2003 Hyundai H-1 (Grand Starex) check oil

PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
6-10 G080N01P-GAT
oo
oo
o Brake hoses and lines
Brake hoses and lines Brake hoses and lines
Brake hoses and lines
Brake hoses and lines
Visually check for proper installation, chafing, cracks, deterioration and any leakage. Replaceany deteriorated or damaged parts immedi-ately. G080O01P-GAT
oo
oo
o Brake fluid
Brake fluid Brake fluid
Brake fluid
Brake fluid
Check brake fluid level in the brake fluid reser- voir. The level should be between "MIN" and"MAX" marks on the side of the reservoir. Useonly hydraulic brake fluid conforming SAEJ1703. G080P01P-GAT
oo
oo
o Rear brake drums and linings
Rear brake drums and linings Rear brake drums and linings
Rear brake drums and linings
Rear brake drums and linings
Check for scoring, burning, leaking fluid, bro- ken parts, and excessive wear. G080Q01P-GAT
oo
oo
o Brake pads, calipers and rotors
Brake pads, calipers and rotors Brake pads, calipers and rotors
Brake pads, calipers and rotors
Brake pads, calipers and rotors
Check the pads for excessive wear, discs for run out and wear, and calipers for fluid leakage. G080R01P-GAT
oo
oo
o
Parking brake
Parking brake Parking brake
Parking brake
Parking brake
Inspect the parking brake system such as parking brake lever, cables, and so on. Fordetailed service procedures, refer to the ShopManual. G080S01P-GAT
oo
oo
o
Exhaust pipe connections,
Exhaust pipe connections, Exhaust pipe connections,
Exhaust pipe connections,
Exhaust pipe connections,
muffler and suspension bolts
muffler and suspension bolts muffler and suspension bolts
muffler and suspension bolts
muffler and suspension bolts
Check the exhaust pipe, muffler, and suspen-sion connections for looseness or damage. G080T01P-GAT
oo
oo
o
Steering gear box, linkage and boots
Steering gear box, linkage and boots Steering gear box, linkage and boots
Steering gear box, linkage and boots
Steering gear box, linkage and boots
With the vehicle stopped and engine off, check for excessive free-play in the steering wheel.Check the linkage for bends or damage. Checkthe dust boots and ball joints for deterioration,cracks, or damage. Replace any damaged parts. G080U01P-GAT
oo
oo
o Wheel bearing grease
Wheel bearing grease Wheel bearing grease
Wheel bearing grease
Wheel bearing grease
Check the wheel bearings and grease accord- ing to the maintenance schedule. For inspec-tion procedures, see Shop Manual.
G080J01P-GAT
oo
oo
o Engine coolant
Engine coolant Engine coolant
Engine coolant
Engine coolant
The coolant should be changed at those inter-
vals specified in the Vehicle Maintenance Re-quirements Section.
G080K01P-GAT oo
oo
o
Timing belt
Timing belt Timing belt
Timing belt
Timing belt
Inspect all parts related with the timing belt for
damage and deformation. Replace any dam-aged parts.
G080L01P-GAT oo
oo
o Manual transmission oil
Manual transmission oil Manual transmission oil
Manual transmission oil
Manual transmission oil
Check manual transaxle oil according to the
maintenance schedule.
NOTE:
NOTE: NOTE:
NOTE:
NOTE:
If the oil level is low, check for possible
If the oil level is low, check for possible If the oil level is low, check for possible
If the oil level is low, check for possible
If the oil level is low, check for possible leaks before adding oil. Do not overfill.
leaks before adding oil. Do not overfill. leaks before adding oil. Do not overfill.
leaks before adding oil. Do not overfill.
leaks before adding oil. Do not overfill.
G080M02P-GAT oo
oo
o
Automatic transmission fluid
Automatic transmission fluid Automatic transmission fluid
Automatic transmission fluid
Automatic transmission fluid
The fluid level should be in the "HOT" range of
the dipstick, after engine and transaxle are at normal operating temperature. Check the Auto-matic Transaxle Fluid level with the enginerunning and the transaxle in neutral, with theparking brake properly applied. Use GENUINEHYUNDAI ATF AUTOMATIC TRANSMISSIONFLUID, DIAMOND ATF DEXRON II or DIA-
MOND ATF SP I when adding or changing
fluid.

