2020 FIAT 500 Owner handbook (in English)

RIMS AND TYRES PROVIDED
Versions Wheels Tyres Snow tyresSpace saver spare wheel(*)Rim -
Tyre
1.2 8V 69
HP5½Jx14H2-ET35 175/65 R14 82T 175/65 R14 82Q (M+S)
4.00Bx14 ET43 – 135x80 R14 84P
4.00Bx14 ET43 – 135x80 R14 84M
4.00Bx14 ET43 – 135x80 B14 84M 5½Jx14H2-ET35 175/65 R14 86T 175/65 R14 82Q (M+S)
6Jx15H2-ET35
(**)185/55 R15 82H(***)185/55 R15 82Q (M+S)
6½Jx16H2-ET35
(**)195/45 R16 84H(***)195/45 R16 84Q (M+S)
0.9
TwinAir
85 HP
(*)
5½Jx14H2-ET35 175/65 R14 82T 175/65 R14 82Q (M+S)
4.00Bx14 ET43 – 135x80 R14 84M
4.00Bx14 ET43 – 135x80 R14 84P
4.00Bx14 ET43 – 135x80 B14 84M 5½Jx14H2-ET35 175/65 R14 86T 175/65 R14 82Q (M+S)
6Jx15H2-ET35
(**)185/55 R15 82H(***)185/55 R15 82Q (M+S)
6½Jx16H2-ET35
(**)195/45 R16 84H(***)195/45 R16 84Q (M+S)
(*) For versions/markets, where provided
(**) Alloy wheel rim
(***) Not suitable for snow chains
159

COLD TYRE INFLATION PRESSURE (bar)
195) 196)
When the tires are warm, the inflation pressure should be + 0.3 bar in relation to the recommended figure.
With snow tyres, add +0.2 bar to the pressure value prescribed for other standard tyres.
However, recheck that the value is correct with the tyre cold.
TyresMedium load Full load
Space saver spare
wheel(*)Front Rear Front Rear
175/65 R14 82T/86T
(1.2 ECO versions)2.4(**)/2.2(***)2.2(**)/2.0(***)2.4(**)/2.3(***)2.2(**)/2.2(***)
2.8 175/65 R14 82T 2.2 2.0 2.3 2.2
175/65 R14 86T 2.2 2.0 2.3 2.2
185/55 R15 82H 2.2 2.1 2.3 2.3
195/45 R16 84H 2.2 2.1 2.4 2.3
(*) For versions/markets, where provided
(**) ECO
(***) COMFORT: ECO consumption is not guaranteed
160
TECHNICAL DATA

SNOW TYRES
200)
Use snow tyres of the same size as the
standard tyres provided with the car.
All four tyres should be the same (brand
and track) to ensure greater safety
when driving and braking as well as a
good manoeuvrability.
Remember that you should not change
the rotation direction of the tyres.
The Fiat Dealership will be happy to
provide advice concerning the most
suitable type of tyre for the customer's
requirements.
The winter performance of these tyres
is considerably reduced when the tread
thickness is less than 4 mm. Replace
them in this case.
Due to the specific characteristics of
snow tyres, in normal weather
conditions or on long motorway
journeys, the performance of these
tyres is lower than that of standard
tyres. Their usage should therefore be
restricted in accordance with their
type approval.IMPORTANT When using snow tyres
with a maximum speed index below the
one that can be reached by the car
(increased by 5%), place a notice in the
passenger compartment, plainly in
view, which states the maximum speed
allowed by the snow tyres (as per EC
Directive). All four tyres should be
the same (brand and track) to ensure
greater safety when driving and braking
as well as a good manoeuvrability.
Remember that you should not change
the rotation direction of the tyres.
SNOW CHAINS
67) 68) 69)
The use of snow chains should be in
compliance with local regulations of
each country. In certain countries, tyres
marked with code M+S (Mud and
Snow) are considered as winter
equipment; therefore their use is
equivalent to that of the snow chains.
Snow chains can be fitted to the tyres
of the front wheels (drive wheels) only.
Check the tension of the snow chains
after the first few metres have been
driven.
Using snow chains with tyres with
non-original dimensions may damage
the vehicle.Using different size or type (M+S, snow,
etc.) tyres between front and rear axle
may adversely affect car driveability,
with the risk of losing control of the car
and resulting accidents.
IMPORTANT Snow chains cannot be
fitted to the space-saver wheel. If a
front tyre is punctured, replace a rear
wheel with the space-saver wheel and
move the rear wheel to the front axle. In
this way, with two normal drive wheels
at the front, snow chains can be fitted.WARNING
193)The space-saver wheel (for
versions/markets where provided) is
specific to your car, do not use it on other
models, or use the space-saver wheel
of other models on your car. The
space-saver wheel must only be used in
the event of an emergency. Never use it for
more than strictly necessary and never
exceed a speed of 80 km/h.
194)Snow chains cannot be fitted to the
space-saver wheel. So, if a front (drive)
wheel is punctured and chains are needed,
a rear wheel should be fitted to the front
of the car and the space-saver wheel
should be fitted to the rear. In this way,
equipped with two normal drive wheels at
the front, they can be fitted with snow
chains, thus resolving the emergency
situation
161

