2018 CITROEN C4 Owners Manual

215
C4-cactus_en_Chap08_En-cas-de-panne_ed01-2016
Do not force the lever as locking will not   be   possible   if   the   clamp   is   not  
p

ositioned   correctly;   start   the   procedure  
ag

ain.
Quick release terminal
Disconnecting the (+) terminal
F Raise the lever A fully to release the clamp  B.
The
  Stop   &   Start   system   may   not   be  
o

perational   during   the   trip   following   the  
f

irst   engine   start.
In
  this   case,   the   system   will   only   be  
a

vailable   again   after   a   continuous  
p

eriod   of   immobilisation   of   the   vehicle,  
a

  period   which   depends   on   the   ambient  
t

emperature   and   the   state   of   charge   of  
t

he   battery   (up   to   about   8   hours).
It
 
is
 
recommended
 
that
 
the
 
battery
 
be
 
d

isconnected if the vehicle is not to be used
for
 
a
 
very
 
long
 
period,
 
so
 
as
 
to
 
maintain
 
an
 
a

dequate
 
state
 
of
 
charge
 
for
 
starting
 
the
 
e

ngine.
Before
 
disconnecting
 
the
 
battery:
F
 
c

lose
 
all
 
openings
 
(doors,
 
boot,
 
windows,
 
r

oof),
F
 
s

witch
 
off
 
all
 
electrical
 
consumers
 
(audio
 
s

ystem,
 
wipers,
 
lighting...),
F
 
s

witch
 
off
 
the
 
ignition
 
and
 
then
 
wait
 f
our minutes.
At
 
the
 
battery,
 
simply
 
detach
 
the
 
(+)
 
terminal.
Disconnecting the battery
Following reconnection of the battery, switch on t
he   ignition   and   wait   1   minute   before   starting   to  
p

ermit   initialisation   of   the   electronic   systems.  
H

owever,   if   problems   remain   following   this  
o

peration, contact a CITROËN dealer or a
qualified
 w

orkshop.
Referring
  to   the   corresponding   section,   you  
m

ust
 y
ourself
 r
einitialise
 (
depending
 o
n
 ve

rsion):
-
 
t
he   remote   control   key,
-
 ...
Following reconnection of the battery
Reconnecting the (+) terminal
F Position   the   open   clamp   B of the cable on
the   positive   post   (+)   of   the   battery.
F
 
P
ress   down   on   the   clamp   to   position   it  
c

orrectly   on   the   battery   post.
F
 
L
ock   the   clamp   by   lowering   the   lever   A.
8
In the event of a breakdown

216
C4-cactus_en_Chap08_En-cas-de-panne_ed01-2016
To w i n g
General recommendations
Observe the legislation in force in your country.
E nsure   that   the   weight   of   the   towing   vehicle   is   higher   than   that   of   the   towed   vehicle.
The
  driver   must   remain   at   the   wheel   of   the   towed   vehicle   and   must   have   a   valid   driving   licence.
When
  towing   a   vehicle   with   all   four   wheels   on   the   ground,   always   use   an   approved   towing   arm;
 r

ope   and   straps   are   prohibited.
The
  towing   vehicle   must   move   off   gently.
When
  towing   a   vehicle   with   the   engine   off,   there   is   no   longer   any   power   assistance   for   braking
 o

r   steering.
In
  the   following   cases,   you   must   always   call   on   a   professional   recovery   service:
-
 
v
ehicle   broken   down   on   a   motor way   or   fast   road,
-
f

our-wheel drive vehicle,
-
 
w
hen   it   is   not   possible   to   put   the   gearbox   into   neutral,   unlock   the   steering,   or   release   the
 par

king
 b
rake,
-
 
t
owing   with   only   two   wheels   on   the   ground,
-
 
w
here   there   is   no   approved   towing   arm   available...
Procedure
 
for
 
having
 
your
 
vehicle
 
towed
 
or
 
for
 
towing
 
another   vehicle   using   a   removable   towing   eye.
The towing eye is stowed under the boot floor,
or
 
may
 
be
 
located
 
under
 
the
 
front
 
passenger
 sea
t, d
epending o
n v
ersion.
In the event of a breakdown

217
C4-cactus_en_Chap08_En-cas-de-panne_ed01-2016
Towing another vehicle
F On  the   rear   bumper,   press   the   bottom   of  t
he   cover   to   unclip   it.
F
 
