1990 VOLKSWAGEN TRANSPORTER charging

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE

3ATTERY

~he battery
is
located under the
front
pas­
senger
seat.
To
check
the
battery, move

lie
seat all the way forward.

On
vehicles
with
swivel seats,
turn
the
seat
180°
(half circle)
an
then push
for­
ward.
Auxiliary
battery*

The
auxiliary battery
is
located under
the
left
seat.
Push
the
seat all the way forward
to gain
access
to
the battery.

The
auxiliary battery supplies power when the vehicle is stationary.
A
special relay be­
tween the vehicle battery and
the
auxiliary battery prevents
the
vehicle battery from

discharging.
This way, you still have power
to start your vehicle. While driving, both
the vehicle battery
and the
auxiliary bat­
tery are charged.
'where applicable
Always heed WARNINGS on page 97. Battery acid level

Under
normal operating conditions,
the

battery
in
your Volkswagen
is
mainten­

ance-free.

At high outside temperatures
it is
advis­
able,
however,
to
check
the
fluid level
at
regular intervals through
the
transparent
battery housing. The fluid level should
al­

ways
be
between
the "min" and "max"
marks
in
each
cell.

If
the fluid level
is
below the "min" mark,
let

your Volkswagen dealer correct
the
condi­
tion.

WARNING
•
Always shield your eyes and avoid
leaning over the
battery
whenever
pos­

sible.

•
Do not let
battery
acid come in
con­

tact
with
skin,
eyes, fabric, or painted
surface.

•
If
you
get
battery
acid
in
your eyes or

on
your
skin,
immediately rinse
with

cold
water
for several minutes and call a doctor.

•
Do not expose the
battery
to an open

flame
or electric spark. Hydrogen gas generated by the
battery
can explode
and cause personal injury.
109


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE
Winter operation During the winter months, battery capacity
tends to decrease as temperatures drop.
Additionally, more power is consumed while starting, and the headlights, heater, rear window defogger, etc., are used more
frequently. Curtail unnecessary power
consumption,
particularly in city traffic or
when travelling short distances only. Let
your
Volkswagen dealer test the battery's
capacity before winter sets in. A well
charged battery will not only prevent

starting
problems but will also live longer.
If
your
vehicle is left standing for several

weeks
at extremely low temperatures, the battery should be removed and stored
where it will not freeze.
This
will prevent it
from being damaged.
When removing the battery, first discon­ nect both cables (see Charging of Bat­

tery),
then unscrew the battery mounting.
WARNING
Always keep the battery well out of the reach of children.
Always heed WARNINGS on page
97.
Charging of battery
WARNING
•
Always shield
your
eyes and avoid

leaning
over
the battery whenever pos­

sible.

•
Charge battery in a well ventilated

area.
Keep away from open flame or

electrical
spark. Do not
smoke.
Hydro­ gen gas generated by the battery is ex­plosive.

•
Battery acid that may spill during
charging should be washed off with a solution of warm water and baking

soda
to neutralize the
acid.

•
If you get battery
acid
in
your
eyes or
on
your
skin,
immediately rinse with

cold
water for several minutes and
call

a
doctor.

•
Never charge
a
frozen battery. It may
explode because of gas trapped in the
ice.
Allow a frozen battery to thaw out
first.

•
Never use a fast charger as a boo­
ster to start the engine.
This
will
seri­

ously damage sensitive electronic
components,
such as relays, radio,

etc.,
as well as the battery charger.
•
Fast charging
a
battery
is
dangerous
and should only be attempted by a
competent mechanic with the proper
equipment.
Slow battery charging WARNING
•
Heed all WARNINGS and follow in­
structions that come with
your
battery

•
It is not necessary to remove the bat­

tery
from the engine compartment, and it
is
also not necessary to disconnect the

cables.

•
Make sure the electrolyte level in each

cell
is between the "min" and "max" marks. If the fluid level is below the "min" mark, le:

your
Volkswagen dealer correct the condi­

tion.

