2000 CHRYSLER CARAVAN Service Manual

TEST TC-43ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR NEG. GOVERNOR
DEVIATION COLD
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
TURN IGNITION OFF.
TEST TC-43A DISCONNECT THE
CONTINUED FROM FUEL INJECTION
PREVIOUS PAGE. PUMP CONNECTOR.**
USING AN OHMMETER CONNECTOR TO
MEASURE CAVITY 8 GROUND ON THE FUEL IS THE RESISTANCE YES REPLACE THE FUEL
OF THE FUEL PUMP INJECTION PUMP, BELOW 5.0 OHMS? INJECTION PUMP
ASSEMBLY... HARNESS SIDE. ASSEMBLY.*
FIG.1
NO
USING AN OHMMETER IS THE RESISTANCE REPAIR THE SHORT
DISCONNECT THE ECM MEASURE THE BELOW 10.0 FOR ANY YES TO GROUND ON THE
HARNESS RESISTANCE TO GROUND OF THE MEASUREMENTS? FUEL QUANTITY
CONNECTORS.** AT ECM CAVITIES 59, ACTUATOR CONTROL
66 AND 80. FIG.2 CIRCUIT.*
NO
NOTE: BEFORE
REPLACING THE ECM, DID FUEL INJECTION YES REPLACE THE ENGINE
PERFORM TEST NTC-3A PUMP PASS TEST CONTROL MODULE.*
TO CHECK INTERNAL NTC-3A?
FUEL PUMP CIRCUITRY.
NO
REPLACE THE FUEL
INJECTION PUMP
ASSEMBLY.*
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
163
ProCarManuals.com

TEST TC-44AREPAIRING - FUEL QUANTITY ACTUATOR NEG. GOVERNOR DEVIATION WARM
Perform TEST DTC Before Proceeding
FIG.1
FIG.2
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
164
ProCarManuals.com

TEST TC-44AREPAIRING - FUEL QUANTITY ACTUATOR NEG. GOVERNOR DEVIATION WARM
Perform TEST DTC Before Proceeding
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
START TEST USING THE DRB,
TC-44A. ERASE CODES.
START THE ENGINE.
VARY THE ENGINE MONITOR THE DRB DOES THE DRB YES CONTINUE TEST
SPEED FROM IDLE TO DISPLAY. DISPLAY THIS CODE? TC-44A ON THE
3500 RPM SEVERALNEXT PAGE.
TIMES.
NO
AT THIS TIME, THE USING THE SCHEMATIC
CONDITION REQUIRED AS A GUIDE, INSPECT WERE ANY PROBLEMS YES REPAIR AS
TO SET THE CODE IS THE WIRING AND FOUND? NECESSARY.*
NOT PRESENT. CONNECTORS.
FIG.1 FIG.2
NO
REFER TO GENERAL
INFORMATION 3.3.2
FOR ADDITIONAL TEST COMPLETE.*
INFORMATION ON
INTERMITTENT CODES.
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
165
ProCarManuals.com

TEST TC-44ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR NEG. GOVERNOR
DEVIATION WARM
FIG.1
FIG.2
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
166
ProCarManuals.com

TEST TC-44ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR NEG. GOVERNOR
DEVIATION WARM
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
TURN IGNITION OFF.
TEST TC-44A DISCONNECT THE
CONTINUED FROM FUEL INJECTION
PREVIOUS PAGE. PUMP CONNECTOR.**
USING AN OHMMETER THE CASE OF THE FUEL
MEASURE CAVITY 8 INJECTION PUMP. IS THE RESISTANCE YES REPLACE THE FUEL
OF THE FUEL PUMP BELOW 5.0 OHMS? INJECTION PUMP
ASSEMBLY CONNECTORASSEMBLY.*
TO... FIG.1
NO
USING AN OHMMETER IS THE RESISTANCE REPAIR THE SHORT
DISCONNECT THE ECM MEASURE THE BELOW 10.0 OHMS YES TO GROUND ON THE
HARNESS RESISTANCE TO GROUND FOR ANY OF THE FUEL QUANTITY
CONNECTORS.** AT ECM CAVITIES 59, MEASUREMENTS? ACTUATOR CONTROL
66 AND 80. FIG.2 CIRCUIT.*
NO
NOTE: BEFORE
REPLACING THE ECM, DID FUEL INJECTION YES REPLACE THE ENGINE
PERFORM TEST NTC-3A PUMP PASS TEST CONTROL MODULE.*
TO CHECK INTERNAL NTC-3A?
FUEL PUMP CIRCUITRY.
NO
REPLACE THE FUEL
INJECTION PUMP
ASSEMBLY.*
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
167
ProCarManuals.com

TEST TC-45AREPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR DEVIATION COLD
Perform TEST DTC Before Proceeding
FIG.1
FIG.2
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
168
ProCarManuals.com

TEST TC-45AREPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR DEVIATION COLD
Perform TEST DTC Before Proceeding
*Perform Verification TEST VER-2A. **Check connectors - Clean / repair as necessary.
START TEST USING THE DRB,
TC-45A. ERASE CODES.
START THE ENGINE.
VARY THE ENGINE MONITOR THE DRB DOES THE DRB YES CONTINUE TEST
SPEED FROM IDLE TO DISPLAY. DISPLAY THIS CODE? TC-45A ON THE
3500 RPM SEVERALNEXT PAGE.
TIMES.
NO
AT THIS TIME, THE USING THE SCHEMATIC
CONDITION REQUIRED AS A GUIDE, INSPECT WERE ANY PROBLEMS YES REPAIR AS
TO SET THE CODE IS THE WIRING AND FOUND? NECESSARY.*
NOT PRESENT. CONNECTORS.
FIG.1 FIG.2
NO
REFER TO GENERAL
INFORMATION 3.3.2
FOR ADDITIONAL TEST COMPLETE.*
INFORMATION ON
INTERMITTENT CODES.
T
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
169
ProCarManuals.com

TEST TC-45ACONTINUED - REPAIRING - FUEL QUANTITY ACTUATOR POS. GOVERNOR
DEVIATION COLDT
R
O
U
B
L
E
C
O
D
E
T
E
S
T
S
170
ProCarManuals.com