2000 CHRYSLER CARAVAN Service Manual

TEST TC-45ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR
DEVIATION COLD
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
CHECK FOR RECENT
TEST TC-45A REPLACEMENT OR
CONTINUED FROM MOVEMENT OF THE
PREVIOUS PAGE. FUEL INJECTION
PUMP ASSEMBLY.
NOTE: AN
IMPROPERLY TIMED WAS THE FUEL YES RESET FUEL
FUEL INJECTION INJECTION PUMP INJECTION PUMP TO
PUMP WILL CAUSE MOVED OR REPLACED? ENGINE TIMING.
THIS CODE TO SET.
NO
INSPECT THE FUEL
SYSTEM FOR AT THE FUEL TANK WAS A RESTRICTION YES REPAIR AS
RESTRICTIONS AT THE MODULE. FOUND? NECESSARY.*
DELIVERY LINES,
FILTER AND....
NO
REPLACE THE FUEL START AND OPERATE
INJECTION PUMP THE ENGINE BETWEEN DOES THE DRB YES REPLACE THE ENGINE
ASSEMBLY. IDLE AND 3500 RPM DISPLAY THIS CODE? CONTROL MODULE.*
USING THE DRB, WHILE MONITORING
ERASE CODES. THE DRB DISPLAY.
NO
TEST COMPLETE.*
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
171
ProCarManuals.com

TEST TC-46AREPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR DEVIATION WARM
Perform TEST DTC Before Proceeding
FIG.1
FIG.2
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
172
ProCarManuals.com

TEST TC-46AREPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR DEVIATION WARM
Perform TEST DTC Before Proceeding
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
START TEST USING THE DRB,
TC-46A. ERASE CODES.
START THE ENGINE.
VARY THE ENGINE MONITOR THE DRB DOES THE DRB YES CONTINUE TEST
SPEED FROM IDLE TO DISPLAY. DISPLAY THIS CODE? TC-46A ON THE
3500 RPM SEVERALNEXT PAGE.
TIMES.
NO
AT THIS TIME, THE USING THE SCHEMATIC
CONDITION REQUIRED AS A GUIDE, INSPECTR WERE ANY PROBLEMS YES REPAIR AS
TO SET THE CODE IS THE WIRING AND FOUND? NECESSARY.*
NOT PRESENT. CONNECTORS.
FIG.1 FIG.2
NO
REFER TO GENERAL
INFORMATION 3.3.2
FOR ADDITIONAL TEST COMPLETE.*
INFORMATION ON
INTERMITTENT CODES.
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
173
ProCarManuals.com

TEST TC-46ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR
DEVIATION WARMT
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
174
ProCarManuals.com

TEST TC-46ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR
DEVIATION WARM
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
CHECK FOR RECENT
TEST TC-46A REPLACEMENT OR
CONTINUED FROM MOVEMENT OF THE
PREVIOUS PAGE. FUEL INJECTION
PUMP ASSEMBLY.
NOTE: AN
IMPROPERLY TIMED WAS THE FUEL YES RESET FUEL
FUEL INJECTION INJECTION PUMP INJECTION PUMP TO
PUMP WILL CAUSE MOVED OR REPLACED? ENGINE TIMING.
THIS CODE TO SET.
NO
INSPECT THE FUEL
SYSTEM FOR AT THE FUEL TANK WAS A RESTRICTION YES REPAIR AS
RESTRICTIONS AT THE MODULE. FOUND? NECESSARY.*
DELIVERY LINES,
FILTER AND....
NO
REPLACE THE FUEL START AND OPERATE
INJECTION PUMP THE ENGINE BETWEEN DOES THE DRB YES REPLACE THE ENGINE
ASSEMBLY. IDLE AND 3500 RPM DISPLAY THIS CODE? CONTROL MODULE.*
USING THE DRB, WHILE MONITORING
ERASE CODES. THE DRB DISPLAY.
NO
TEST COMPLETE.*
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
175
ProCarManuals.com

TEST TC-47AREPAIRING - FUEL TEMPERATURE SENSOR SRC HIGH EXCEEDED
Perform TEST DTC Before Proceeding
FIG.1
FIG.2
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
176
ProCarManuals.com

TEST TC-47AREPAIRING - FUEL TEMPERATURE SENSOR SRC HIGH EXCEEDED
Perform TEST DTC Before Proceeding
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
DOES THE DRB
START TEST USING THE DRB, DISPLAY "FUEL YES CONTINUE TEST
TC-47A. ERASE CODES. TEMPERATURE SENSOR TC-47A ON THE
HIGH EXCEEDED"? NEXT PAGE.
NO
USE THE SCHEMATIC AS DOES THE DRB REPAIR THE HARNESS
A GUIDE AND WIGGLE MONITOR THE DRB DISPLAY "FUEL YES OR CONNECTOR THAT
THE FUEL TEMPERATURE DISPLAY. TEMPERATURE SENSOR CAUSED THE CODE TO
SENSOR CONNECTOR & HIGH EXCEEDED"? SET.*
HARNESS. FIG.1
NO
AT THIS TIME, THE USING THE
CONDITION REQUIRED SCHEMATIC AS A WERE ANY PROBLEMS YES REPAIR AS
TO SET THE CODE IS GUIDE, INSPECT THE FOUND? NECESSARY.*
NOT PRESENT. WIRING AND
FIG.2 CONNECTORS.
NO
REFER TO GENERAL
INFORMATION 3.3.2
FOR ADDITIONAL TEST COMPLETE.*
INFORMATION ON
INTERMITTENT CODES.
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
177
ProCarManuals.com

TEST TC-47ACONTINUED - REPAIRING - FUEL TEMPERATURE SENSOR SRC HIGH EXCEEDED
FIG.1
FIG.2
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
178
ProCarManuals.com