2003 Hyundai H-1 (Grand Starex) jacking

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-2 E040A02P-GAT
JACKING UP THE VEHICLE
JACKING UP THE VEHICLE JACKING UP THE VEHICLE
JACKING UP THE VEHICLE
JACKING UP THE VEHICLE
GS40050A
1. Loosen the holding nut and pull out the
handle.
GS40060A
2. Insert the opposite end of the handle, andthen tighten the holding nut.
E040A01P-1
2WD
The method for jacking up the vehicle should be remembered in order to change a tire in theevent of a puncture and in order to install tirechains.
E040A02P-GAG
4WD
After stopping the engine and applying the
parking brake on a flat level surface, also use chocks to hold the wheels.
E040A03P-GAGRR
Position the jack only at the specified points indicated in the illustration, and the use of thejack at other points could damage the vehiclebody.
GS40080A
Jack handleRelief valve
Using the jack handle, turn the relief valve clockwise until it reaches a stop.
The jack handle is stored as shown in thefigure. To assemble, follow the steps below.

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-3
GS40090A
Notch of handle
Pressure piston
Then fit the handle into the pressure piston, and
align the groove of the handle with the notch of the holder.
Move the jack handle up and down to raise the
piston.
Using a jack handle, turn the relief valve coun-
terclockwise slowly to lower the piston.
Press the piston down all the way, and turn the
relief valve clockwise as far as possible.
GS40100A
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
(1)(1)
(1)(1)
(1)
Use only the jack included with the ve-
Use only the jack included with the ve- Use only the jack included with the ve-
Use only the jack included with the ve-
Use only the jack included with the ve-
hicle and use it only for changing a wheel.
hicle and use it only for changing a wheel. hicle and use it only for changing a wheel.
hicle and use it only for changing a wheel.
hicle and use it only for changing a wheel.
(2)(2)
(2)(2)
(2)
Position the jack on a hard level surface.
Position the jack on a hard level surface. Position the jack on a hard level surface.
Position the jack on a hard level surface.
Position the jack on a hard level surface.
(3)(3)
(3)(3)
(3)
If the relief valve is loosened by turning
If the relief valve is loosened by turning If the relief valve is loosened by turning
If the relief valve is loosened by turning
If the relief valve is loosened by turning
it 2 or more times in the counterclock-
it 2 or more times in the counterclock- it 2 or more times in the counterclock-
it 2 or more times in the counterclock-
it 2 or more times in the counterclock-
wise direction, the jack’s oil will leak and
wise direction, the jack’s oil will leak and wise direction, the jack’s oil will leak and
wise direction, the jack’s oil will leak and
wise direction, the jack’s oil will leak and
the jack cannot be used.
the jack cannot be used. the jack cannot be used.
the jack cannot be used.
the jack cannot be used.
(4)(4)
(4)(4)
(4)
This jack is hydraulic, and the ram is a
This jack is hydraulic, and the ram is a This jack is hydraulic, and the ram is a
This jack is hydraulic, and the ram is a
This jack is hydraulic, and the ram is a
two-stage type. When both rams are
two-stage type. When both rams are two-stage type. When both rams are
two-stage type. When both rams are
two-stage type. When both rams are
raised and the stop mark(Green paint)
raised and the stop mark(Green paint) raised and the stop mark(Green paint)
raised and the stop mark(Green paint)
raised and the stop mark(Green paint)
of the upper ram becomes visible, stop
of the upper ram becomes visible, stop of the upper ram becomes visible, stop
of the upper ram becomes visible, stop
of the upper ram becomes visible, stop
jacking immediately.
jacking immediately. jacking immediately.
jacking immediately.
jacking immediately.
Further extension of the ram may dam-
Further extension of the ram may dam- Further extension of the ram may dam-
Further extension of the ram may dam-
Further extension of the ram may dam-
age the jack.
age the jack. age the jack.
age the jack.
age the jack.