•
Connect charger cables.
Charger cables must be connected
POSITIVE
(+) to
POSITIVE
(+) and

NEGATIVE
(-) to
NEGATIVE
(-).
Do not connect or disconnect charger

cables
while charger is operating to re­
duce the danger of exploding.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine VEHICLE CARE
• Switch on charger.
• Charging
rate
not over 6 Amp.

Vormally,
a battery should be charged at
rc more than 10 percent of its rated
capa­

city.

For
example, a charging current of 4.5

Amp.
would be used on a battery having
• Ah. Rated capacity of the battery in .our vehicle is listed on the battery

"Dusing.

• After charging,
turn
off charger and dis-
ronnect charger
cables.

To
remove
battery
from
vehicle • Disconnect negative ground cable.
• Disconnect positive cable.
• Unscrew bolt of holding plate with open

end
wrench.
To
reinstall
battery
in vehicle •
Place
battery in vehicle and tighten bolt
of holding plate.
• Reconnect positive cable. • Reconnect negative ground cable.

WARNING
Do not
reverse
polarity.

Cleaning
terminals
and
connections
WARNING
• Before
work
is done on the
electrical

system, disconnect the
negative

ground cable.
•
When
working
on the
battery,
be
sure not to short circuit the
terminals

with
tools or
other
metal
objects. This

would
cause the
battery
to
heat
up
very

quickly,
which
could
lead
to
damage
or
explosion and personal
injury.

The
terminals and connections should be kept clean and greased with silicone spray

or
petroleum jelly. Make sure the ground

connection
to the body is
tight
and free of

corrosion.

With
a disconnected
battery
the
engine
must
not run because the
electrical
sys­
tem
will
be damaged. Replacing
battery

A
replacement battery must have the
same
specifications and dimensions as
the original equipment battery.
Specifica­

tions are listed on the battery housing.
Make
sure the replacement battery is in­

stalled
correctly and securely. See "Re­ moving and reinstalling battery".
Always heed
WARNINGS
on
page
97.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

page

Accessories
122

Air
cleaner 103

Air
Conditioner 54 All-wheel-drive 75
Alternator warning
light
44

Ashtrays
64
Assist
handles and coat hooks ... 67
Automatic safety belts 14
Automatic Transmission 35
Automatic Transmission Fluid .... 102 Auxiliary Heater 57, 60
Battery 109
Battery charging 110

Brake
fluid reservoir 108

Brake
warning
light
43
Brakes
29

Break-in
period 69

Bulb
chart 130

Bulb
replacing 130
Buzzer
7,35

Capacities
147

Catalytic
converter 144

Central
locking system 8
Cigarette lighter 63
Child
safety 15

Chime
7,35

Cleaning
products 89

Climate
controls 51
Clock
41 page

Coolant
temperature gauge .... 41

Cooling
system 104

Consumer
information 152
Corrosion
protection 94

Cruise
control 49

Curtains
27

Cup
holder 66

Dashboard
4

Data
146
Defogging/defrosting 52 Differential lock 33

Dimensions
148
Do-it-yourself service 123

Doors
9

Economically
driving 72

Electric
windows 12

Emergency
equipment 70
Emergency
flasher 46

Emergency
starting 136

Emergency
towing 138

Emission
Control System 144
Engine
code letter 151

Engine
compartment lid 97

Engine
cooling 41,104
Engine
exhaust 144

Engine
number 151

Engine
oil changing 100
pace

Engine
oil checking 9?

Engine
oil grades 9E

Expansion
tank 105

Fan
41, 10c

Folding
table 65

Foreign
country driving 120 Front seats 20

Fuel
economy 72

Fuel
gauge 42
Fuel
injection 142

Fuel
supply 86

Fuel
tank 85

Fuses
12E

Gas
Station
Information
156

Gasoline
additives 86
Gearshift lever 32

Glove
compartment 64
Headlight dimmer and flasher .... 48 Headlights 13C
Headlight adjustment 134
Headlight switch 46

Head
restraints 19 HeatingA/entilation 51
High beam 45,48
Horn 4
Identification label and number ... 151
Ignition/steering lock 38
Indicator lights 43


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans