
(2) Connect recovery hose to water outlet connec-
tor/thermostat housing (Fig. 29).
(3) Fill container to proper level. Refer to Cooling
System Refilling in this section.
ENGINE BLOCK HEATER
REMOVAL
(1) Drain coolant from radiator and cylinder block.
Refer to Cooling System Draining in this section for
procedure.
(2) Detach power cord plug from heater (Fig. 31).
(3) Loosen screw in center of heater. Remove
heater assembly (Fig. 31).
INSTALLATION
(1) Thoroughly clean core hole and heater seat.
(2) Insert heater assembly with element loop posi-
tionedupward (Fig. 31).
(3) With heater seated, tighten center screw
securely to assure a positive seal.
(4) Connect power cord to block heater (Fig. 31).
(5) Fill cooling system with coolant to the proper
level, vent air, and inspect for leaks.
ACCESSORY DRIVE BELTS
POWER STEERING PUMP AND AIR CONDITIONING
COMPRESSOR BELT
REMOVAL
(1) Using a 17 mm wrench, rotate belt tensioner
clockwise (Fig. 33) until belt can be removed from
power steering pump pulley. Gently, release spring
tension on tensioner.
(2) Remove belt (Fig. 34).
INSTALLATION
(1) Install belt (Fig. 34) over all pulleys except for
the power steering pump pulley.
(2) Using a 17 mm wrench, rotate belt tensioner
clockwise (Fig. 33) until belt can be installed onto
power steering pulley. Release spring tension onto
belt.
NOTE: When installing drive belt onto pulleys,
make sure that belt is properly routed and all
V-grooves make proper contact with pulley grooves.
(3) After belt is installed, inspect belt length indi-
cator marks (Fig. 35). The indicator mark should be
within the minimum belt length and maximum belt
length marks. On a new belt, the indicator mark
should align approximately with the nominal belt
length mark.
Fig. 31 Engine Block Heater
1 ± CORE PLUG
2 ± BLOCK HEATER
3 ± POWER CORD
Fig. 32 Accessory Drive Belts
1 ± GENERATOR BELT
2 ± AUTOMATIC BELT TENSIONER
3 ± POWER STEERING PUMP/A/C COMPRESSOR BELT
7 - 24 COOLING SYSTEMPL
REMOVAL AND INSTALLATION (Continued)

SPECIFICATIONS
COOLING SYSTEM CAPACITY
TORQUE SPECIFICATIONSSPECIAL TOOLS
COOLING
6.2 Liters (6.5 qts.)
CAPACITY, Includes Heater and Coolant Reserve
System
DESCRIPTION N´m Ft.
Lbs.In.
Lbs.
A/C Condenser to RadiatorÐ
Screws5.4 Ð 50
Automatic Belt Tensioner
PulleyÐBolt27 20 Ð
Coolant Recovery ContainerÐ
Nut/Screw4Ð35
Fan Module to RadiatorÐ
Screws7.2 Ð 65
Fan Motor to ShroudÐScrews 3.8 Ð 34
Fan Blade to Motor ShaftÐ
Nut3.8 Ð 34
In Rush Current SupressorÐ
Screw2.6 Ð 23
Generator MountingÐPivot
Bolt54 40 Ð
Generator MountingÐLocking
Nut54 40 Ð
Radiator (Cooling Module) to
BodyÐScrews10 Ð 90
Thermostat Housing/Water
Outlet ConnectorÐScrews12 Ð 105
Transmission HoseÐClamps 2 Ð 18
Water Pump to Engine
BlockÐBolts12 Ð 105
Water Pump Inlet Tube to
Engine BlockÐBolts12 Ð 105
Hose Clamp Pliers 6094
Coolant Refractometer 8286
7 - 30 COOLING SYSTEMPL

DIAGNOSIS AND TESTING
AIRBAG SYSTEM
(1) Disconnect and isolate the battery negative
cable (Fig. 4).
