2023 TOYOTA RAIZE engine

3166-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
aWasher fluid tank ( ➞P. 324)
b Engine oil filler cap (➞ P. 317)
c Engine oil level dipstick ( ➞P. 316)
d Brake fluid reservoir ( ➞P. 320)
e Battery ( ➞P. 321)
f Fuse box ( ➞P. 348) g
Air cleaner ( ➞P. 325)
hEngine coolant reservoir (➞P. 319)
i Electric cooling fan
j Condenser ( ➞P. 320)
k Radiator ( ➞P. 320)
Engine oil
With the engine at operating temper ature and turned off, check the oil
level on the dipstick.
⬛Checking the engine oil
a Park the vehicle on level ground. After warming up the engine and
turning it off, wait more than 5 minutes for the oil to drain back into the
bottom of the engine.
b Holding a rag under the end, pull the dipstick out.
▶WA-VE engine▶1KR-VET engine
c Wipe the dipstick clean.
d Reinsert the dipstick fully.
eHolding a rag under the end, pull the
dipstick out and check the oil level.
a Low
b Normal
c Excessive
The shape of the dipstick may dif-
fer depending on the type of
vehicle or engine.
f Wipe the dipstick and reinsert it fully.
KBRO620901NKBRO620902N
KBRO620905N
RAIZE_OM_General_BZ358E.book 316 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3176-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
⬛Adding engine oil
If the oil level is below or near the low level mark, add engine oil of the
same type as that already in the engine.
▶WA-VE engine▶1KR-VET engine
Make sure to check the oil type and prepare the items needed before add-
ing oil.
a Remove the oil filler cap by turning it counterclockwise.
b Add engine oil slowly, checking the dipstick.
c Install the oil filler cap by turning it clockwise.
⬛Engine oil consumption
A certain amount of engine oil will be consumed while driving. In the following
situations, oil consumption may increase, and engine oil may need to be
refilled in between oil maintenance intervals.
⚫When the engine is new, for example directly after purchasing the vehicle or
after replacing the engine
⚫If low quality oil or oil of an inappropriate viscosity is used
⚫When driving at high engine speeds or with a heavy load, or when driving
while accelerating or decelerating frequently
⚫When leaving the engine idling for a long time, or when driving frequently
through heavy traffic
KBRO620906NKBRO620907N
Engine oil selection➞ P. 421, 423
Oil quantity (Low to Full)1.5 L (1.6 qt., 1.3 Imp.qt.)
ItemsClean funnel
RAIZE_OM_General_BZ358E.book 317 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3186-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
⚫When the outside temperature is low, the engine oil may become white and
creamy, and it may get to the back of the oil filler cap or oil filling port.This
phenomenon takes place when water vapor in the engine is cooled, forming
water drops, which in turn are mixed wi th the engine oil. This, however, will
disappear when the water evaporates as the outside temperature gets high
or the engine warms up.The engine oil does not deteriorate due to this phe-
nomenon and there will be no problem if the engine oil is continued to be
used.
WARNING
⬛Used engine oil
⚫Used engine oil contains potentially harmful contaminants which may cause
skin disorders such as inflammation and skin cancer, so care should be
taken to avoid prolonged and repeated contact. To remove used engine oil
from your skin, wash thoroughly with soap and water.
⚫Dispose of used oil and filters only in a safe and acceptable manner. Do not
dispose of used oil and filters in hous ehold trash, in sewers or onto the
ground.
Call your Toyota dealer, service stat ion or auto parts store for information
concerning recycling or disposal.
⚫Do not leave used engine oil within the reach of children.
⬛If engine oil is spilled
If oil is spilled on the alternator, wipe off the oil immediately. Oil spilled on the
alternator will cause a fire.
NOTICE
⬛To prevent serious engine damage
Observe the following precautions.
⚫Check the oil level on a regular basis.
⚫Do not use any engine oil additive.
⬛When replacing the engine oil
⚫Be careful not to spill engine oil on the vehicle components.
⚫Avoid overfilling, or the engine could be damaged.
⚫Check the oil level on the dipstick every time you refill the vehicle.
⚫Be sure the engine oil filler cap is properly tightened.
RAIZE_OM_General_BZ358E.book 318 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3196-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Engine coolant
The coolant level is satisfactory if it is between the “FULL” and “LOW” lines
on the reservoir when the engine is cold.
a Reservoir cap
b “FULL” line
c “LOW” line
If the level is on or below the “LOW”
line, add coolant up to the “FULL” line.
