2005 TOYOTA AVENSIS Actuator

SFI
SFISFI
SFISFI
SFI
D25842

Circuit Description
The major role and, operation of the circuit
and its component parts are explained.

Diagnostic Trouble Code No. and Detection Item

Indicates the diagnostic trouble codes, diagnostic
trouble code settings and suspect areas for a
problem.
Wiring Diagram
This shows a wiring diagram of the circuit.
Use this diagram together with ELECTRICAL
WIRING DIAGRAM to thoroughly understand the
circuit.
Wire colors are indicated by an alphabetical code.
B = Black, L = Blue, R = Red, BR = Brown,
LG = Light Green, V = Violet, G = Green,
O = Orange, W = White, GR = Gray, P = Pink,
Y = Yellow, SB = Sky Blue
The first letter indicates the basic wire color and
the second letter indicates the color of the stripe.
Inspection Procedures
Use the inspection procedures to determine
if the circuit is normal or abnormal. If it is ab-
normal, use it to determine whether the prob-
lem is located in the sensors, actuators, wire
harness or ECU.

Indicates the condition of the connector of the ECU
during the check.


Connections of tester are
indicated by (+), (±) after
terminals name.
Connector being checked
is connected.Connector being checked
is disconnected.
For inspection of connector
with body ground, there is
nothing about the body
ground written down.
± INTRODUCTIONHOW TO TROUBLESHOOT ECU CONTROLLED
SYSTEMS01±31
AVENSIS REPAIR MANUAL (RM1018E)
CIRCUIT INSPECTION
How to read and use each page is shown below.

022KS±01
± PREPARATIONBRAKE
02±33
AVENSIS REPAIR MANUAL (RM1018E)
BRAKE
PREPARATION
SST
09023±00100Union Nut Wrench 10 mmBRAKE FLUID
BRAKE MASTER CYLINDER
SUB±ASSY
FRONT BRAKE
REAR BRAKE
BRAKE BOOSTER ASSY(LHD)
BRAKE BOOSTER ASSY(RHD)
BRAKE ACTUATOR ASSY(W/ VSC)
BRAKE ACTUATOR ASSY(W/O VSC)
09023±38400Union Nut Wrench 14mmBRAKE FLUID
BRAKE MASTER CYLINDER
SUB±ASSY
FRONT BRAKE
REAR BRAKE
BRAKE BOOSTER ASSY(LHD)
BRAKE BOOSTER ASSY(RHD)
BRAKE ACTUATOR ASSY(W/ VSC)
09214±76011Crankshaft Pulley ReplacerSKID CONTROL SENSOR
09520±00031Rear Axle Shaft PullerSKID CONTROL SENSOR
(09520±00040)ShockerSKID CONTROL SENSOR
09521±00020Drive Shaft Boot Clamping ToolSKID CONTROL SENSOR
09550±60010Differential Side Bearing
ReplacerFRONT BRAKE
(09710±06051)ReplacerREAR BRAKE
09950±00020Bearing RemoverSKID CONTROL SENSOR
Recomended Tools
09042±00010Torx Socket T30STEERING SENSOR

030MV±02
03±42
± SERVICE SPECIFICATIONSBRAKE
AVENSIS REPAIR MANUAL (RM1018E)
TORQUE SPECIFICATION
Part TightenedN
mkgf
cmft
lbf
Wheel nut1031,05076
Brake line union nut 10 mm
14 mm15
29155
29611
21
Brake booster clevis lock nut1919414
Brake master cylinder sub±assy x Brake booster assy2020415
Charcoal canister bracket x Body5.45548 in.
lbf
Brake booster assy x Body131309
Brake pedal support x Instrument panel reinforcement2424117
Brake pedale support x Brake pedal3737527
Brake pedale support x Body131309
Brake tube clamp x body5.45548 in.
lbf
Vacuum pump x Engine2121415
Vacuum pump union nut1414010
Vacuum pump check valve sub±assy x End cover7421454
Vacuum pump end cover x vacuum pump housing7.88069 in.
lbf
Front disc brake bleeder plug101027
Front brake cylinder mounting x Steering knuckle1021,04075
Front disc brake cylinder x Front disc brake cylinder mounting3030622
Front disc brake caliper x Flexible hose2929621
Rear disc brake bleeder plug101027
Rear disc brake cylinder mounting x Steering knuckle4747534
Rear disc brake cylinder x Rear disc brake cylinder mounting3030622
Rear disc brake caliper x Flexible hose2929621
Brake actuator x Brake actuator bracket
w/o VSC:
w/ VSC:7.0
4.771
4862 in.
lbf
42 in.
lbf
Front speed sensor wire harness clamp x shock absorber2929621
Brake actuator bracket x Body1919514
Front speed sensor x Steering knuckle8.08271 in.
lbf
Yawrate sensor bracket set bolt2121415
Yawrate sensor x Yawrate sensor bracket66153 in.
lbf
Yawrate sensor bracket x Body2121415

05C6N±01
±
DIAGNOSTICS SFI SYSTEM(1AZ±FE)
05±161
AVENSIS REPAIR MANUAL (RM1018E)
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Parameters listed in the chart may not be exactly the same as your readings due to\
the type of instrument
or other factors.