(2) Connect the DRB llltscan tool to the Data
Link Connector (DLC), located at left side of the
steering column and at the lower edge of the lower
instrument panel (Fig. 5). Ensure that the latest ver-
sion is being used.
(3) Turn the ignition key to ON position. Exit vehi-
cle with the DRB llltscan tool.
(4) After checking that no one is inside the vehicle,
connect the battery negative cable.
(5) Using the DRB llltscan tool, read and record
active Diagnostic Trouble Code (DTC) data.
(6) Read and record any stored DTC's.
(7) Refer to the proper Body Diagnostic Procedures
Manual if any DTC's are found in Step 5 or Step 6.
(8) Erase stored DTC's if there are no active
DTC's. If problems remain, DTC's will not erase.
Refer to the proper Body Diagnostic Procedures Man-
ual to diagnose the problem.If airbag warning
lamp either fails to light, or goes on and stays
on, there is a system malfunction. Refer to the
proper Body Diagnostic Procedures Manual to
diagnose the problem.
SERVICE PROCEDURES
CLEAN UP PROCEDURE
Roll of fold the driver side airbag towards the
steering wheel and tape the airbag module cover over
deployed bag.
Roll or fold the passenger airbag towards the
instrument panel surface and close the door over the
folded bag. Then tape the door shut.
Use a vacuum cleaner to remove any residual pow-
der from the vehicle interior. Work from the outside
in to avoid kneeling or sitting in a contaminated
area. Vacuum the heater and A/C outlets as well. If
the heater or air conditioner was in RECIRC mode at
time of airbag deployment, operate blower motor on
low speed and vacuum powder residue expelled from
the heater and A/C outlets. Multiple vacuum cleaning
may to necessary to decontaminate the interior of the
vehicle.
NOTE: Dispose deployed airbag properly, contact
dealer or government agency for disposal recom-
mendations.
SERVICE OF DEPLOYED AIRBAG MODULE
DRIVER AIRBAG
After a Driver Airbag Module has been deployed
the following components must be replaced because
they cannot be reused. Other driver airbag system
components are replaced if damaged.
²Driver Airbag Module
Fig. 4 Battery Negative Cable Remove/Install
1 ± NEGATIVE CABLE
2 ± NEGATIVE BATTERY POST
Fig. 5 Data Link Connector (DLC) Location
1 ± DATA LINK CONNECTOR (DLC)
2 ± BRAKE PEDAL
PLPASSIVE RESTRAINT SYSTEMS 8M - 3

WIRING DIAGRAMS
TABLE OF CONTENTS
page page
AIR CONDITIONING-HEATER........... 8W-42-1
AIRBAG SYSTEM.................... 8W-43-1
ANTI-LOCK BRAKES.................. 8W-35-1
AUDIO SYSTEM..................... 8W-47-1
CHARGING SYSTEM.................. 8W-20-1
COMPONENT INDEX.................. 8W-02-1
CONNECTOR PIN-OUTS............... 8W-80-1
CONNECTOR/GROUND LOCATIONS...... 8W-90-1
FRONT LIGHTING.................... 8W-50-1
FUEL/IGNITION SYSTEM.............. 8W-30-1
FUSE BLOCK........................ 8W-11-1
GENERAL INFORMATION.............. 8W-01-1
GROUND DISTRIBUTION.............. 8W-15-1
HORN/CIGAR LIGHTER/POWER OUTLET . . 8W-41-1
INSTRUMENT CLUSTER............... 8W-40-1INTERIOR LIGHTING.................. 8W-44-1
POWER DISTRIBUTION............... 8W-10-1
POWER DOOR LOCKS................ 8W-61-1
POWER MIRRORS................... 8W-62-1
POWER SUNROOF................... 8W-64-1
POWER WINDOWS................... 8W-60-1
REAR LIGHTING..................... 8W-51-1
REAR WINDOW DEFOGGER............ 8W-48-1