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-6 I040A01P-GAT
Vehicle Interior
Vehicle Interior Vehicle Interior
Vehicle Interior
Vehicle Interior
The following should be checked each time when the vehicle is driven:
o Light operation
o Windshield wiper operation
o Horn operation
o Defroster, heater operation (and air condi- tioning, if equipped)
o Steering operation and condition
o Mirror condition and operation
o Turn signal operation
o Accelerator pedal operation
o Brake operation, including parking brake
o Manual transmission operation, including clutch operation
o Automatic transmission operation, including "Park" mechanism operation
o Seat control condition and operation
o Seat belt condition and operation
o Sunvisor operation
If you notice anything that does not operate correctly or appear to be functioning correctly,inspect it carefully and seek assistance fromyour Hyundai dealer if service is needed. Adequate care of your vehicle at regular inter- vals serves to preserve the value and appear-ance as long as possible. Some maintenance items can be carried out bythe owner (Consumer Information), while othershould be done only by an authorized dealer(Periodic Inspection and Maintenance). Thissection describes only those items which canbe carried out by the owner. In the event amalfunction or other problem is discovered,have it corrected by an authorized HYUNDAIdealer. This section contains information oninspection maintenance procedures that youcan do yourself, if you so desire. Follow theinstructions and cautions for each of the vari-ous procedures. When checking or servicing the inside of the engine compartment, be sure the engine isstopped and has had a chance to cool down. Ifit is necessary to do work in the engine com-partment with the engine running, be especiallycareful that your clothing, hair, etc., becomesnot caught by the fan, V-belts, or other movingparts. I050A01P-GAT
Inspection items
Inspection items Inspection items
Inspection items
Inspection items
( 1 ) Engine oil
( 2 ) Engine coolant
(3) Battery
( 4 ) Brake fluid
( 5 ) Clutch fluid (hydraulic clutch only)
( 6 ) Washer fluid
( 7 ) Wheel condition (including spare wheel)
(8) Tire inflation pressure (including spare
wheel)
I020A02P-GAT
GENERAL CHECKS
GENERAL CHECKS GENERAL CHECKS
GENERAL CHECKS
GENERAL CHECKS
Engine Compartment
Engine Compartment Engine Compartment
Engine Compartment
Engine Compartment The following should be checked regularly:
o Engine oil level and condition
o Transmission fluid level and condition
o Brake fluid level
o Clutch fluid level
o Engine coolant level
o Windshield washer fluid level
o Accessory drive belt condition
o Coolant hose condition
o Fluid leaks (on or below components)
o Power steering fluid level and condition
o Tire pressure and condition (including spare)
o Battery condition I030A02P-GAT
Vehicle Exterior
Vehicle Exterior Vehicle Exterior
Vehicle Exterior
Vehicle Exterior The following should be checked monthly:
o Overall appearance and condition
o Wheel condition and wheel nut tightness
o Air cleaner filter condition
o Exhaust system condition
o Light condition and operation
o Windshield glass condition
o Wiper blade condition
o Paint condition and corrosion
o Fluid leaks
o Door and hood lock condition

8-7
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
( 9 ) Fuel, engine coolant, oil and exhaust gas leakage
(10) Exterior and interior lamp operation (11) Meter, gauge, and indication/warning lamp operation
(12) Steering wheel free play(13) Clutch pedal free play (14) Brake pedal free play (15) Parking brake lever stroke
Others
Others Others
Others
Others
(1) Wheel rotation
(1) Wheel rotation (1) Wheel rotation
(1) Wheel rotation
(1) Wheel rotation
Every 20,000km (12,000miles)or 12
Every 20,000km (12,000miles)or 12 Every 20,000km (12,000miles)or 12
Every 20,000km (12,000miles)or 12
Every 20,000km (12,000miles)or 12
months, whichever comes first
months, whichever comes first months, whichever comes first
months, whichever comes first
months, whichever comes first
(2) Hinge and latch lubrication
(2) Hinge and latch lubrication (2) Hinge and latch lubrication
(2) Hinge and latch lubrication
(2) Hinge and latch lubrication level surface, stop the engine, and then wait a few moments to allow the engine oil in circula-tion to return to the oil pan to ensure accuratemeasurement. Remove the dipstick and wipe itwith a clean cloth. Reinsert the dipstick andread the oil level, which should always bewithin the range indicated in the figure.