S
crew   the   towing   eye   in   fully.
F
 
I
nstall   a   towing   arm.
F
 
S
witch   on   the   hazard   warning   lamps   on  
b

oth   vehicles.
F
 
M
ove   off   gently   and   drive   slowly   over   a  
s

hort   distance   only.
F
 O
n
 
the
 
front
 
bumper,
 
press
 
at
 
the
 
bottom
 
of
 t
he
 
cover
 
to
 
unclip
 
it.
F
 
S

crew
 
the
 
towing
 
eye
 
in
 
fully.
F
 
I

nstall
 
a
 
towing
 
arm.
F
 
P

ut
 
the
 
gear
 
lever
 
into
 
neutral
 
(control
 
N for
an
 
electronic
 
gearbox).
Towing the vehicle
Failure to follow this instruction could
lead   to   damage   to   certain   components  
(

brakes,   transmission, ...)   and   the  
a

bsence   of   braking   assistance   on  
r

estarting   the   engine. F
 
U
nlock   the   steering   by   turning   the   ignition  
k

ey   one   notch   and   release   the   parking  
b

rake.
F  
S
witch   on   the   hazard   warning   lamps   on  
b

oth   vehicles.
F  
M
ove   off   gently   and   drive   slowly   over   a  
s

hort   distance   only.
8
In the event of a breakdown

218
C4-cactus_en_Chap08_En-cas-de-panne_ed01-2016
Running out of fuel (Diesel)
On vehicles fitted with HDi engines, the fuel system   must   be   primed   if   you   run   out   of   fuel.
e-HDi 92 engine
F Fill  the   fuel   tank   with   at   least   five   litres   of  d
iesel.
F
 
O
pen   the   bonnet.
F
 
I
f   necessary,   unclip   the   styling   cover   for  
a

ccess   to   the   priming   pump.
F
 
S
queeze   and   release   the   priming   pump  
r

epeatedly until resistance is felt (there
may
  be   resistance   at   the   first   press).
F
 
O
perate   the   starter   until   the   engine   starts  
(

if   the   engine   does   not   start   at   the   first  
a

ttempt,   wait   around   15   seconds   before  
t

rying
 ag
ain).
F
 
I
f   the   engine   does   not   start   after   a   few  
a

ttempts,   operate   the   priming   pump   again  
t

hen   start   the   engine.
F
 
C
lip   the   styling   cover   back   in   place.
F
 
C
lose   the   bonnet.
If
 
the
 
engine
 
does
 
not
 
start
 
first
 
time,
 
d

on't
 
keep
 
trying
 
but
 
start
 
the
 
procedure
 
a

gain
 
from
 
the
 
beginning.
BlueHDi engine
F Fill
  the   fuel   tank   with   at   least   five   litres   of  D
iesel.
F
 
S
witch   on   the   ignition   (without   starting   the  
e

ngine).
F

W
ait around 6 seconds and switch off the
ignition.
F
 
R
epeat   the   operation   10   times.
F
 
O
perate   the   starter   to   run   the   engine.
In the event of a breakdown

219
C4-cactus_en_Chap09_caracteristiques-techniques_ed01-2016
EnginePureTech 75PureTech 82PureTech 82 S&S PureTech 110 S&S
Gearbox Manual
(5-speed) Manual
(5-speed) ETG electronic
(5-speed) Manual
(5-speed)
Model code 0PHMU0PHMZ0PHNZ
Cubic capacity (cc) 1
  1991
  1991
  199
Bore
  x   stroke   (mm) 75
  x   90.575
  x   90.575
  x   90.5
Max
  power:   EU   standard   (kW)* 55 60 81
Max
  power   engine   speed   (rpm) 5
  7505
  7505
  500
Max
  torque:   EU   standard   (Nm) 11 6 118205
Max
  torque   engine   speed   (rpm) 2
  7502
  7501
  500
Fuel UnleadedUnleadedUnleaded
Catalytic converter yesyesyes
Engine
  oil   capacity   with   replacement   of   the   oil  
f

ilter (in litres) 3.25
3.25 3.5
*
  
T
he   maximum   power   corresponds   to   the   type   approved   value   on   a   test   bed,   under   conditions   defined   by   European   legislation  
(directive
 1