If a malfunction code is displayed during the DTC check in the check mode, check the circuit f\
or the codes
listed in the table below. For details of each code, refer to the ''See page '' under the respective ''DTC No.''
in the DTC chart.



\f \b
 *1
CHK ENG 
P0010/39 *4 (05±169)Camshaft Position ºAº Actuator
Circuit (Bank 1)
Open or short in oil control valve (OCV) circuit

Oil control valve

ECM

P0011/59 *4
(05±174)Camshaft Position ºAº ±Timing
Over±Advanced or System Per-
formance (Bank 1)
Valve timing

Oil control valve (OCV)

Camshaft timing gear assy


P0012/59 *4
(05±174)Camshaft Position ºAº ±Timing
Over± Retarded (Bank 1)
Camshaft timing gear assy

ECM


P0016/18 *4
(05±181)Crankshaft Position ± Camshaft
Position Correlation (Bank 1
Sensor A)
Mechanical system (Timing chain has jumped a tooth, chain
stretched)

ECM


P0031/21
*2, *4
(05±182)Oxygen (A/F) Sensor Heater
Control Circuit Low (Bank 1 Sen-
sor 1)


P0032/21
*2, *4
(05±182)Oxygen (A/F) Sensor Heater
Control Circuit High (Bank 1
Sensor 1)

Open or short in heater circuit of A/F sensor

A/F sensor heater

P0051/28
*2, *4
(05±182)Oxygen (A/F) Sensor Heater
Control Circuit Low (Bank 2 Sen-
sor 1)
A/F sensor heater

A/F relay

ECM


P0052/28
*2, *4
(05±182)Oxygen (A/F) Sensor Heater
Control Circuit High (Bank 2
Sensor 1)


P0100/31
(05±186)Mass Air Flow Circuit
Ohti ifltiit

P0102/31(05±186)Mass or volume Air Flow Circuit
Low Input
Open or short in mass air flow meter circuit

Mass air flow meter

ECM

P0103/31
(05±186)Mass or volume Air Flow Circuit
High Input
ECM

P0110/24(05±194)Intake Air Temperature Circuit
O h ti itk it i it


P0112/24(05±194)Intake Air Temperature Circuit
Low Input
Open or short in intake air temp. sensor circuit

Intake air temp. sensor (built in mass air flow meter)

ECM


P0113/24
(05±194)Intake Air Temperature Circuit
High Input
ECM


P0115/22(05±199)Engine Coolant Temperature Cir-
cuit
Open or short in engine coolant temperature sensor circuit

P0117/22(05±199)Engine Coolant Temperature Cir-
cuit Low Input
Open or short in engine coolant temperature sensor circuit

Engine coolant temperature sensor

ECM

P0118/22
(05±199)Engine Coolant Temperature Cir-
cuit High Input
ECM

P0120/41 (05±204)Throttle/Pedal Position Sensor/
Switch ºAº Circuit
Throttle position sensor (built in throttle body)

ECM

P0122/41
(05±204)Throttle/Pedal Position Sensor/
Switch ºAº Circuit Low Input

Throttle position sensor (built in throttle body)

Short in VTA1 circuit

Open in VC circuit

ECM



A71007
MassAir Flow Meter Crankshaft Position Sensor
Actual Valve TimingCorrection Target Valve Timing
Feedback
Duty Control ECM
Camshaft Timing
Oil Control
Valve (OCV)
Vehicle Speed Signal Engine Coolant Temp. SensorThrottle Position Sensor
Camshaft Position Sensor
± DIAGNOSTICSSFI SYSTEM (1AZ±FE)
05±169
AVENSIS REPAIR MANUAL (RM1018E)
DTC P0010/39 CAMSHAFT POSITION ºAº ACTUATOR
CIRCUIT (BANK 1)
CIRCUIT DESCRIPTION
The VVT system controls the intake camshaft to provide the optimal valve timing for every driving condition. This control
is performed based on the signals, such conditions as intake air volume, throttle position and engine coolant tempera-
ture.
The ECM controls the oil control valve (OCV), based on the signals output from the sensors. The VVT controller regu-
lates the intake camshaft angle using oil pressure through the oil control valve (OCV). As result, the relative position
between the camshaft and the crankshaft becomes optimal, and the engine torque improves, fuel economy improves,
exhaust emissions decrease under overall driving conditions. Also, the ECM detects the actual valve timing using the
signals from the camshaft position sensor and the crankshaft position sensor, and performs feedback control. This is
how target valve timing is achieved by the ECM.
DTC No.DTC Detection ConditionTrouble Area
P0010/39Open or short in oil control valve (OCV) circuit

Open or short in oil control valve circuit

Oil control valve

ECM
05C6R±01

05CID±01
±
DIAGNOSTICS SFI SYSTEM(1AZ±FSE)
05±309
AVENSIS REPAIR MANUAL (RM1018E)
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Parameters listed in the chart may not be exactly the same as your readings due to\
the type of instrument
or other factors.