GS80030A
Good
I060A01P-GAT
ENGINE OIL
ENGINE OIL ENGINE OIL
ENGINE OIL
ENGINE OIL
It is important to check the oil level at regular
intervals or before starting a long trip.
This check must be made with the engine
warm but not running. Park the vehicle on a
GS80040A
If the oil level is below the specified limit,
remove the cap located on the cylinder head cover and add enough oil to raise the level towithin the specified range. Be sure to use thespecified engine oil and do not mix varioustypes of oil. Also, avoid mixing different makesof oil together if possible. After adding oil, closethe cap securely.
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
Be careful not to touch the hot exhaust
Be careful not to touch the hot exhaust Be careful not to touch the hot exhaust
Be careful not to touch the hot exhaust
Be careful not to touch the hot exhaust manifold.
manifold. manifold.
manifold.
manifold. CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
Avoid overfilling, or the engine could be
Avoid overfilling, or the engine could be Avoid overfilling, or the engine could be
Avoid overfilling, or the engine could be
Avoid overfilling, or the engine could bedamaged.
damaged. damaged.
damaged.
damaged.
NOTE:
NOTE: NOTE:
NOTE:
NOTE:
Check the oil level on the dipstick once
Check the oil level on the dipstick once Check the oil level on the dipstick once
Check the oil level on the dipstick once
Check the oil level on the dipstick onceagain after adding the oil.
again after adding the oil. again after adding the oil.
again after adding the oil.
again after adding the oil.
I070A05P-GATSelection of engine oil
Selection of engine oil Selection of engine oil
Selection of engine oil
Selection of engine oil (1) Use engine oil conforming to the following
API classification. Gasoline Engine
Europe : SG, SG/CD, SH or SH/CDExcept Europe : SE or above
Diesel Engine 2.6 N/A : CF-4 or above2.5 4D56 T/C or TCI : CF-4 or above
2.5 CRDi TCI : CE or above
(2) Select engine oil of the proper SAE viscos- ity number according to the atmospheric temperature. Recommened viscosity is given in the fol- lowing drawing.

8-9
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
G210A01A-AATCHECKING THE BATTERY
CHECKING THE BATTERY CHECKING THE BATTERY
CHECKING THE BATTERY
CHECKING THE BATTERY
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
When working with batteries, carefully ob-
When working with batteries, carefully ob- When working with batteries, carefully ob-
When working with batteries, carefully ob-
When working with batteries, carefully ob-
serve the following precautions to avoid
serve the following precautions to avoid serve the following precautions to avoid
serve the following precautions to avoid
serve the following precautions to avoid
serious injuries.
serious injuries. serious injuries.
serious injuries.
serious injuries. The fluid in the battery contains a strong solu- tion of sulfuric acid, which is poisonous andhighly corrosive. Be careful not to spill it onyourself or the car. If you do spill battery fluid onyourself, immediately do the following:
o If battery fluid is on your skin, flush the affected areas with water for at least 15minutes and then seek medical assistance.
o If battery fluid is in your eyes, rinse out your eyes with water and get medical assistanceas soon as possible. While you are beingdriven to get medical assistance, continueto rinse your eyes by using a sponge or softcloth saturated with water.
o If you swallow battery fluid, drink a large quantity of water or milk followed by milk ofmagnesia, eat a raw egg or drink vegetableoil. Get medical assistance as soon aspossible.
While batteries are being charged (either by abattery charger or by the vehicle’s alternator),they produce explosive gases. Always observethese warnings to prevent injuries from occur-ring:
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia- Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia- tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant
system is under pressure and any hot cool-
system is under pressure and any hot cool- system is under pressure and any hot cool-
system is under pressure and any hot cool-
system is under pressure and any hot cool-
ant escaping could cause severe burns.
ant escaping could cause severe burns. ant escaping could cause severe burns.
ant escaping could cause severe burns.
ant escaping could cause severe burns.
I080B01P-GATAnti-freeze
Anti-freeze Anti-freeze
Anti-freeze
Anti-freeze
The engine coolant contains an ethylene glycol
anti-corrosion agent. The cylinder head and coolant pump housing are cast aluminium alloy,and periodic changing of the engine coolant isnecessary to prevent corrosion of these parts. Because of the necessity of this anti-corrosion
agent, the coolant must not be replaced withplain water even in summer.
The required concentration of anti-freeze differs
depending on the expected ambient tempera-ture.
Ambient tempera-ture (minimum) °C (°F) Anti-freeze concentration %
-10
(15)
30 -20
(-5)
40 -30
(-20)
50 -45
(-49)
60
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen- performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen-
tration within the range of 30 to 60%.
tration within the range of 30 to 60%. tration within the range of 30 to 60%.
tration within the range of 30 to 60%.
tration within the range of 30 to 60%.
Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result in Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result ina reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool- a reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool-
ing performance thus adversely affecting
ing performance thus adversely affecting ing performance thus adversely affecting
ing performance thus adversely affecting
ing performance thus adversely affecting
the engine.
the engine. the engine.
the engine.
the engine.
I080A01P-GAT
ENGINE COOLANT
ENGINE COOLANT ENGINE COOLANT
ENGINE COOLANT
ENGINE COOLANT
I080A01P-GAG
FULL
LOW
A translucent coolant reservoir tank is in the
engine compartment. The coolant level in this tank should be kept
between the "LOW" and "FULL" marks when measured while the engine is warm and idling.
The cooling system is a closed system and
normally the loss of coolant should be veryslight. A noticeable drop in the coolant levelcould indicate leakage.
If this occurs, have the system checked at an
authorized HYUNDAI dealer as soon as pos-sible.
If the level should drop below the "LOW" level
on the reservoir tank, add coolant.
Also, if the reservoir tank is completely empty,
remove the radiator cap and add coolant untilthe level reaches the filler neck.

8-13
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I200A01P-GAG


30 mm (1.2 in.)
I200A01P-GAT
STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY
Check by moving the steering wheel left and
right. The free play at the circumference should not
exceed the standard value.
Free play 30 mm (1.2 in.) If the steering wheel free play exceeds the
standard value, have the steering wheel ad- justed at an authorized HYUNDAI dealer.
I170A01P-GAT
FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND
EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE
Look under the body of your vehicle to check
for fuel, engine coolant, oil, and exhaust gasleaks. If leaks are evident, take your vehicle to an
authorized HYUNDAI dealer for inspection.
I160A02P-GAT
TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE
Check the tire inflation pressure of all the tires
while they are cold; if insufficient or excessive,adjust to the specified value.
After the tire inflation pressure has been ad-
justed, check the tires for damage and airleaks.
Be sure to put rubber caps on the valves.
kg/cm² (PSI)
Mini- Bus Tire size
195R 14C-6PR 205/70R 15 215/80R 15
205/70R 15C-6PR Rear
2.8(40)2.8(40)2.2(32) 2.8(40) Front
2.8(40) 2.8(40)2.2(32)2.8(40)
Up to 3 persons Up to
MAX. load
Rear
3.5(50)2.8(40)2.2(32)3.5(50)
Front
2.8(40) 2.8(40) 2.2(32)2.8(40)
Veh- icle
kg/cm² (PSI)
Vehicle
VAN
TRUCK Tire size
195R 14C-8PR 195R 14C-6PR195R 13C-8PR Rear
4.5(65) -
3.5(50)
Front
2.8(40)2.8(40)
-
I180A01P-GATEXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP- EXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP-
ERATION
ERATION ERATION
ERATION
ERATION
Operate the light switch and combination switch
to confirm that all lamps are functioning prop- erly.
If the lamps do not go on, the probable cause
is a blown fuse or defective lamp bulb. Checkthe fuses first. If there is no blown fuse, checkthe lamp bulbs.
For information regarding the inspection and
replacement of the fuses and the lamp bulbs,refer to the section entitled "In case of emer-gency" If the fuses and bulbs are all OK, take the
vehicle to an authorized HYUNDAI dealer forinspection.
I190A01P-GATMETER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/ METER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/
WARNING LAMP OPERATION
WARNING LAMP OPERATION WARNING LAMP OPERATION
WARNING LAMP OPERATION
WARNING LAMP OPERATION
Run the engine to check the operation of all
meters, gauge, and indication/ warning lamps.If there is anything wrong, take the vehicle toan authorized HYUNDAI dealer for inspection.

10-1
INDEX
INDEX INDEX
INDEX
INDEX
BRAKE SYSTEM ....................................................................... 3-13 ~ 3-14
BRAKE WARNING AND PARKING BRAKE INDICATION
LAMP-RED ................................................................................................ 2-9
C CARE OF CASSETTE TAPES ..............................................2-56 ~ 2-57
CARE OF DISC ...................................................................................... 2-56
CARRYING CHILDREN ........................................................................ 1-12
CENTRAL DOOR LOCKS .................................................................... 1-10
CHANGING GEARS ................................................................................. 3-5
CHARGE WARNING LAMP-RED ......................................................... 2-9
CHILD PROTECTION SLIDE DOOR ................................................1-12
CHILD RESTRAINT SYSTEM ................................................1-25 ~ 1-28
CIGARETTE LIGHTER ......................................................................... 2-23
CLUTCH FLUID ....................................................................................... 8-10
CLUTCH PEDAL FREE PLAY ............................................................ 8-14
D DAYTIME RUNNING LIGHTS ............................................................. 2-13
DEFROSTING/DEFOGGING ............................................................... 2-26
DIGITAL CLOCK ..................................................................................... 2-24
DISEL ENGINE ROOM ................................................................ 8 - 1 ~ 8 - 4
DIESEL PREHEAT INDICATION LIGHT-AMBER ..............2-9 ~ 2-10
DOOR-AJAR WARNING LAMP-RED .................................................. 2-9
DRINK HOLDER ..................................................................................... 2-22
DURING COLD WEATHER ....................................................3-16 ~ 3-17
E ECONOMICAL DRIVING ......................................................... 3-14 ~ 3-15
EMERGENCY STARTING ................................................................... 4-14
K000A01P-GAT
10.
10. 10.
10.
10.
INDEX
INDEX INDEX
INDEX
INDEX
A ADJUSTABLE FRONT SEATS ........................................................... 1-18
AIR CONDITIONER OPERATION .....................................................2-27
ANTENNA ................................................................................................. 2-58
ALTIMETER ................................................................................................. 2-7
ANTI-FREEZE ............................................................................................. 8-9
ANTI-LOCK BRAKE SYSTEM ............................................................ 3-12
ANTI-LOCK BRAKE WARNING LIGHT ...........................................2-10
APPEARANCE CARE .............................................................................. 5-1
ASHTRAY (Front) ................................................................................... 2-23
ASHTRAY (Rear) .................................................................................... 2-23
A/T OIL TEMPERATURE WARNING LIGHT ..................................2-10
AUDIO FAULT CODE ........................................................................... 2-55
AUXILIARY SEAT ................................................................................... 1-22
AUTOMATIC TRANSMISSION OPERATION ........................ 3 - 5 ~ 3 - 8
AUTOMATIC TRANSMISSION FLUID CHECK .............8-11 ~ 8-12
B BATTERY ..................................................................................................... 8-9
BEFORE OPERATION PRECAUTIONS FOR NEW VEHICLE .... 1-1
BI-LEVEL HEATING ............................................................................... 2-25
BLEEDING THE FUEL SYSTEM ..........................................4-13 ~ 4-14
BRAKE FLUID ......................................................................................... 8-10
BRAKE PEDAL ........................................................................................ 3-11
BRAKE PEDAL FREE PLAY ............................................................... 8-14
1010
1010
10