2017 TOYOTA AURIS Owners Manual (in English)

5778-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
8
When trouble arises
Remove the deck mat. (P. 433)
Take out the emergency tire puncture repair kit. (P. 575)
Take out the repair kit.
When taking out the bottle from the original bag, do not tear or discard the
bag.
Attach the 2 stickers as shown.
Remove any dirt and moisture from
the wheel before attaching the
label. If it is impossible to attach
the label, make sure to tell any
authorized Toyota dealer or
repairer, or other duly qualified and
equipped professional when you
have them repair and replace the
tire that sealant is injected.
Remove the valve cap from the
valve of the punctured tire.
Taking out the emergency tire puncture repair kit
Emergency repair method
1
2
1
2
3
UK AURIS_HB_OM_Europe_OM12K97E.book 577 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5788-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
Remove the cap from the noz-
zle.
Connect the nozzle to the
valve.
Screw the end of the nozzle clock-
wise as far as possible.
The bottle should hang vertically
without contacting the ground. If
the bottle does not hang vertically,
move the vehicle so that the tire
valve is located properly.
Remove the cap from the bot-
tle.
Pull the hose out from the com-
pressor.
4
5
6
7
UK AURIS_HB_OM_Europe_OM12K97E.book 578 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5798-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
8
When trouble arises
Connect the bottle to the com-
pressor.
Screw the end of the nozzle clock-
wise as far as possible.
Make sure that the compressor
switch is off.
Remove the power plug from
the compressor.
Connect the power plug to the
power outlet socket. (P. 439)
8
9
10
11
UK AURIS_HB_OM_Europe_OM12K97E.book 579 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5808-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
Check the specified tire inflation pressure.
Tire inflation pressure is specified on the label as shown. (P. 625)
Start the vehicle’s engine.
To inject the sealant and inflate
the tire, turn the compressor
switch on.
12
Left-hand drive vehiclesRight-hand drive vehicles
13
14
UK AURIS_HB_OM_Europe_OM12K97E.book 580 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5818-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
8
When trouble arises
Inflate the tire until the specified
air pressure is reached.
The sealant will be injected
and the pressure will surge
and then gradually decrease.
The air pressure gauge will
display the actual tire infla-
tion pressure about 1 minute
(5 minutes at low tempera-
ture) after the switch is
turned on.
Inflate the tire until the speci-
fied air pressure.
• If the tire inflation pressure is
still lower than the specified
point after inflation for 35 min-
utes with the switch on, the tire
is too damaged to be repaired.
Turn the compressor switch off
and contact any authorized
Toyota dealer or repairer, or
another duly qualified and
equipped professional.
• If the tire inflation pressure exceeds the specified air pressure, let out
some air to adjust the tire inflation pressure. (P. 584, 625)
15
1
2
3
UK AURIS_HB_OM_Europe_OM12K97E.book 581 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5828-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
Turn the compressor off.
Disconnect the nozzle from the valve on the tire and then pull out
the power plug from the power outlet socket.
Some sealant may leak when the hose is removed.
Press the button to release
pressure from the bottle.
Attach the cap to the nozzle.
Install the valve cap onto the valve of the repaired tire.
Disconnect the hose from the
bottle and attach the cap to the
bottle.
Place the bottle in the original bag
and zip it.
16
17
18
19
20
21
UK AURIS_HB_OM_Europe_OM12K97E.book 582 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5838-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
8
When trouble arises
Temporarily store the bottle and compressor in the luggage com-
partment.
To spread the liquid sealant evenly within the tire, immediately drive
safely for about 5 km (3 miles) below 80 km/h (50 mph).
After driving for about 5 km (3
miles), stop your vehicle in a
safe place on a hard, flat sur-
face and connect the compres-
sor.
Check the tire inflation pres-
sure.
If the tire inflation pressure is
under 130 kPa (1.3 kgf/cm
2
or bar, 19 psi): The puncture
cannot be repaired. Contact
any authorized Toyota dealer
or repairer, or another duly
qualified and equipped pro-
fessional.
If the tire inflation pressure is 130 kPa (1.3 kgf/cm
2 or bar, 19 psi)
or higher, but less than the specified air pressure: Proceed to .
If the tire inflation pressure is the specified air pressure (P.
625): Proceed to .
Turn the compressor switch on to inflate the tire until the specified
air pressure is reached. Drive for about 5 km (3 miles) and then
perform .
Store the compressor in the luggage compartment.
Taking precautions to avoid sudden braking, sudden acceleration
and sharp turns, drive carefully at under 80 km/h (50 mph) to the
nearest authorized Toyota dealer or repairer, or another duly quali-
fied and equipped professional for tire repair or replacement.
22
23
24
25
1
2
26
3
27
26
24
27
28
UK AURIS_HB_OM_Europe_OM12K97E.book 583 ページ ２０１６年６月２７日　月曜日　午後５時４２分

5848-2. Steps to take in an emergency
UK AURIS_HB_EE (OM12K97E)
■If the tire is inflated to more than the specified air pressure
Check that the air pressure indicator shows the specified air pressure.
If the air pressure is under the designated pressure, turn the compressor
switch on again and repeat the inflation procedure until the specified air
pressure is reached.
■After a tire is repaired with the emergency tire puncture repair kit
●The tire pressure warning valve and transmitter should be replaced.
●Even if the tire inflation pressure is at the recommended level, the tire pres-
sure warning light may come on/flash. Press the button to let some air out.
1
2
UK AURIS_HB_OM_Europe_OM12K97E.book 584 ページ ２０１６年６月２７日　月曜日　午後５時４２分