195)Remember that the road holding
qualities of your car also depend on correct
tyre pressures.
196)If tyre pressure is too low, the tyre
may overheat and be severely damaged as
a result.
197)Do not switch tyres from the
right­hand side of the vehicle to the
left­hand side, and vice versa.
198)Never submit alloy rims to repainting
treatments requiring the use of
temperatures exceeding 150°C. The
mechanical properties of the wheels could
be impaired.
199)DO NOT fit wheel hub caps when
using integral hub caps fixed (with springs)
to the steel rim and after sale tyres
provided with Rim Protector. Use of
unsuitable tyres and wheel caps may
cause sudden decrease of tyre pressure.
200)The maximum speed for snow tyres
marked “Q” is 160 km/h, while it is 190
km/h for “T” tyres and 210 km/h for "H"
tyres. The highway code speed limits must
however always be complied with.
WARNING
67)Keep the vehicle's speed down when
snow chains are fitted; never exceed 50
km/h.
68)With snow chains, use the accelerator
with extreme care to prevent, or to limit
as much as possible, slipping of the drive
wheels that could cause chain breakage,
resulting in damage to the car body or
mechanical components.69)Avoid potholes, steps and pavements
and avoid driving long distances on roads
not covered with snow to avoid damaging
the car and the roadbed.
162
TECHNICAL DATA

DIMENSIONS
Dimensions are expressed in mm and refer to the vehicle equipped with its standard-supplied tyres. Height is measured with
car unladen.
BOOT VOLUMEPetrol versions: capacity (VDA standards): 185 litres.LPG versions: capacity (VDA standards): 165 litres.
Versions A B C D E F G I
0.9 TwinAir 85 HP(°)3571 720 2300 551
1488(*)1413 /
1414(**)16271407 /
1408(**)
1.2 8V 69 HP 3571 720 2300 551
1488(*)1413 1627 1407
(°) For versions/markets, where provided
(*) Small variations in size are possible depending on the dimensions of the rims.
(**) With 195/45 R16 tyres
140F0S0605
163

WEIGHTS
Versions 1.2 8V 69 HP1.2 8V 69 HP
LPG0.9 TwinAir 85 HP(°)
Unladen weight (with all fluids, fuel tank filled
to 90% and without optional equipment) (kg):960 / 975(*)980 / 995(*)980 980 1000
Payload including the driver (kg)
(**)400 / 385(*)380 / 365(*)380 390 385
Maximum permitted loads (kg)
(***)
- front axle: 770 770 770 830 830
– rear axle: 640 640 640 640 640
- total: 1360 1360 1360 1370 1385
Towable loads (kg)
– braked trailer:
(****) (****) (****)800 800
– non-braked trailer:
(****) (****) (****)400 400
Maximum load on the ball (braked trailer)
(kg):
(****) (****) (****)60 60
(°) For versions/markets, where provided
(*) Versions with Dualogic transmission
(**) If special equipment is fitted (sunroof, etc.) the unladen car weight increases, thus reducing the specified payload in relation to the maximum permitted loads.
(***) Loads not to be exceeded. The user should carry goods in the luggage compartment and/on load carrying platform within the maximum permitted loads.
(****) IMPORTANT A trailer cannot be towed so there are no provisions for fitting a tow hook.
164
TECHNICAL DATA

REFUELLING
1.2 8V 69 HP / 1.2
8V 69 HP LPG0.9 TwinAir 85 HP(°)Prescribed fuels and original lubricants
Fuel tank (petrol - litres):
35 / 30.5(***)35
Unleaded petrol with RON no lower than 95
(EN228 specifications)
including a reserve of (litres): 5.0 5.0
Engine cooling system:
4.85 / 5.2
(**)5.3Mixture of distilled water and PARAFLUUP
liquid at 50%(*)
Engine sump (litres):- 2.8 SELENIA DIGITEK P.E.
2.5 -SELENIA K P.E. (1.2 8V 69 HP version) /
SELENIA MULTIPOWER GAS 5W-40 (1.2
8V 69 HP LPG)
Engine sump and filter (litres):- 3.2 SELENIA DIGITEK P.E.
2.8 -SELENIA K P.E. (1.2 8V 69 HP version) /
SELENIA MULTIPOWER GAS 5W-40 (1.2
8V 69 HP LPG)
Gearbox/differential casing (litres): 1.65 1.65 TUTELA TRANSMISSION GEARFORCE
(°) For versions/markets, where provided
(***) LPG versions (including reserve). The figure already takes into account the 80% tank filling limit and the residual fluid required for priming and the maximum
permitted capacity. In addition, after different refuelling processes, this figure may vary due to differences between the network pump supply pressures, pumps
having different supply/locking features, tank not completely run out of fuel. (**) LPG versions (*) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLUUPand demineralised water.
165

1.2 8V 69 HP / 1.2
8V 69 HP LPG0.9 TwinAir 85 HP(°)Prescribed fuels and original lubricants
Dualogic gearbox hydraulic activation
system:0.70 (litres) / (0.59) kg -TUTELA CS SPEED Special oil with “ATF
DEXRON III” type additive
Hydraulic brakes circuit (kg): 0.55 0.55
TUTELA TOP 4/S
Hydraulic clutch controls (RH drive versions): 0.100 -
Windscreen and rear window washer fluid
reservoir (litres):2.5 2.5Mixture of water and PETRONAS DURANCE
SC35
(°) For versions/markets, where provided
166
TECHNICAL DATA