SPLICE INFORMATION................ 8W-70-1
SPLICE LOCATIONS.................. 8W-95-1
STARTING SYSTEM.................. 8W-21-1
TURN SIGNALS...................... 8W-52-1
VEHICLE THEFT SECURITY SYSTEM..... 8W-39-1
WIPERS............................ 8W-53-1
PLWIRING DIAGRAMS 8W - 1

8W-02 COMPONENT INDEX
Component Page
A/C Compressor Clutch Relay............8W-42
A/C Compressor Clutch.................8W-42
A/C Cycling Switch....................8W-42
A/C Heater Blower Motor...............8W-42
A/C Heater Control....................8W-42
A/C Pressure Switches..................8W-42
Airbag Control Module.................8W-43
Airbags.............................8W-43
Antenna.............................8W-47
Automatic Shut Down Relay.............8W-30
Back-Up Lamp Switch..................8W-51
Back-Up Lamps.......................8W-51
Battery.............................8W-20
Blower Motor Resistor Block.............8W-42
Brake Lamp Switch....................8W-30
Brake Shift Interlock Solenoid...........8W-30
Brake Warning Indicator Switch..........8W-40
Camshaft Position Sensor...............8W-30
Cargo Lamp..........................8W-44
Center High Mounted Stop Lamp.........8W-51
Center Stack Lamp....................8W-44
Cigar Lighter/Power Outlet..............8W-41
Circuit Breakers (FB)..................8W-11
City Lamps..........................8W-50
Clockspring.....................8W-33, 41, 43
Clutch Interlock Switch.................8W-30
Combination Flasher...................8W-52
Controller Anti-Lock Brake..............8W-35
Crankshaft Position Sensor..............8W-30
Data Link Connector...................8W-30
Decklid Release Switch.................8W-44
Decklid Solenoid......................8W-61
Diode No. 1..........................8W-42
Dome Lamp..........................8W-44
Dome Lamp/Intrusion Sensor............8W-44
Door Ajar Switches....................8W-40
Door Lock Motors.....................8W-61
Engine Coolant Temperature Sensor.......8W-30
Engine Oil Pressure Switch..............8W-30
Engine Starter Motor Relay.............8W-21
Engine Starter Motor..................8W-21
Fog Lamps........................8W-50, 51
Front Fog Lamp Switch.................8W-50
Fuel Injectors........................8W-30
Fuel Pump Module....................8W-30
Fuel Pump Relay......................8W-30
Fuel Tank...........................8W-30
Fuses (FB)...........................8W-11
Fuses (PDC).........................8W-10
Fuse Block...........................8W-11
Fusible Link A11...................8W-20, 21
Grounds.............................8W-15Component Page
Generator...........................8W-20
Glove Box Lamp/Switch.................8W-44
Headlamp Beam Select..............8W-40, 50
Headlamp Leveling Motors..............8W-50
Headlamp Leveling Switch Illumination....8W-50
Headlamp Leveling Switch..............8W-50
Headlamp Switch...................8W-50, 51
Headlamps..........................8W-50
Horns..............................8W-41
Horn Relay..........................8W-41
Horn Switch.........................8W-41
Hood Ajar Switch......................8W-39
Idle Air Control Motor..................8W-30
Ignition Coil.........................8W-30
Ignition Switch.......................8W-10
Indicators...........................8W-40
