2020 MERCEDES-BENZ SPRINTER gas type

#
Neverre fuel using gasoline in diesel
engines. #
Never mix gasoline with diesel fuel. *
NO
TEDama gedue toincor rect fuel Even small amounts of
the wrong fuel could
re sult in damage tothe fuel sy stem, the
engine and emission cont rol sy stem.
Ne verre fuel with:
R Gasoline
R Marine diesel
R Heating oil
R Pure bio-diesel or vege tab le oil
R Paraffin or kerosene #
Do not mix such fuels with diesel fuel
and do not use any special additives.
If yo u ha veaccidentally refueled with the
wrong fuel, obser vethefo llowing: #
Do not switch on the ignition. #
Consult a qualified specialist workshop. *
NO
TEMalfunctions due tocontaminated
fuel Fu
el contamination can lead tomalfunctions
in the fuel sy stem. #
Ifyo u are using drums or canis ters to
re fuel theve hicle, you should filter the
fuel before filling. *
NO
TEDama gedue toincor rect fuel Incor
rect fuel can lead toengine damage. #
Refuel only ULSD or diesel fuel with a
sulfur content of maximum 15ppm. Usually
you will find information about the fuel
grade on the fuel pump. If there is no identifica‐
tion on the fuel pump, consult a gasst ation
attendant.
The fuel grade recommended foryo ur vehicle is
fo und on the instruction label in the fuel filler
fl ap . Note
s on low outside temperatures &
WARNING Risk offire and explosion due
to fuel igniting
If yo u heat fuel sy stem components, e.g. with
a heat gun or open flame, these components
could be damaged.
Fu el may leak out and ignite. Depending on
th e type of damage, fuel might not escape
until the engine is running. #
Never heat fuel sy stem components. #
Consult a qualified specialist workshop
to have the malfunction rectified. Re
fill only with commercially available ULTRA-
LO W SULFUR DIESEL (ULSD, maximum sulfur
content 15ppm), which fulfills the ASTM D9 75
st andard.
The flow properties of diesel fuel may be inade‐
qu ate at low outside temp eratures due toparaf fin
separation.
% Malfunctions
resulting from paraf fin separa‐
tion can only be rectified byheating the
entire fuel sy stem. Park theve hicle in a
heated garage ,fo rex ample.
To prev ent malfunctions, diesel fuel with
impr oved flow ch aracteristics is available in the
winter mon ths. Yo u can obtain fur ther informa‐
tion on this at thega sst ation or from your fuel
supplier.
Yo ur vehicle is equipped with a fuel preheating
sy stem. This additionally impr ovesth eflow char‐
acteristics of the diesel fuel byabout 14.5 °F
(8 °C). ULTR A-LO W SULFUR DIESEL can be used
without risk of malfunction down toan outside
te mp erature of appr oximately 14.5 °F (-10 °C).
* NO
TEDama gedue togasoline or paraf fin Gasoline or paraf
fin in diesel fuel impairs the
lubricity of the fuel. This can result in damage
to the fuel injection sy stem, forex ample. #
Do not add any gasoline or paraf fin to
diesel fuel toimpr oveitsflow character‐
istics. B20 fuels with bio-diesel content
* NO
TEDama gedue toincor rect fuel Continuous use of fuels wi
thbio-diesel con‐
te nt ove r 5% (B20 fuels) can lead tofuel filter 342
Tech nical da ta

Ad
ditive
* NO
TEEngine damage due touse of addi‐
tives in the engine oil The use of additional additives in
the engine
oil can damage the engine. #
Do not use any additional additives in
the engine oil. Miscibility of engine oil
The benefits of high-quality engine oils are
re
duced bymixing oil.
We recommend that you on lyuse engine oil of
th e same grade and SAE classi fication as the oil
fi lled at the last oil change. If, in exceptional
cases, engine oil of the type in the engine is not
av ailable, use ano ther appr oved mineral or syn‐
th etic engine oil.
Ve hicles with a diesel engine: ifth e grade is
not available, you may also refill with engine oils
acco rding toMB-F reigabe or MB-Appr oval 228.5,
229.3 or 229.5. The refill qu antity is then limited
to maximum 1.1 US qt (1.0 liter).
Yo u must then ha vean oil change car ried out at
th e earliest possible opportunit y.
