1990 VOLKSWAGEN TRANSPORTER engine coolant

Downloaded from www.Manualslib.com manuals search engine
INSTRUMENT PANEL AND CONTROLS
page
1 - Air vents 51
2 - Light switch and thumb wheel for instrument illumination 46
3 - Safety belt and brake warning lights 43, 47
4 - Speedometer with trip odometer 40 5 — Warning/indicator lights 6, 43
6 - Clock or tachometer with fuel gauge and coolant temperature gauge 40,41
7 - Rear window defogger switch 47
8 - Emergency flasher switch 46 9 - For additional switch
10 - Air vents, left and right 51
11 - Ashtray 64
12 - Loudspeaker grille
13 - Fuses 128 14 - Turn signal/headlight dimmer switch lever 48
15 - Horn page
16 - Digital clock 40
17 - Steering lock/ignition/starter switch 38
18 - Temperature switch for auxiliary heater 57
19 - Windshield wiper/washer lever 50
20 - Secondary heat exchanger switch 53
21 - Emission Control System (ECS) 45
22 - Climate controls 51
23 - Air vents 51
24 - Radio1)
25 - Cigarette lighter 63 26 - Glove compartment 64
1) A separate brochure is provided for your factory-installed

radio.
If you replace your radio, please be sure to read the notes
in the chapter "Do-it-yourself Service", page 135.
Note
Some features mentioned are standard equipment on some
models only or are options on others.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
[INSTRUMENT
PANEL
AND
CONTROLS

WARNING AND
INDICATOR
LIGHT
SYMBOLS

Symbol
Details

on
page


Turn
signals

44,48

a Alternator A

44

Oil pressure 1^1
43

ID
High beam

45,48

=L Coolant temperature 1^

45,104

(®)
BRAKE
Brake
®
29,43

A Safety belt
14,44

A Emergency flasher

46

m
Rear
window defogger

47
WARNING
If one of the lights marked with ®

comes
on suddenly while driving, move a safe distance off the
road.
Turn

off the engine,
turn
the emergency
fla­

sher on and use other warning devices
to alert other motorists. Go to listed page in
your
Owner's
Manual for ex­

planations.

Some
of the lights mentioned are on certain
models
only and may be options on other

models.

6


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

STARTING
PROCEDURES
WARNING
•
Fasten safety belts before driving.

•
Never
start or let the engine run in a
confined or enclosed, unventilated

area.
Exhaust fumes from the engine
contain carbon monoxide, which is a

colorless
and odorless gas. Carbon monoxide can be
fatal
if inhaled.

•
Never
leave engine idling unatten­

ded.
An unattended vehicle with a run­
ning
engine is potentially hazardous.

•
Do not park or operate the vehicle in

areas
where the hot exhaust system may come in contact with dry grass,

brush,
fuel
spill
or other
material,

which can cause a fire.

•
Do not leave engine unattended at

idle.
When starting engine, be ready to
drive off immediately. Maintain moder­
ate
speed until the engine is
com­

pletely warm. Remember that
your
en­
gine performs best at operating
tem­
perature.
Automatic
Transmission
Engine will only start with selector lever in
Neutral or Park.

Manual
Transmission
Start with gearshift lever in Neutral, clutch

pedal
depressed, so that the starter only

has
to crank the engine.

Starting
engine
•
Do not depress accelerator pedal
when starting. At extrem low temperatures
the engine will probably start better, if you depress accelerator pedal slighly.

•
As soon as the engine starts, release
the ignition key.

•
If the engine does not start the first time
or
stalls,
turn
the ignition off and restart. Depress the accelerator pedal slowly
during the second starting attempt.

•
Operate the starter for no more than

10
seconds.
•
Allow about 30 seconds between each

starting
attempt.
STOPPING
ENGINE

Do not stop engine immediately after
hard or extended driving. Keep engine
running for about two minutes to pre­

vent
excessive heat build-up.
WARNING
•
Before you check anything in the
engine compartment, stop the engine and let it cool down. Hot components

can
burn skin on contact.