Indicator Drivers......................8W-40
Inlet Air Temperature Sensor............8W-30
Instrument Cluster....................8W-40
Instrument Panel Drivers...............8W-40
Knock Sensor.........................8W-30
Leak Detection Pump..................8W-30
License Lamps........................8W-51
Manifold Absolute Pressure Sensor........8W-30
Map/Reading Lamps...................8W-44
Multi- Function Switch.........8W-40, 50, 51, 52
Noise Suppressor......................8W-30
Oxygen Sensors.......................8W-30
Park Brake Switch....................8W-40
Park/Neutral Position Switch............8W-51
Park/Turn Signal Lamps................8W-52
Power Distribution Center...............8W-10
Power Mirror Switch...................8W-62
Power Steering Pressure Switch..........8W-30
Powertrain Control Module..............8W-30
PRNDL Lamp........................8W-44
Proportional Evap/Purge Solenoid.........8W-30
Radiator Fan Motor....................8W-42
Radiator Fan Relay....................8W-42
Radio...............................8W-47
Rear Window Defogger Switch...........8W-48
Rear Window Defogger.................8W-48
Remote Keyless Entry Module............8W-39
Repeater Lamps......................8W-52
Seat Belt Switch......................8W-40
Sentry Key Immobilizer Module..........8W-39
Side Marker Lamps....................8W-50
Siren...............................8W-39
Speakers............................8W-47
Splice Information.....................8W-70
Sunroof Control Module................8W-64
Sunroof Motor........................8W-64
PL8W - 02 COMPONENT INDEX 8W - 02 - 1

8W-11 FUSE BLOCK
Component Page
A/C Compressor Clutch Relay.......8W-11-11, 12
A/C Cycling Switch.................8W-11-7, 8
A/C Heater Blower Motor............8W-11-7, 8
Airbag Control Module.........8W-11-7, 8, 11, 12
Back-Up Lamp Switch..............8W-11-7, 8
Brake Shift Interlock Solenoid........8W-11-7, 8
Circuit Breaker No. 1 (FB)............8W-11-17
Circuit Breaker No. 2 (FB)............8W-11-18
Combination Flasher.................8W-11-6
Controller Anti-Lock Brake.........8W-11-11, 12
Driver Door Lock Switch...............8W-11-9
Driver Power Mirror.................8W-11-16
Driver Power Window Switch........8W-11-9, 17
Fuel Pump Relay.................8W-11-11, 12
Fuse 1 (FB).........................8W-11-6
Fuse 2 (FB).........................8W-11-6
Fuse 3 (FB).........................8W-11-6
Fuse 4 (FB).........................8W-11-6
Fuse 5 (FB).........................8W-11-7
Fuse 6 (FB).......................8W-11-7, 8
Fuse 7 (FB).......................8W-11-7, 8
Fuse 8 (FB).........................8W-11-8
Fuse 9 (FB)........................8W-11-11
Fuse 10 (FB)....................8W-11-10, 11
Fuse 10 (PDC)......................8W-11-16
Fuse 11 (FB)....................8W-11-10, 12
Fuse 12 (FB).......................8W-11-12
Fuse 14 (FB)....................8W-11-13, 14
Fuse 15 (FB)....................8W-11-13, 14
Fuse 16 (FB)....................8W-11-13, 14
Fuse 17 (FB)....................8W-11-19, 20
Fuse 18 (FB)....................8W-11-19, 20
Fuse 19 (FB).......................8W-11-19
Fuse 20 (FB).......................8W-11-16
Fuse Block............8W-11-2, 3, 6, 7, 8, 10, 11,
13, 14, 16, 17, 18, 19
Headlamp Leveling Switch............8W-11-20