Ve hicles with a gasoline engine: ifth e grade is
not available, you may refill with engine oils
acco rding toMB-F reigabe or MB-Appr oval 229.3
or AC EA A3/B4. The refill qu antity is then limited
to maximum 1.1 US qt (1.0 liter).
Yo u must then ha vean oil change car ried out at
th e earliest possible opportunit y.
Engine oils are di fferentiated according to:
R Engine oil brand
R Grade (MB-F reigabe or MB-Appr oval)
R SAE classi fication (viscosity)
Oil change inter val
The on-board computer automatically sho ws the
date of the next oil change as an event messa ge
on the displa y.
Mercedes-Benz recommends having the oil
ch anged at a qualified specialist workshop. Engine oil capacities Engine
Engine oil
M2 74 Approx. 11.1 qt
(10.5 liters)
OM642 Approx.13 .2 qt
(12.5 li ters)
OM651 (rear wheel
drive) Appr
ox.12 .2 qt
(1 1. 5 liters) Information on oil consum
ption
Depending on the driving style, theve hicle con‐
sumes a maximum of 1.1 US qt (1.0 liter) of
engine oil per 620 miles (1000 km).
In thefo llowing cases, oil consum ption may also
exc eed this limit:
R The vehicle is ne w.
R You use theve hicle mostly under arduous
conditions.
R You drive frequent lyat a high engine speed.
Re gular maintenance is a prerequisite forfa vo ra‐
ble consum ption figures. You can only assess the
oil consum ption af ter a long journe y.Check the
oil le vel in the engine regularly, e.g. weekly or
eve rytime youre fuel. Note
s on brake fluid Obser
vethe no tes on operating fluids
(/ page 340). &
WARNING Risk of an accident due to
va por poc kets form ing in the brake sys‐
tem
The brake fluid con stant lyabsorbs moisture
from the air. This lo wersthe boiling point of
th e brake fluid. If the boiling point is too lo w,
va por poc kets may form inthe brake sy stem
when the brakes are applied hard.
This causes the braking ef fect to be impaired. #
Have the brake fluid rene we d at the
specified inter vals. *
NO
TEDama getopaint, plastic or rubber
by brake fluid There is a
risk of damage toproperty if brake
fl uid comes into con tact wi thpaint, plastic or
ru bber. 346
Tech nical da ta

#
Make sure that no windshield washer
concentrate spills out next tothefiller
opening. *
NO
TEDama getotheex terior lighting
due tounsuitable windshield washer fluid Uns
uitable windshield washer fluid may dam‐
age the plastic sur face of theex terior lighting. #
Only use windshield washer fluid which
is also suitable for use on plast ic surfa‐
ces, e.g. MB SummerFit or MB Winter‐
Fit. *
NO
TEBlocked spr aynozzles caused by
mixing windshield washer fluids #
Do not mix MB SummerFit and MB Win‐
te rFit with other windshield washer flu‐
ids. Do not use distilled or de-ionized
water.Other‐
wise, thefill le vel sensor may give a false reading.
Information on the windshield washer fluid
Re commended windshield washer fluid:
R abovefreezing point: e.g. MB SummerFit
R below freezing point: e.g. MB WinterFit
Mixing ratio
Fo rth e cor rect mixing ratio, referto the informa‐
tion on the anti-freeze container.
Mix thewa sher fluid with windshield washer fluid
all year round.
Fi lling capacities
Wi ndshield washer sy stem
Wa sher fluid
5.8 qt (5.5 l) Re
frigerant Note
s onrefrigerant
Obser vethe no tes on operating fluids
(/ page 340).
% Yo
ur vehicle's climate contro l system can be
fi lled with R‑134a refrigerant. The refrigerant
R‑134a contains fluorinated greenhouse gas.
If yo ur vehicle is filled with R‑134a refrigerant, the
fo llowing information applies: *
NO
TEDama gecaused byincor rect refrig‐
erant If
th e incor rect refrigerant is used, this can
damage the climate cont rol sy stem. #
Use only R‑134a refrigerant or thePAG
oil appr ovedfo ryo ur vehicle by
Mercedes-Benz. #
The appr ovedPA G oil may not be mixed
with any other PAG oil that is not
appr ovedfo r R‑134a refrigerant. Maintenance
work, such as adding refrigerant or
re placing components, may be car ried out only
by aqu alified specialist workshop. All the applica‐
ble regulations relating tothis and theSA E J639
st andard must be adhered to.