•
The radiator fan switches on auto­

matically
when the coolant reaches a cer­

tain
temperature and will continue to run
(even
with ignition off) until the coolant
temperature drops.

39




www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

INSTRUMENTCLUSTER
page

1 -
Speedometer/Odometer
.... 40

2
-
Digital clock*
40

3
-
Tachometer* or normal clock
. . 41

4
-
Coolant temperature gauge
. . 41
5
-
Fuel gauge
42

6
-
Warning/indicator lights
|B25-624J

1 -
Speedometer/Odometer

The
speedometer
indicates road
speed.

The
odometer
indicates
the
distance
driven.
USA
models: Miles

Canada
models: Kilometers
To record
a
distance, reset
the
trip

odometer to
zero by pressing the button.
The last
digit
in red indicates
1
/10 of a mile
or kilometer. 2
-
Digital
clock*
To
set the
digital clock, use
a
ball
point

pen.

•
Push
left
button
below display window
briefly
to
advance one hour
at a
time
and

right
button
to
advance
one
minute
at a

time.

•
Hold buttons depressed
to
advance
hours or minutes rapidly.

•
For second accuracy, synchronize
with

the
aid of a
digital
wrist
watch
or a
time
signal
from
your radio. Set the clock one minute slow, then briefly push
right
button

the moment the seconds of the
wrist
watch have completed a
full
minute or the signal
in the radio sounds.
40 *where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT
I - Tachometer*
"he red shaded area at the end of the scale indicates the maximum permissible
engine rpm (revolutions per minute) for all gears after the break-in period. Before
'eaching this area, the next higher gear
snould be selected or the foot eased off
the accelerator pedal. Earlier shifting saves fuel and reduces noise.
Sniff to the next lower gear when the en-
; ne rpm drops below 1500 rpm.
~ne green shaded area on the scale snows the speed at which the engine is de-
•
eloping its most favourable torque.
3 - Normal clock*

~J
set the clock, depress the knob in the : al center and
turn.
4 - Coolant temperature
gauge X
tare applicable The needle in the coolant temperature
gauge will indicate the temperature of the
coolant shortly after the ignition is
switched on.
When ignition is switched on the warning light (c) will flash for a few seconds as a
functional check.
a - Engine cold
Avoid high engine speeds and heavy throt­ tle when the needle is still in this area of
the
dial.

b - Normal temperature During normal running the needle will re­
main somewhere in the middle of the
dial.
If the engine is working hard at hign a--
bient temperatures, the needle may as:
go further to the right, but this is no cause
for concern so long as the coolant
tem­
perature warning light does not start

flashing.

c - Warning light If the light flashes when driving first check
the coolant temperature gauge. If the nee­
dle is in the normal range, add coolant at the next opportunity. If the needle is in the warn­
ing range, either the coolant level is too low
or the coolant temperature is too high. Move the vehicle a safe distance off the

road,
stop the engine and depress the
emergency flasher switch.
The fan should be operating when the warning light is on (listen for fan, located in
front of car behind grille).
WARNING • To reduce the risk of being burned,
never open the hood if you see or hear
steam or coolant escaping from the
engine compartment. Wait until no
steam or coolant can be seen or heard
before carefully opening the hood.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

WARNING continned •
The
engine compartment
of any

motor vehicle
is a
potentially hazard­
ous
area.
Before you check anything in the engine compartment, stop
the

engine and
let it
cool down. Always
exercise extreme caution when work­
ing
one the
engine. Heed
all of the

WARNINGS on page
97.

Reduce the risk
of
scalding from
hot

coolant by following these steps.
• If the coolant reservoir cap must be
removed, wait until
the
engine
has

cooled down.
• Protect face, hands
and
arms
by

covering
the cap
with
a
large, thick
rag
to
protect against escaping fluid
and
steam.

• Carefully and slowly
turn
cap
one

turn
to
allow excess pressure
to es­
cape before completely removing

cap.