Headlamp Switch...................8W-11-13
Instrument Cluster.....8W-11-10, 13, 14, 18, 19, 21
Leak Detection Pump................8W-11-11Component Page
Left City Lamp.....................8W-11-15
Left Front Fog Lamp.................8W-11-19
Left Front Side Marker Lamp..........8W-11-15
Left Headlamp................8W-11-19, 20, 21
Left Headlamp Leveling Motor.........8W-11-20
Left License Lamp..................8W-11-14
Left Park/Turn Signal Lamp...........8W-11-15
Left Tail/Stop Lamp.................8W-11-14
Left Tail/Stop/Turn Signal Lamp........8W-11-13
License Lamp......................8W-11-13
Multi- Function Switch.....8W-11-6, 13, 14, 18, 19
Park/Neutral Position Switch.........8W-11-7, 8
Passenger Door Lock Switch............8W-11-9
Passenger Power Mirror..............8W-11-16
Passenger Power Window Switch.....8W-11-9, 17
Power Distribution Center............8W-11-16
Power Mirror Switch................8W-11-6, 9
Powertrain Control Module.........8W-11-11, 12
Radiator Fan Relay...............8W-11-11, 12
Radio........................8W-11-6, 13, 14
Rear Window Defogger...............8W-11-16
Rear Window Defogger Switch......8W-11-7, 8, 16
Remote Keyless Entry Module......8W-11-10, 13,
14, 18
Right City Lamp....................8W-11-15
Right Front Fog Lamp...............8W-11-19
Right Front Side Marker Lamp.........8W-11-15
Right Headlamp...............8W-11-19, 20, 21
Right Headlamp Leveling Motor........8W-11-20
Right License Lamp.................8W-11-14
Right Park/Turn Signal Lamp..........8W-11-15
Right Tail/Stop Lamp................8W-11-14
Right Tail/Stop/Turn Signal Lamp.......8W-11-13
Sentry Key Immobilizer Module........8W-11-10
Sunroof Control Module...............8W-11-6
Sunroof Switch......................8W-11-6
Torque Converter Clutch Solenoid....8W-11-11, 12
Wipe/Wash Switch...................8W-11-6
Wiper Motor........................8W-11-6
PL8W - 11 FUSE BLOCK 8W - 11 - 1

3
SWITCH POSITION
NEUTRAL
PARK/
B
BACK-UP
MTX ATX
LAMP
SWITCH
WT18 F20 F20
18
WT7FUSE
10A 20A
FUSE
6
10AFUSE
5
272625
BLOCK FUSE RUN A22
15
AIRBAG
CONTROL
MODULE
F25
18
TN/LG
C1
14
DG
4C203
C1
14
DG
1
MOTOR BLOWER
HEATER
A/C-
F20
20
WT
C18C104
F20
20
WT
2C203
F20
20
WT
2
F20
22
WT
76 5
F20
20
WT
S216
A
(8W-11-9)B
(8W-11-9)
11C20511C201
F20
20
WTF20
20
WT
F20
20
WTF20
20
WT
TO
S241 PASSENGER
POWER
WINDOW
SWITCH
TO2C108
2
2
F20
20
WT
SWITCH DEFOGGER
WINDOW
REAR
18
WT20 F20
BUILT-
UP-
EXPORT BUILT-
UP-
EXPORTEXCEPT
SWITCH CYCLING
A/C SOLENOID INTERLOCK
SHIFT
BRAKE
F20
18
WT
(8W-51-2) (8W-51-2)(8W-43-2)
(8W-42-3) (8W-10-9)
(8W-11-2)
(8W-48-2)
(8W-42-6) (8W-30-13)
PL8W-11 FUSE BLOCK
LHD8W - 11 - 7
PLI01107008W-10

3
SWITCH POSITION
NEUTRAL
PARK/
B
BACK-UP
MTX ATX
LAMP
SWITCH
WT18 F20
F20
20
WT
8FUSE10A 20A
FUSE
7
10AFUSE
6
282726
BLOCK FUSE RUN A22
15
AIRBAG
CONTROL
MODULE
F25
18
TN/LG
C1
14
DG
4C203
C1
14
DG
1
MOTOR BLOWER
HEATER
A/C-
F20
20
WT
C18C104
F20
20
WT
2
SWITCH DEFOGGER
WINDOW
REAR
F20
20
WT
2C203
F20
20
WT
2
F20
22
WT
87 6
2
F20
20
WT
SOLENOID INTERLOCK
SHIFT
BRAKE
S216
A
(8W-11-9)B
(8W-11-9)
11C20511C201
F20
20
WTF20
20
WT
F20
20
WTF20
20
WT
TO
S241 PASSENGER
POWER
WINDOW
SWITCH
TO
2C108
18
SWITCH CYCLING
A/C
F20
18
WT
(8W-51-2) (8W-51-2)(8W-43-2)
(8W-42-3)
(8W-48-2)(8W-10-9)
(8W-11-3)
(8W-30-13)
(8W-42-6)
8W - 11 - 8 8W-11 FUSE BLOCK
RHDPL
008W-10PLI01108