(5)(5)
(5)(5)
(5) When the jack is used, be sure that there
When the jack is used, be sure that there When the jack is used, be sure that there
When the jack is used, be sure that there
When the jack is used, be sure that there
is no one in or under the vehicle.
is no one in or under the vehicle. is no one in or under the vehicle.
is no one in or under the vehicle.
is no one in or under the vehicle. (6)(6)
(6)(6)
(6) When jacking up the vehicle, do so only
When jacking up the vehicle, do so only When jacking up the vehicle, do so only
When jacking up the vehicle, do so only
When jacking up the vehicle, do so only
until the tires are slightly lifted from the
until the tires are slightly lifted from the until the tires are slightly lifted from the
until the tires are slightly lifted from the
until the tires are slightly lifted from the
ground. It is dangerous to jack up the
ground. It is dangerous to jack up the ground. It is dangerous to jack up the
ground. It is dangerous to jack up the
ground. It is dangerous to jack up the
vehicle more than that much.
vehicle more than that much. vehicle more than that much.
vehicle more than that much.
vehicle more than that much.
(7)(7)
(7)(7)
(7) It is very dangerous if the jack somehow
It is very dangerous if the jack somehow It is very dangerous if the jack somehow
It is very dangerous if the jack somehow
It is very dangerous if the jack somehow
slips, so never leave the vehicle in the
slips, so never leave the vehicle in the slips, so never leave the vehicle in the
slips, so never leave the vehicle in the
slips, so never leave the vehicle in the
jacked-up position, and never shake the
jacked-up position, and never shake the jacked-up position, and never shake the
jacked-up position, and never shake the
jacked-up position, and never shake the
vehicle while it is raised.
vehicle while it is raised. vehicle while it is raised.
vehicle while it is raised.
vehicle while it is raised.
E040B01P-GAT To jack up vehicle on 4-wheel drive
To jack up vehicle on 4-wheel drive To jack up vehicle on 4-wheel drive
To jack up vehicle on 4-wheel drive
To jack up vehicle on 4-wheel drive
GS40110A
Do not crank the engine while jacking up the
vehicle.
The tire on the ground may turn and the vehicle
may roll off the jack.

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-7
GS40210A
E060A08P-GAG
2WD4WD Tightening torque:
Tightening torque: Tightening torque:
Tightening torque:
Tightening torque:GS40230A
GS40200A
Rear
Front
Minibus, Van 12 to 14 kg.m (118 to 137 N.m, 87 to 101 lbs.ft)12 to 14 kg.m (118 to 137 N.m, 87 to 101 lbs.ft)
Truck 18 to 22 kg.m (177 to 216 N.m, 130 to 159 lbs.ft) 18 to 22 kg.m (177 to 216 N.m, 130 to 159 lbs.ft)
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
Never put oil on the wheel bolts or nuts,
Never put oil on the wheel bolts or nuts, Never put oil on the wheel bolts or nuts,
Never put oil on the wheel bolts or nuts,
Never put oil on the wheel bolts or nuts, because this may cause them to become
because this may cause them to become because this may cause them to become
because this may cause them to become
because this may cause them to become
loose.
loose. loose.
loose.
loose.
9. Lower the vehicle slowly and then alter-
nately tighten the nuts until each nut has been tightened to the specified torque. CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
When tightening the wheel nuts, do not
When tightening the wheel nuts, do not When tightening the wheel nuts, do not
When tightening the wheel nuts, do not
When tightening the wheel nuts, do not
apply excessive force to tighten them, such
apply excessive force to tighten them, such apply excessive force to tighten them, such
apply excessive force to tighten them, such
apply excessive force to tighten them, such
as by using your foot to apply force to the
as by using your foot to apply force to the as by using your foot to apply force to the
as by using your foot to apply force to the
as by using your foot to apply force to the
wheel nut wrench, or by using a pipe or
wheel nut wrench, or by using a pipe or wheel nut wrench, or by using a pipe or
wheel nut wrench, or by using a pipe or
wheel nut wrench, or by using a pipe or
similar tool.
similar tool. similar tool.
similar tool.
similar tool.
10. Remove the chock from the wheel.
11. Place the wheel cap, and then tap the wheel cap edge with your hand.
12. The fault tire should be repaired and bal- anced as soon as possible.
6. Refer to the section entitled "Jacking up the
vehicle" to select a jacking point near the flattire at which to position the jack, and thenraise the vehicle until the tire is slightly offthe ground. Remove the wheel nuts.
7. Clean away any mud, etc. on the hub sur- face or in the installation holes in the wheel, and then mount the spare tire.
8. With the tapered side of the wheel nuts facing toward the wheel (see illustration),screw the nuts onto the bolt and tighten allthe way by hand, to the extent that the wheelis not loose.

10-3
INDEX
INDEX INDEX
INDEX
INDEX
J JACK HANDLE ........................................................................................... 4-1
JACKING UP THE VEHICLE ..................................................... 4 - 2 ~ 4 - 3
K KEYS ... .......................................................................................................... 1-4
L LIMITED-SLIP DIFFERENTIAL ........................................................... 3-18
LOADING .................................................................................................. 3-12
LOCKING USING THE KEY .................................................................. 1-9
LOW FUEL WARNING LAMP-AMBER ............................................... 2-9
LUBRICATION CHART ................................................................ 9 - 3 ~ 9 - 4
LUMBAR SUPPORT CONTROL ........................................................1-19
M MAINTENANCE .......................................................................................... 1-2
MAKING A FLAT SEAT ........................................................................ 1-23
MANUAL TRANSMISSION ......................................................... 3 - 4 ~ 3 - 5
MEASUREMENT ........................................................................................ 9-1
METER, GAUGE, AND INDICATION/WARNING
LAMP OPERATION ............................................................................. 8-13
MULTI-FUNCTION LIGHT SWITCH ..................................................2-11
MULTIMETER ............................................................................................. 2-4
O ODOMETER ................................................................................................ 2-5
OIL PRESSURE WARNING LAMP-RED ............................................ 2-9
OUTSIDE REAR VIEW MIRROR ......................................................2-21
OUTSIDE REAR VIEW MIRROR HEATER ....................................2-22
OVERDRIVE OFF INDICATOR ............................................................. 2-9
OVERDRIVE SWITCH ............................................................................. 3-8
OVERHEAD AIR CONDITIONING ....................................................2-29P
PARKING BRAKE LEVEL STROKE .................................................8-14
PARKING BRAKE .................................................................................. 3-12
PARKING ..................................................................................... 3-13 ~ 3-14
PASSING SWITCH ................................................................... 2-11 ~ 2-12
POSITIONS OF SWITCHES AND LEVERS ...................................... 2-1
POWER WINDOW .................................................................... 1-17 ~ 1-18
PRE-TENSIONER SEAT BELT ..........................................................1-24
PREVENTIVE MAINTENANCE .............................................................. 6-1
R REAR AIR-CONDITIONING ................................................................. 2-29
REAR HEATER ....................................................................................... 2-28
REAR ROOM LAMP .............................................................................. 2-18
REAR SIDE, QUARTER WINDOW ......................................1-16 ~ 1-17
REAR WINDOW DEFROSTER SWITCH ........................................2-16
REMOTE FUEL-FILLER LID RELEASE ..............................1-15 ~ 1-16
REMOVAL OF WATER FROM THE FUEL FILTER ........4-13 ~ 4-14
REPLACEMENT OF LAMP BULBS ..................................................4-16
ROOF RACK ............................................................................................ 2-21
RUNNING-IN RECOMMENDATIONS .................................................. 1-1
S SEAT BELTS ........................................................................................... 1-23
3-point system .......................................................................... 1-23 ~ 1-24
Lap belts ................................................................................................. 1-25
SEAT BELT REMINDER LIGHT .........................................................2-10
SEAT WARMER ...................................................................................... 1-19
SECOND SEAT .......................................................................... 1-19 ~ 1-20
SIDE VENTILATOR .............................................................................. 2-26
SLIDING WINDOW GLASS ................................................................. 1-17