2000 CHRYSLER CARAVAN Service Manual

TEST NTC-11ACONTINUED - CHECKING RADIATOR FAN OPERATION
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
TEST NTC-11A
CONTINUED FROM
THE PREVIOUS TURN IGNITION OFF.
PAGE.
KEY ON. REPAIR SHORT TO
REMOVE RAD FAN DOES THE LEFT SIDE YES GROUND IN RAD FAN
RELAY #1.** USING THE DRB, RAD FAN CYCLE ON GROUND CKT. BETWEEN
ACTUATE LOW SPEED AND OFF? LEFT SIDE RAD FAN
RAD FAN. AND RELAY #1*
NO
KEY OFF. USE AN BETWEEN RAD FAN
OHMMETER IN THE RELAY #1 TERMINALS IS THE RESISTANCE YES REPLACE THE RAD
FOLLOWING STEPS. 30 AND 87. BELOW 5.0 OHMS? FAN RELAY #1.*
MEASURE THE
RESISTANCE... FIG.1
NO
DISCONNECT THE MEASURE RESISTANCE REPAIR THE SHORT
RIGHT SIDE RAD FAN BETWEEN RAD FAN IS THE RESISTANCE YES TO GROUND IN THE
HARNESS RELAY #1 HARNESS BELOW 5.0 OHMS? RAD FAN RELAY #3
CONNECTOR.** CONNECTOR CAVITY 5 OUTPUT CIRCUIT.*
AND GROUND. FIG.2
NO
REPLACE THE RIGHT
SIDE RADIATOR
FAN.*
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
355
ProCarManuals.com

TEST NTC-11BCHECKING RADIATOR FAN OPERATION
Perform TEST NTC-11A Before Proceeding
FIG.1FIG.2
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
356
ProCarManuals.com

TEST NTC-11BCHECKING RADIATOR FAN OPERATION
Perform TEST NTC-11A Before Proceeding
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
REMOVE THE DIESEL
POWER RELAY.WITH A JUMPER WIRE
CONNECT DIESEL
POWER RELAY CONN
CAVITIES 30 & 87
(IN PDC).
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
357
ProCarManuals.com

TEST NTC-11BCONTINUED - CHECKING RADIATOR FAN OPERATION
FIG.1
FIG.2
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
358
ProCarManuals.com

TEST NTC-11BCONTINUED - CHECKING RADIATOR FAN OPERATION
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
TEST NTC-11B
CONTINUED FROM
THE PREVIOUS TURN IGNITION OFF.
PAGE.
TURN IGNITION ON. REPAIR THE OPEN
DISCONNECT RAD FAN USING A VOLTMETER, IS THE VOLTAGE NO FUSED BATTERY SUPPLY
RELAY #3.** MEASURE RELAY ABOVE 10.0 VOLTS? CKT. IF THE FUSE IS
HARNESS CONNECTOR BLOWN, CHECK FOR
CAVITY 8. FIG.1 SHORT TO GROUND.*
YES
CONNECT A JUMPER CAVITIES 2 AND 8.
WIRE ACROSS RAD IS THE RIGHT SIDE NO REPAIR OPEN RAD
FAN RELAY #3 RAD FAN ON? FAN RELAY #3
HARNESSOUTPUT CIRCUIT.*
CONNECTOR... FIG.1
YES
DISCONNECT RAD FAN RAD FAN RLY #1
RELAY #1 AND #3 HARNESS CONN. CAVITY IS THE RESISTANCE NO REPAIR OPEN HIGH
HARNESS CONNECTORS. 6 AND RAD FAN RLY #3 BELOW 5.0 OHMS? SPEED FAN CONTROL
MEASURE RESISTANCE HARNESS CONN. CAVITY CIRCUIT.*
BETWEEN... 6. FIG.1 AND 2
YES
MEASURE RESISTANCE RAD FAN RELAY #3
BETWEEN RAD FAN HARNESS CONNECTOR IS THE RESISTANCE NO REPAIR THE OPEN
RELAY #1 HARNESS CAVITY 4. BELOW 5.0 OHMS? DIESEL POWER RELAY
CONNECTOR CAVITY 4OUTPUT CIRCUIT.*
AND... FIG.1
YES
REPLACE THE RAD
FAN RELAY #3.*
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
359
ProCarManuals.com

TEST NTC-11CCHECKING RADIATOR FAN OPERATION
Perform TEST NTC-11A Before Proceeding
FIG.1FIG.2
FIG.3
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
360
ProCarManuals.com

TEST NTC-11CCHECKING RADIATOR FAN OPERATION
Perform TEST NTC-11A Before Proceeding
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
START TEST
NTC-11C. TURN IGNITION OFF.
USING A VOLTMETER,
DISCONNECT THE RAD MEASURE RAD FAN IS THE VOLTAGE NO REPAIR OPEN
FAN RELAY #2.** RELAY #2 HARNESS ABOVE 11.0 VOLTS? BATTERY SUPPLY
CONNECTOR CAVITY 8. CIRCUIT OR FUSE.*
FIG.1
YES
CONNECT A JUMPER
WIRE ACROSS RAD CAVITIES 8 AND 2. DID THE FANS TURN YES REPLACE RAD FAN
FAN RELAY #2 ON? RELAY #2.*
HARNESS
CONNECTOR... FIG.1
NO
REPAIR RELAY #2
DID THE BATTERY YES OUTPUT CKT. FOR
SUPPLY FUSE BLOW? SHORT TO GROUND OR
SHORTED LEFT SIDE
RAD FAN MOTOR.*
NO
DISCONNECT FAN USE A VOLTMETER TO
MOTOR HARNESS MEASURE FAN MOTOR IS THE VOLTAGE NO REPAIR OPEN RELAY
CONNECTOR.** HARNESS CONNECTOR ABOVE 10.0 VOLTS? #2 OUTPUT
WITH JUMPER STILL CAVITY 4. CIRCUIT.*
CONNECTED... FIG.2
YES
RECONNECT FAN CONNECT A JUMPER REPAIR OPEN CKT
MOTOR HARNESS WIRE BETWEEN GROUND DID LEFT SIDE RAD NO BETWEEN RLY #1 AND
CONNECTOR. AND RAD FAN RELAY #1 FAN TURN ON? LEFT SIDE FAN MTR.*
DISCONNECT RAD FAN HARNESS CONNECTOR IF OK, REPLACE LEFT
RELAY #1.** CAVITY 8. FIG.3 SIDE FAN MTR.
YES
CONTINUE TEST
NTC-11C ON THE
NEXT PAGE.
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
361
ProCarManuals.com

TEST NTC-11CCONTINUED - CHECKING RADIATOR FAN OPERATION
FIG.1
FIG.2
N
O
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
362
ProCarManuals.com