•
To
help avoid being burned,
do not

spill
antifreeze
or
coolant
on the ex­

haust system
or hot
engine parts.
Under
some conditions, the ethylene
glycol
in
engine coolant
is
combusti­
ble.
If a
visual check shows that coolant level
and V-belt
are
normal,
but the
warning light continues to
flash,
contact
your
near­
est dealer
to
have
the
cause located
and

corrected.
For more details see "Cooling system"
on

page 104.

If the
coolant gauge needle nears
the

upper end
of
the scale and the engine ap­
pears
to be
overheating,
turn
off the air

conditioner.
Do
not
install accessories
(fog
lights
or
in­
sect screens,
for
example)
on top of the

front
bumper.
They
may
restrict engine
cooling.
5
-
Fuel gauge
The needle
in
the fuel gauge will indicate the fuel level
in the
tank shortly after
the
ignition is switched on.
The fuel tank capacity is
16
gal/60
(syncro
18.5/70)
liters.
When
the
needle reaches the
red
area
at
the bottom there
is a
reserve
of
about 2.6 U.S. gal.
or
10 liters
of
fuel left in the tank.
Time to refuel.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

WARNING
/ INDICATOR
LIGHTS

1 2 3 4 5 6 7 8
your vehicle is equipped
with
several
•nportant indicator and warning devices to
~ionitor the continued reliable operation of .our vehicle. Familiarize yourself
with

:hese
devices so if one should come on .ou know what to do.
-allure to heed applicable warnings and "nportant vehicle information may result in

serious
personal injury or vehicle damage.

WARNING
•
Whenever
stalled
or stopped for
epair,
move
the
vehicle
a
safe
distance
off the road, stop the
engine
and
turn

on the
emergency
flasher
(see
page

46).
• The
engine
compartment
of any

-lotor
vehicle
is a
potentially
hazard­
ous
area.
Before
you check
anything
in

?ie
engine
compartment,
stop the
engine
and let it cool down.
Always

exercise
extreme
caution
when
work­
ing
under
the
engine
hood.
Heed
all of
re
WARNINGS
on
page
97.
page

1 - Brake 43

2
- Safety belt 18

3
- Turn signals 44
4 - Alternator 44
5
- For additional light
6 - For additional light 7 - Oil pressure 43
8 - High beam 45
9 - Coolant temperature/level . . . 45
10 - For additional switch 9 10
B25-5t?

1-Brake
« ->

The
light comes on while the engine is
cranking.
It goes out after the engine is started and the parking brake is
fully
released.
This is your assurance
that
the
brake warning light is functioning properly.
If the brake warning light does not light JC
while cranking the engine or setting :ne parking brake, there may be a malfunction in the electrical system. In this
case
c;~-
tact your Volkswagen dealer.
'where applicable
Always
heed
WARNINGS
on next page


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
I
CONTROLS AND EQUIPMENT
AUXILIARY HEATER* (Syncro models only)
The auxiliary heater* heats the coolant in the heating circuit and supplies the heat exchanger in the normal heating system
and the additional heat exchanger* for the
passenger compartment heating with heated coolant.
The system is switched off and on or the
switch-
on time preselected by means of a
switch and indicator unit located on the left under the instrument panel.
Air distribution and regulation is done with the controls of the normal heating and
ven­

tilation system (see "Ventilation/Heating"
on page 51).
The auxiliary heater can be used with vehicle stationary or when it is moving.
When vehicle is stationary, the heater only runs for a maximum of 30 minutes in order
to avoid draining the battery. It also switches off automatically when a coolant
temperature of 80° C (175° F) is reached.
When the coolant temperature drops below 70° C (158° F) the heater is auto­matically switched on again. The heater runs on fuel from the vehicle
tank and uses up to half a litre (one quart) per hour. Controls
A - Buttons for setting time and
preselected time
B - Indicator lamp for preselected time
C - Preselected time D - Display
E - Actual time
F - Heater on/off
G - Warning lamp (Heater on)
60 "where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans