1997 TOYOTA SUPRA transmission fluid

IN04I-01
- INTRODUCTIONTERMS
IN-33
33 Author
: Date
:
1997 SUPRA (RM502U)
TERMS
ABBREVIATIONS USED IN THIS MANUAL
AbbreviationsMeaning
ABSAnti-Lock Brake System
ALRAutomatic Locking Retractor
APPROX.Approximately
A/T, ATMAutomatic Transmission
AT FAutomatic Transmission Fluid
BTDCBefore Top Dead Center
CBCircuit Breaker
CDCompact Disc
CRSChild Restraint System
DOHCDouble Over Head Cam
DPDash Pot
ECUElectronic Control Unit
ELREmergency Locking Retractor
ESAElectronic Spark Advance
EXExhaust (Manifold, Valve)
FIPGFormed in Place Gasket
FLFusible Link
FrFront
H-FuseHigh Current Fuse
IGIgnition
INIntake (Manifold, Valve)
J/BJunction Block
LEDLight Emitting Diode
LHLeft-Hand
LLCLong Life Coolant (Year Around Coolant)
LSDLimited Slip Differential
Max.Maximum
Min.Minimum
MPMultipurpose
M/TManual Transmission
O/D, ODOverdrive
O/SOversize
P&BVProportioning and Bypass Valve
PCVPositive Crankcase Ventilation
PPSProgressive Power Steering
PSPower Steering
RHRight-Hand
RrRear
SRSSupplemental Restraint System
SSMSpecial Service Materials
SSTSpecial Service Tools
STDStandard

Position of Parts in Engine Compartment
E 4 Engine Coolant Temp. Sender
E 5 Engine Coolant Temp. SW
E 6 Engine Hood Courtesy SW
E 7 Engine Oil Level Sensor
F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light RH and Parking Light RH
F 9 Front Wiper Motor
G 1 Generator
G 2 Generator
H 1 Headlight Hi LH
H 2 Headlight Hi RH
H 3 Headlight Lo LH
H 4 Headlight Lo RH
H 5 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 8 Horn LH
H 9 Horn RH A 1 A/C Ambient Temp Sensor
A 2 A/C Condensor Fan Motor
A 3 A/C Triple Pressure SW
(A/C Dual and Single Pressure SW)
A 4 A/C Magnetic Clutch and Lock Sensor
A 5 A/T Fluid Temp. Sensor
A 6 ABS Actuator
A 7 ABS Actuator
A10 ABS Speed Sensor Front LH
A11 ABS Speed Sensor Front RH
B 1 Back-Up Light SW (M/T)
B 2 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor No.1
C 2 Camshaft Position Sensor No.2
C 3 Crankshaft Position Sensor
C 4 Cruise Control Actuator
D 1 Data Link Connector 1
D 2 Daytime Running Light Relay No.3
D 3 Daytime Running Light Relay No.3
E 1 EGR Gas Temp. Sensor
E 2 Electronically Controlled Transmission Solenoid
E 3 Engine Coolant Temp. Sensor
[2JZ-GTE]
24
26
G ELECTRICAL WIRING ROUTING

26
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[2JZ-GE]
E 1 EGR Gas Temp. Sensor
E 2 Electronically Controlled Transmission Solenoid
E 3 Engine Coolant Temp. Sensor
E 4 Engine Coolant Temp. Sender
E 6 Engine Hood Courtesy SW
E 7 Engine Oil Level Sensor
F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light RH and Parking Light RH
F 9 Front Wiper Motor
G 1 Generator
G 2 Generator A 1 A/C Ambient Temp. Sensor
A 3 A/C Dual Pressure SW
A 4 A/C Magnetic Clutch and Lock Sensor
A 5 A/T Fluid Temp. Sensor
A 6 ABS Actuator
A 7 ABS Actuator
A 8 ABS Relay
A 9 ABS Relay
A10 ABS Speed Sensor Front LH
A11 ABS Speed Sensor Front RH
B 1 Back-Up Light SW (M/T)
B 2 Brake Fluid Level Warning SW
C 3 Crankshaft Position Sensor
C 4 Cruise Control Actuator
D 1 Data Link Connector 1
D 4 Distributor

1 21 2
2 1
1 2
1 2
1 2 2 1
E16 E16 E16
IEIJ1 11
IJ2 12 IJ2 3 B 21 B1A 4 A 20
B 42 B63 B44 B24 B46 A3A18 B27 B7
3 12 8
43124 VTA2 IDL2 THW OIL THG K D M NE NE-
W- B W- B W- BL- R B- R
L- Y
O
BR- Y GR - RY- L
W- B W- B W- B GR- RW- BY- L L- R
W- B W- B
W- B
G- Y
B- R
BRG- YYY- L
G- WYL
G- W WB- R
Y- L
(
SHIELDED)(
SHIELDED) NCO+ NCO-STP TE 1FROM POWER SOURCE SYSTEM (
SEE PAGE 56)
STOP LIGHT
SW DATA LINK
CONNECTOR 1
O/D DIRECT CLUTCH
SPEED SENSOR
S11 D 1
O 1
Y
S 5
SUB THROTTLE
POSITION SENSOR
ENGINE COOLANT TEMP. SENSOR
A/T FLUID TEMP. SENSOR
EGR GAS TEMP. SENSOR
KICK DOWN SW E 3
A 5
E 1
K 4
ELECTRONICALLY CONTROLLED
TRANSMISSION PATTERN
SELECT SW
CRANKSHAFT
POSITION SENSOR
E 8
C 3
ENGINE CONTROL MODULEA E 9 , E1 0B
E14 W- B
W- B
B 65E2
15A
STOP
1I 10
TE1 +B
NORMAL
MANUAL
1J 11H 13
142
ELECTRONICALLY CONTROLLED TRANSMISSION

1 21 2
2 1
1 2
E28 E28
IEIJ1 11
IJ 2 12 IJ2 3A 4 A 20
B 24 B46 A3A18 B25 B7
3 12 8
4 OIL THG KD M G2 G-
W- B W- BB- R
O
BR- Y W- B W- B
W- B W- B
W- B
G- Y
W
GG- YY
G- W G- W WB- R
Y- L
(
SHIELDED)(
SHIELDED) STP TE1FROM P OWER SOURCE SYSTEM (
SEE PAGE 56)
STOP LIGHT
SW DA TA L INK
CONNECTOR 1
S11 D 1
Y A/T FLUID TEMP. SENSOR
EGR GAS TEMP. SENSOR
KICK DOWN SWA 5
E 1
K 4
ELECTRONICALLY CONTROLLED
TRANSMISSION PATTERN
SELECT SW E 8 ENGINE CONTROL MODULEA E 9 , E10B
B 26G1
R
B 27NE
B
1234
DISTRIBUTOR D 4
BR A 32PS
1 2
BR- W BRPOWER STEERING
PRESSURE SW P 3
B 65
W- B
E2
1J 11H 13
NORMAL
MANUAL
NE G1 G2 G-
TE1 +B
15A
STOP
1I 10
152
ELECTRONICALLY CONTROLLED TRANSMISSION

MA01F-02
MA-4
- MAINTENANCEUNDER HOOD
41 Author
: Date
:
1997 SUPRA (RM502U)
UNDER HOOD
GENERAL MAINTENANCE
1. GENERAL NOTES

Maintenance items may vary from country to country. Check the owner's manual supplement in which
the maintenance schedule is shown.

Every service item in the periodic maintenance schedule must be performed.

Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).

Maintenance service after the last period should be performed at the same interval as before unless
otherwise noted.

Failure to do even one item an cause the engine to run poorly and increase exhaust emissions.
2. WINDSHIELD WASHER FLUID
Check that there is sufficient fluid in the tank.
3. ENGINE COOLANT LEVEL
Check that the coolant level is between the ºFULLº and ºLOWº lines on the see-through reservoir.
4. RADIATOR AND HOSES
(a) Check that the front of the radiator is clean and not blocked with leaves, dirt or bugs.
(b) Check the hoses for cracks, kinks, rot or loose connections.
5. BATTERY ELECTROLYTE LEVEL
Check that the electrolyte level of all battery cells is between the upper and lower level lines on the case.
6. BRAKE AND CLUTCH FLUID LEVELS
Check that the brake and clutch fluid levels are near the upper level line on the see-through reservoirs.
7. ENGINE DRIVE BELT
Check drive belt for fraying, cracks, wear or oil contamination.
8. ENGINE OIL LEVEL
Check the level on the dipstick with the engine turned off.
9. POWER STEERING FLUID LEVEL

Check the level on the dipstick.

The level should be in the ºHOTº or ºCOLDº range depending on the fluid temperature.
10. AUTOMATIC TRANSMISSION FLUID LEVEL
(a) Park the vehicle on a level surface.
(b) With the engine idling and the parking brake applied, shift the selector into all positions from ºPº to ºLº,
and then shift into ºPº position.
(c) Pull out the dipstick and wipe off the fluid with a clean rag. Re-insert the dipstick and check that the
fluid level is in the HOT range.
(d) Do this check with the fluid at normal driving temperature (70 - 80°C, 158 - 176°F).
HINT:
Wait until the engine cools down (approx. 30 min.) before checking the fluid level after extended driving at
high speeds, in hot weather, in heavy traffic or pulling a trailer.
11. EXHAUST SYSTEM
If any change in the sound of the exhaust or smell of the exhaust fumes is noticed, have the cause located
and corrected.

B03051Boots
MA01I-02
- MAINTENANCECHASSIS
MA-7
44 Author
: Date
:
1997 SUPRA (RM502U)
CHASSIS
INSPECTION
1. INSPECT STEERING LINKAGE
(a) Check the steering wheel freeplay.
(See page SR-8)
(b) Check the steering linkage for looseness or damage.
Check that:

Tie rod ends do not have excessive play.

Dust seals and boots are not damaged.

Boot clamps are not loose.
2. INSPECT SRS AIRBAG (Seep page RS-9)
3. INSPECT STEERING GEAR HOUSING OIL
Check the steering gear housing for oil leakage.
4. INSPECT BALL JOINT DUST COVERS
Visually check the dust covers for damage.
5. INSPECT TRANSMISSION OIL (FLUID) AND
DIFFERENTIAL OIL
Visually check the transmission and differential for oil (fluid)
leakage.
If leakage is found, check for the cause and repair it.
6. REPLACE MANUAL TRANSMISSION OIL
(W58: See page MT-4)
(V160: See page MT-3)
7. REPLACE AUTOMATIC TRANSMISSION FLUID
(2JZ-GE: See page AT-2)
(2JZ-GTE: See page AT-2)
8. REPLACE DIFFERENTIAL OIL (See page SA-60)