If a malfunction code is displayed during the DTC check in the check mode, check the circuit f\
or the codes
listed in the table below. For details of each code, refer to the ''See page '' under the respective ''DTC No.''
in the DTC chart.



\f  \b
 *1
CHK ENG 
P0010
(05±322)Camshaft Position ºAº Actuator
Circuit (Bank 1)
Open or short in OCV circuit

OCV

ECM

P0011
(05±325)Camshaft Position ºAº ±Timing
Over± Advanced or System Per-
formance (Bank 1)
Valve timing

OCV

VVT controller assembly

P0012
(05±325)Camshaft Position ºAº ±Timing
Over± Retarded (Bank 1)
VVT controller assembly

ECM

P0016
(05±329)Crankshaft Position ± Camshaft
Position Correlation (Bank 1
Sensor A)
Mechanical system (Timing chain has jumped a tooth, chain
stretched)

ECM

P0031
(05±330)Oxygen Sensor Heater Circuit
Low (Bank 1 Sensor 1)

Open in heater circuit of heated oxygen sensor

Heated oxygen sensor heater

EFI relay

EFI fuse

EFI No. 2 fuse

ECM

P0032
(05±330)Oxygen Sensor Heater Circuit
High (Bank 1 Sensor 1)
Short in heater circuit of heated oxygen sensor

Heated oxygen sensor heater

ECM

P0037
(05±330)Oxygen Sensor Heater Control
Circuit Low (Bank 1 Sensor 2)
Same as DTC No. P0031
P0038
(05±330)Oxygen Sensor Heater Control
Circuit High (Bank 1 Sensor 2)
Same as DTC No. P0032
P0051
(05±330)Oxygen Sensor Heater Circuit
Low (Bank 2 Sensor 1)
Same as DTC No. P0031
P0052
(05±330)Oxygen Sensor Heater Circuit
High (Bank 2 Sensor 1)
Same as DTC No. P0032
P0057
(05±330)Oxygen Sensor Heater Control
Circuit Low (Bank 2 Sensor 2)
Same as DTC No. P0031
P0058
(05±330)Oxygen Sensor Heater Control
Circuit High (Bank 2 Sensor 2)
Same as DTC No. P0032
P0100
(05±336)Mass or volume Air Flow Circuit
Ohti ifltiit

P0102
(05±336)Mass or volume Air Flow Circuit
Low Input
Open or short in mass air flow meter circuit

Mass air flow meter

ECM

P0103
(05±336)Mass or volume Air Flow Circuit
High Input
ECM

P0105
(05±342)Manifold Absolute Pressure/
Barometric Pressure Circuit
P0107
(05±342)Manifold Absolute Pressure/
Barometric Pressure Circuit Low
Input
Open or short in manifold absolute pressure sensor circuit

Manifold absolute pressure sensor

ECM

P0108
(05±342)Manifold Absolute Pressure/
Barometric Pressure Circuit High
Input
ECM


05±314
±
DIAGNOSTICS SFI SYSTEM (1AZ±FSE)
AVENSIS REPAIR MANUAL (RM1018E) 


\f  
*
1
CHK ENG
 
 \b
P0555
(05±459)Brake Booster Pressure Sensor
Circuit

Open or short in brake booster pressure sensor circuit

Brake booster pressure sensor

Vacuum hose

ECM

P0556
(05±462)Brake Booster Pressure Sensor
Circuit Range/Performance

Vacuum hose (between the brake booster and intake manifold,
the brake booster and brake booster pressure sensor, and the
intake manifold and manifold absolute pressure sensor)

Open or short in brake booster pressure sensor circuit

Brake booster pressure sensor

Manifold absolute pressure sensor

Brake booster

Open or short in stop light switch circuit

Stop light switch

ECM

P0557
(05±459)Brake Booster Pressure Sensor
Circuit Low Input
Same as DTC No. P0555
P0558
(05±459)Brake Booster Pressure Sensor
Circuit High Input
Same as DTC No. P0555
P0560
(05±467)System Voltage
Open in back±up power source circuit