All workon the climate cont rol sy stem should
alw ays be car ried out at a qualified specialist
wo rkshop. Example:
refrigerant warning label
1 Warning symbols
2 Refrigerant capacity
3 Applicable standards
4 PAG oil part number
5 Refrigerant type
Wa rning symbols 1referto thefo llowing:
R Potential dangers
R The per form ance of main tenance workat a
qu alified specialist workshop Ve
hicle data Information on
vehicle dimensions The
following section con tains impor tant tech ni‐
cal da taforyo ur vehicle. Your vehicle documents
contain fur ther vehicle-specific and equipment-
dependent tech nical da tasuch as vehicle dimen‐
sions and weights. 348
Tech nical da ta

Maximum permissible
weights and loads
Ve hicle type, gross vehicle weight and curb weight Ve
hicle model Perm issible gross vehicle
we ight GVWR Pe
rm issible curb weight 7)
15 00 8550 lbs (3.878t) 7400 lbs (3.357 t)
2500 8550 lbs (3.878t)
9050 lb s (4.105 t)
94 80 lbs (4.300 t) 7000 lbs (3.175 t)
(gasoline only)
74 00 lbs (3.357 t)
(diesel only)
3500 9900 lbs (4.490 t) (For Canada
only)74
00 lbs (3.357 t)
9989 lbs (4.531 t) (For USA
only)
3500 XD 11030 lbs (5.003 t) 10470 lbs (4.749 t)
4500 12125 lbs (5.500 t) 9375 lbs (4.252 t) 7)
Maximum permissible curb weight of a road‐
wo rthy vehicle without driver or occupants,
including all fluids and their tanks when filled up
to 100%.
Fr ont axle load, rear axle load, gross weight of vehicle combination (se ries, optional)
Ve hicle types 1500 and 2500 with a max. permissible gross weight of 8,550 lbs (3.8 78t),
9,050 lbs (4 .105 t) and 9,480 lbs (4.300 t) Pe
rm issible front axle load GAWR (FA) Perm issible rear axle load GAWR (RA)
41 00 lbs (1.860 t) 5)
5360 lbs (2.431 t)
44 10 lbs (2.000 t) 1) Ve
hicle type 3500 with a max. permissible gross weight of 9900 lbs (4.490 t) (For Canada only)
and 9989 lbs (4.531 t) (For USA only) Pe
rm issible front axle load GAWR (FA) Perm issible rear axle load GAWR (RA)
4080 lbs (1.851 t) 5)
7060 lbs (3.202 t)
44 10 lbs (2.000 t) 1) 350
Tech nical da ta

St
arting an automatic gasst ation
sear ch.............................................. 227
St arting the automatic service sta‐
tion sear ch....................................... 227
In tern et
Calling up a web page ...................... 257
Calling up thewe b br ows er set‐
tings .................................................2 58
Calling up web br ows er options .......2 58
Closing the br ows er .........................2 59
Deleting a bookma rk........................ 258
Deleting his tory ................................ 258
Managing bookmar ks....................... 258
In tern etconnection
Au tomatic disconnection .................. 256
Canceling permission (mobile
phone) ............................................. .256
Communication module function ..... 254
Connection status ............................ 256
Disconnection following Inactivity .... 256
Displaying the connection status .... .256
Es tablishing ...................................... 256
Es tablishing automatically ................ 256
Information ...................................... 254
Mobile phone de tails ........................ 256
Re strictions ...................................... 254
Setting access da ta(Blue tooth ®
) .....2 55
Setting up (Blu etoo th®
) .................... 255
Setting up (Wi-Fi) .............................. 255
Internet radio
Calling up thest ation list (category
last selec ted) .................................... 261
Internet radio
see TuneIn
iPhone ®
see Apple CarPl ay® J
Jack ........................................................ 327
Hydraulic .......................................... 306
Re moving thehy draulic jack from
th estow age compartment .............. .307
St orage location of hydraulic jack .... 306
Jump-start connection .........................295 K
Ke y........................................................... 46
Battery ............................................... 47
Electrical consumption ....................... 47
Fu nctions ........................................... 46
Ke yring attachment ........................... 47
Mechanical key .................................. .47Overview ............................................ 46
Problem ..............................................48
Ra
dio connection ...............................46
Un locking setting ................................ 47 L
Labeling (tires) see Tire labeling
Lane de tection (au tomatic)
see Active Lane Keeping Assist
Lane Keeping Assist ............................ .166
Fu nction ........................................... 16 6
Sy stem limitations ............................1 66
Tr ailer operation .............................. .166
Lane Keeping Assist
see Active Lane Keeping Assist
see Lane Keeping Assist
Language ............................................... 213
No tes ................................................ 213
Setting .............................................. 213
LA TC H-type (ISOFIX) child seat
securing sy stem
In stalling ............................................ .41
Le vel control
see ENR (elect ronic le vel control)
License pla telamp (changing bulbs) .... 93