(➞ P. 412)
⬛Coolant selection
Only use “Toyota Super Long Life Coolan t” or a similar high quality ethylene
glycol based non-silicate, non-amine, non-nitrite, and non-borate coolant with
long-life hybrid org anic acid technology.
“Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deion-
ized water. (Minimum temperature: -35°C [-31°F])
For more details about engine coolant, contact your Toyota Genuine dealer.
⬛If the coolant level drops within a short time of replenishing
Visually check the radiator, hoses, engine coolant reservoir cap, drain cock and
water pump.
If you cannot find a leak, have your Toyo ta dealer test the cap and check for
leaks in the cooling system.
WARNING
⬛When the engine is hot
Do not remove the radiator cap.
The cooling system may be under pressure and may spray hot coolant if the
cap is removed, causing seri ous injuries, such as burns.
⬛When replacing the coolant
To avoid coolant spilling on the altern ator, do not remove the upper radiator
hose from engine side (remove from the radiator side). Coolant spilled on the
alternator will cause corrosion of the coil and a fire.
1
3
2
KBRO620908N
RAIZE_OM_General_BZ358E.book 319 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3206-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
NOTICE
⬛When adding coolant
Coolant is neither plain water nor straight antifreeze. The correct mixture of
water and antifreeze must be used to provide proper lubrication, corrosion
protection and cooling. Be sure to read the antifreeze or coolant label.
⬛If you spill coolant
Be sure to wash it off with water to pr event it from damaging parts or paint.
Radiator and condenser
Check the radiator and condenser and clear away any foreign objects. If
either of the above parts is extremel y dirty or you are not sure of their
condition, have your vehicle inspected by your Toyota dealer.
WARNING
⬛When the engine is hot
Do not touch the radiator or condenser as they may be hot and cause serious
injuries, such as burns.
Brake fluid
⬛Checking fluid level
The brake fluid level should be
between the “MAX” and “MIN” lines
on the tank.
⬛Adding fluid
Make sure to check the fluid type and prepare the necessary item.
KBRO620912E
Fluid typeFMVSS No.116 DOT 3 brake fluid
ItemClean funnel
RAIZE_OM_General_BZ358E.book 320 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3256-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
WARNING
⬛When adding washer fluid
Do not add washer fluid when the engine is hot or running as washer fluid con-
tains alcohol and may catch fire if spilled on the engine, etc.
NOTICE
⬛Do not use any fluid other than washer fluid
Do not use soapy water or engine an tifreeze instead of washer fluid.
Doing so may cause streaking on the vehicle’s painted surfaces, as well as
damaging the pump leading to proble ms of the washer fluid not spraying.
⬛Diluting washer fluid
Dilute washer fluid with water as necessary.
Refer to the freezing temperatures list ed on the label of the washer fluid bot-
tle.
Air cleaner filter
Check the air cleaner filter as follows:
a Release the clips.
KBRO620913E
RAIZE_OM_General_BZ358E.book 325 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3266-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
bRelease the 2 claws.
c Lift the cover and take out the air
cleaner filter.
Inspect the outer surface of the filter, and replace the filter if it is
extremely dirty. If the filter is only moderately dusty, use compressed air
to blow dust out of the filter.
WARNING
⬛To prevent inhaling dust
Wear a respirator when using compressed air to clean the air cleaner filter.
NOTICE
⬛To prevent damaging the engine
Do not drive with the air cleaner filter removed. Doing so causes excessive
engine wear.
KBRO620915E
KBRO620914E
RAIZE_OM_General_BZ358E.book 326 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3296-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Initializing the tire pressure warning system
(vehicles with a tire pressure warning system)
⬛The tire pressure warning system must be initialized in the
following circumstances:
⚫When rotating front and rear tires which have different tire inflation
pressures
⚫When changing the tire size
When the tire pressure warning system is initialized, the current tire infla-
tion pressure is set as the benchmark pressure.
⬛How to initialize the tire pressure warning system
a Park the vehicle in a safe place and turn the engine switch to “OFF”.
Initialization cannot be performed while the vehicle is moving.
b Adjust the tire inflation pressure to the specified cold tire inflation pres-
sure level. ( ➞P. 428)
Make sure to adjust the tire pressure to the specified cold tire inflation
pressure level. The tire pressure warning system will operate based on
this pressure level.
c Turn the engine switch to “ON”.
d Press and hold the tire pressure
warning reset switch until the tire
pressure warning light blinks
slowly 3 times.
e Wait for a few minutes with the engine switch in “ON” and then turn the
engine switch to “ACC” or “OFF”.
KBRO620403E
RAIZE_OM_General_BZ358E.book 329 ページ ２０２２年５月１７日　火曜日　午後１時５９分