note
To help p re v ent scratc hing ch ro me surfaces :
Do not us e abrasive cleaners or abrasive sponges.
D o no t clean or p olish chrome parts o r other ve hicl e surfaces in a sandy o r dusty place.
D o no t surfaces that a re
Note
To h e lp prev ent d amage to anodized surfaces:
Neve r usc sol vents, or abrasive sp onges o r
cleaners.
Neve r use
Do not use abrasive cleaners or abmsive
sponges.
D o not anodized surfaces in sandy o r dusty places.
surfaces that are
266 267