Light switch (o verview) ........................ .84
Lighting see Lights
Lights ...................................................... 84
Ad aptive Highbeam Assist .................. 86
Au tomatic driving lights ...................... 84
Combination swit ch............................ 85
Co rnering light ................................... 85
Driving abroad (symmetrical low
beam) .................................................84
Haza rdwa rning lamps ........................ 85
High beam .......................................... 85
High-beam flasher .............................. 85
Indicator ............................................ .85
Light switch ........................................ 84
Low beam ........................................... 84
Pa rking light ...................................... .84
Re ar fog light ...................................... 84
Re sponsibility with lighting sy stems ... 84
Setting theex terior lighting switch-
off delay time .....................................86
Setting the instrument lighting ......... 178
Switching the sur round lighting
on/off ................................................ 87
Limited Warranty (vehicle) ....................27 398
Index

see
Touch Control N
Na vigation
Menu (on-board computer) ............... 181
Overview ...........................................2 17
Showing/hiding the menu ................2 16
Switching on ..................................... 216
Up dating the map data ..................... 239
Vo ice commands (Voice Cont rol
Sy stem) ............................................ 187
Na vigation
see Destination
see Destination entry
see Parking service
see Route
see Route guidance
see Traf fic information
Na vigation announcements
Ac tivating/deactivating .................... 230
Ad justing thevo lume ........................ 231
Re peating .........................................2 31
Switching audio fadeout on/off ........ 231
Na vigation instructions (on-board
computer) ..............................................1 81
Ne arField Communication (NFC) .......2 45
Connecting a mobile phone tothe
MBUX multimedia sy stem ................2 45
Gene ral information .......................... 24 5
Switching mobile phones ................. 24 5
Using a mobile phone ....................... 24 5
NFC see Near Field Communication (NFC)
No tification types ................................ 205
No tifications Center
Calling up notifications ..................... 206
Editing notifications ......................... 206
Global sea rch ................................... 207
Noti fication types ............................. 205
Overview .......................................... 205
Selecting actions for notifications .... 206
Using theglobal sear ch.................... 207
No tifications Center
see Notification types
No zzles
see Air vents O
Occupant saf ety
see Airbag
see Pets in theve hicle see
Restra int sy stem
see Seat belt
Odome ter
see Display total dis tance (trip menu)
Oil see Engine oil
On-board co mputer .............................. 176
Ad justing thest ationary heater/
ve ntilation ......................................... 107
Assi stance graphic menu ................ .179
Diesel particulate filter load display
.......................................................... 12 0
Displ aying the service due date ........ 278
Media menu .....................................1 82
Menu navigation ............................... 181
Menus overview ................................ 176
Multifunction display ........................ 17 7
Operating .......................................... 176
Ra dio menu ...................................... 181
Service menu .................................... 178
Settings menu .................................. 183
Te lephone menu .............................. .182
Tr ip menu ........................................ .179
On-board diagno stics inter face
see Diagno stics connection
On-boa rdelectronics
Engine electronics ............................ 337
No tes ................................................ 337
Tw o-w ayradios .................................3 37
Open-source software ........................... 30
Opening and closing the loc kable
compartment abo vethe windshield .....78
Opening the cup holder in there ar
passen ger co mpartment ....................... 78
Opening/closing the hood .................. 278
Operating fluids
Ad ditives (fuel) .................................. 341
Brake fluid ........................................ 346
Coolant (engine) .............................. .347
DEF .................................................. 343
Engine oil ......................................... 344
Fu el (diesel) ...................................... 341
Fu el (gasoline) ..................................3 41
No tes ............................................... 340
Wi ndshield washer fluid .......... .347, 348
Operating Instructions (vehicle
equipment) .............................................23
Operating saf ety
Chan ges in the engine po wer out‐
put ...................................................... 26
Information ........................................ .24 Index
401