ECM
P0571
(05±1711)Brake Switch ºAº Circuit
Cruise control system

P0604
(05±470)Internal Control Module Random
Access Memory (RAM) Error
P0606
(05±470)ECM/PCM Processor
ECM
P0607
(05±470)Control Module Performance
P0617
(05±471)Starter Relay Circuit High

Short in park/neutral position switch (A/T)

Park/neutral position switch (A/T)

Ignition switch

ECM

P0657
(05±470)Actuator Supply Voltage Circuit /
Open
ECM
P0705 *4
(05±474)
Transmission Range Sensor Cir-
cuit Malfunction (PRNDL Input)
Short in park/neutral position switch circuit

Park/neutral position switch

ECM

P0710 *4
(05±941)
Transmission Fluid Temperature
Sensor ºAº circuit
Electronic controlled automatic transmission (ECT)
P0711 *3,4
(05±943)
Transmission Fluid Temperature
Sensor ºAº Performance
Electronic controlled automatic transmission (ECT)
P0712 *4
(05±941)
Transmission Fluid Temperature
Sensor ºAº Circuit Low Input
Electronic controlled automatic transmission (ECT)
P0713 *4
(05±941)
Transmission Fluid Temperature
Sensor ºAº Circuit High Input
Electronic controlled automatic transmission (ECT)
P0717 *4
(05±945)
Input/Turbine Speed Sensor ºAº
Circuit No Signal
Electronic controlled automatic transmission (ECT)
P0724 *4
(05±947)Brake Switch ºBº Circuit High

Short in stop light switch signal circuit

Stop light switch

ECM

P0741 *3,4
(05±948)
Torque Converter Clutch Circuit
Performance or Stuck Off
Electronic controlled automatic transmission (ECT)
P0743 *4
(05±951)
Torque Converter Clutch Circuit
Electrical
Electronic controlled automatic transmission (ECT)

±
DIAGNOSTICS SFI SYSTEM (1AZ±FSE)
05±315
AVENSIS REPAIR MANUAL (RM1018E)


\f  
*
1
CHK ENG
 
 \b
P0746 *3,4
(05±954)
Pressure Control Solenoid ºAº
Performance (Shift Solenoid
Valve SL1)

Electronic controlled automatic transmission (ECT)
P0748 *4
(05±956)
Pressure Control Solenoid ºAº
Electrical (Shift Solenoid Valve
SL1)

Electronic controlled automatic transmission (ECT)
P0766 *3,4
(05±962)
Shift Solenoid ºDº Performance
(Shift Solenoid Valve S4)
Electronic controlled automatic transmission (ECT)
P0776 *3,4
(05±963)
Pressure Control Solenoid ºBº
Performance (Shift Solenoid
Valve SL2)

Electronic controlled automatic transmission (ECT)
P0778 *4
(05±956)
Pressure Control Solenoid ºBº
Electrical (Shift Solenoid Valve
SL2)

Electronic controlled automatic transmission (ECT)
P0793 *4
(05±965)
Intermediate Shaft Speed Sen-
sor ºAº Circuit No Signal
Electronic controlled automatic transmission (ECT)
P0982 *4
(05±956)Shift Solenoid ºDº Control Low
Electronic controlled automatic transmission (ECT)
P0983 *4
(05±956)Shift Solenoid ºDº Control High
Electronic controlled automatic transmission (ECT)
P1235
(05±477)High Pressure Fuel Pump Circuit

Open or short in fuel pump (high pressure)

Fuel pump (high pressure)

ECM

P2008
(05±480)Intake Manifold Runner Control
Circuit/Open (Bank 1)
Open of short in VSV for IACV circuit

VSV for IACV

ECM

P2102
(05±483)Throttle Actuator Control Motor
Circuit Low
Open in throttle control motor circuit

Throttle control motor

ECM

P2103
(05±483)Throttle Actuator Control Motor
Circuit High
Short in throttle control motor circuit

Throttle control motor

ECM

P2111
(05±485)Throttle Actuator Control System
± Stuck Open
Throttle control motor circuit

Throttle control motor
P2112
(05±485)Throttle Actuator Control System
± Stuck Closed
Throttle body

Throttle valve
P2118
(05±487)Actuator Control Motor Current
Range/Performance
Open in ETCS power source circuit

ECM
P2119
(05±490)Throttle Actuator Control Throttle
Body Range/Performance
Electric throttle control system

ECM
P2120
(05±492)Throttle/Pedal Position Sensor/
Switch ºDº Circuit
Open or short in accelerator pedal position sensor circuit

Accelerator pedal position sensor

ECM

P2121
(05±499)Throttle/Pedal Position Sensor/
Switch ºDº Circuit Range/Perfor-
mance
Open or short in accelerator pedal position sensor circuit

Accelerator pedal position sensor

ECM