999/99/EC).
Engines and gearboxes - PETROL
9
Technical data

220
C4-cactus_en_Chap09_caracteristiques-techniques_ed01-2016
EnginePureTech 75PureTech 82 PureTech 82 S&SPureTech 110 S&S
Gearbox Manual
(5-speed) Manual
(5-speed) ETG electronic
(5-speed) Manual
(5-speed)
Model code 0PHMU0PHMZ0PHNZ
Unladen
  weight 965965 9751 020
Kerb
  weight* 1 0401 040 1
  0501
  095
Gross
  vehicle   weight  
(GV W) 1
  5001
  5001
  5101
  555
Gross
  train   weight   (GTW)
on
  a   12   %   gradient 1
  9001
  9001
  9102
  155
Braked
  trailer**  
o

n   a   10   %   or   12   %   gradient 720
720 725825
Unbraked
 t

railer** 520520 525545
Recommended
  nose   weight   (towbar) 55555555
Weights and towed loads (in kg) - PETROL
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for e
ach   additional   1   000   metres   of   altitude.
Never
  exceed   60   mph   (100   km/h)   when   towing   (comply   with   the   legislation   in   force   in   your   country).
High
  ambient   temperatures   may   result   in   a   reduction   in   the   per formance   of   the   vehicle   to   protect   the   engine;   if   the   ambient   temperature   is   above   37   °C,  
l

imit   the   towed   load.
*
  The   kerb   weight   is   equal   to   the   unladen   weight   +   driver   (75   kg).
**
  Maximum   trailer   weight   within   the   GTW   limit.
Technical data

221
C4-cactus_en_Chap09_caracteristiques-techniques_ed01-2016
Enginee-HDi 92BlueHDi 100 BlueHDi 100 S&S
Gearbox ETG6 electronic
(6-speed) Manual
(5-speed) Manual
(5-speed) ETG6 electronic
(6-speed)
Model code 0B9HP0BBHY 0BBHY
Cubic capacity (cc) 1
  5601
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.375
  x   88.3
Max
  power:   EU   standard   (kW)* 6873 73
Max
  power   engine   speed   (rpm) 4 0003
  7503
  750
Max
  torque:   EU   standard   (Nm) 230254 254
Max
  torque   engine   speed   (rpm) 1
  7501
  7501
  750
Fuel DieselDiesel Diesel
Catalytic converter yesyes yes
Particle filter yesyes yes
Engine
  oil   capacity   with   replacement   of   the   oil  
f

ilter (in litres) 3.75
3.75 3.75
*
  
T
he   maximum   power   corresponds   to   the   value   type   approved   on   a   test   bed,   under   conditions   defined   by   European   legislation  
(Directive
 1

999/99/EC).
Engines and gearboxes - DIESEL
9
Technical data

222
C4-cactus_en_Chap09_caracteristiques-techniques_ed01-2016
Enginee-HDi 92BlueHDi 100 BlueHDi 100 S&S
Gearbox ETG6 electronic
(6-speed) Manual
(5-speed) Manual
(5-speed) ETG6 electronic
(6-speed)
Model code 0B9HP0BBHY 0BBHY
Unladen
  weight 1
  0551 068 1 0701
  085
Kerb
  weight* 1
  1301
  1431
  1451 160
Gross
  vehicle   weight   (GV W) 1
  6051 610 1 6101
  630
Gross
  train   weight   (GTW)  
o

n   a   12%   gradient 2
  2052 210 2 2102
  230
Braked
  trailer   (within   GTW   limit)
on
  a   10%   or   12%   gradient 825
825825825
Unbraked
 t

railer 565570570580
Recommended
  nose   weight   (towbar) 55555555
Weights and towed loads (in kg) - DIESEL
* The kerb weight is equal to the unladen weight + driver (75 kg).
T he   GTW   and   towed   load   values   indicated   are   valid   up   to   a   maximum   altitude   of   1   000   metres;   the   towed   load   mentioned   must   be   reduced   by   10   %   for  
e

ach   additional   1   000   metres   of   altitude.
Never   exceed   60   mph   (100   km/h)   when   towing   (comply   with   the   legislation   in   force   in   your   country).
High   ambient   temperatures   may   result   in   a   reduction   in   the   per formance   of   the   vehicle   to   protect   the   engine;   if   the   ambient   temperature   is   above   37   °C,  
l

imit   the   towed   load.
Technical data