2015 TATA SAFARI Owners Manual

89
D R I V I N GDRIVING SAFET DRIVING SAFETDRIVING SAFET DRIVING SAFET
DRIVING SAFET
Y YY Y
Y
control of the vehicle and increase
the risk of injury yourself and
others.
mobile phones mobile phonesmobile phones mobile phones
mobile phones
Avoid using mobile phones while
driving a car. This could divert your
attention from the road and result
in an accident.
F FF F
F
a aa a
a
tigue 'R tigue 'Rtigue 'R tigue 'R
tigue 'R
est R est Rest R est R
est R
e ee e
e
viv vivviv viv
viv
e sur e sure sur e sur
e sur
viv vivviv viv
viv
e' e'e' e'
e'
Do not attempt driving when you
feel tired, sleepy long distance
driving can tire you very much and
fatigue can dull your reflexes and
judgment. Take a brake and get
refreshed at intervals.SAFETY CHECKS SAFETY CHECKSSAFETY CHECKS SAFETY CHECKS
SAFETY CHECKS
Windshield/wiper/windshield Windshield/wiper/windshieldWindshield/wiper/windshield Windshield/wiper/windshield
Windshield/wiper/windshield
washer washerwasher washer
washer
Always keep windshield glass
clean to avoid any distraction in
visibility. Ensure proper working of
wipers and condition of wiper
blade. Ensure that windshield
washer reservoir is full. Do not
operate wiper alone when the
windshield glass is dry this would
damage the windshield.
Headlights HeadlightsHeadlights Headlights
Headlights
Keep headlight lenses clean. Check
for operation of headlamps in both
high/low beam condition. Check for
correct focusing of headlamps. Use
only recommended type of bulbs.
Do not use the high beam unless it
is inevitable. Its dazzle may glare
the driver of the oncoming car the
condition thus causing an accident.
DRIVING SAFETY DRIVING SAFETYDRIVING SAFETY DRIVING SAFETY
DRIVING SAFETY
Seat Belt Seat BeltSeat Belt Seat Belt
Seat Belt
Seat-belts are life saving
equipment, use of seat-belt
reduces the chance of injury and
severity of injury in case of an
accident. It is strongly
recommended that all the car
occupants should always wear
seat-belt, while car is in motion.
W WW W
W
ARNING ARNINGARNING ARNING
ARNING
If the vehicle is fitted with air bags,
the air bag is a supplementary
restraint system and can only
provide intended protection when
the seat-belts are worn. For
maximum safety in any collision a
seat-belt must be worn.
Influence of Alcohol Influence of AlcoholInfluence of Alcohol Influence of Alcohol
Influence of Alcohol
Avoid driving under the influences
of alcohol or drugs. Alcohol and
drugs will severely impair your
ProCarManuals.com

90
D R I V I N GDRIVING SAFET DRIVING SAFETDRIVING SAFET DRIVING SAFET
DRIVING SAFET
Y YY Y
Y
Side indicators / Hazard warning Side indicators / Hazard warningSide indicators / Hazard warning Side indicators / Hazard warning
Side indicators / Hazard warning
Ensure that all side indicators/
hazard warning lights are always in
working condition and they are used
when required.
Horn HornHorn Horn
Horn
Ensure the horn is working properly.
Horn provides safety to other road
users by alerting your presence.
Brakes BrakesBrakes Brakes
Brakes
Ensure brakes are working properly.
Check brake fluid level in reservoir.
Don not drive the car when brake
warning lamp is 'ON'.
T TT T
T
yr yryr yr
yr
es eses es
es
Check the condition of tyres for any
abnormalities. Maintain correct
tyre pressure, it is very importantparticularly when subjected to
extreme condition, such as high
speed, high load and high outside
temperature. Do not use worn or
bald tyres on the front wheels.
First Aid Kit First Aid KitFirst Aid Kit First Aid Kit
First Aid Kit
First aid kit is provided in your
vehicle. This is for use in case of
minor injuries. It is to be regularly
checked for any disintegration and
should be updated regularly.
A AA A
A
d dd d
d
v vv v
v
anc ancanc anc
anc
e e e e
e
W WW W
W
ar arar ar
ar
ning ning ning ning
ning
T TT T
T
r rr r
r
iangle iangleiangle iangle
iangle
There is an advanced warning
triangle provided along with your
vehicle. In case there is a
breakdown and the vehicle is
parked at the side of the road, then
the triangle is to be kept as per
instructions given below :Remove advance warning triangle
from case and assemble.
Place the triangle on the road
behind the vehicle when it
stranded on the road. The triangle
must be at least 5 meters behind
the vehicle in the same lane of
traffic.
Increase the distance to 150
meters on a highway or if a bad/hill
top obscures the view.
ProCarManuals.com

91
FUEL, LUBRICANTS & COOLANTS
• •• •
•Fuel FuelFuel Fuel
Fuel
• •• •
•Lubricants LubricantsLubricants Lubricants
Lubricants
• •• •
•Coolants CoolantsCoolants Coolants
Coolants
• •• •
•Recommended oils & lubricants Recommended oils & lubricantsRecommended oils & lubricants Recommended oils & lubricants
Recommended oils & lubricants
This section give information regarding recommendations of fuel &
oils to be used on TATA Safari Vehicles. Use only these fuel & oils on
your vehicle to avoid damage to vital systems & components.
ProCarManuals.com

92
FUEL, LUBRICANTS & COOLANTSFUEL FUELFUEL FUEL
FUEL
Fuel FuelFuel Fuel
Fuel
High speed diesel conforming to IS 1460 or EN 590 or equivalent
is recommended to be used as fuel.
At very low temperatures fluidity of diesel may become
insufficient due to paraffin separation. It is therefore, necessary
to mix supplementary fuel with summer or winter grade diesel.
The supplementary fuel to be used is kerosene or aviation
turbine fuel.
Ratios for mixing of supplementary fuel and diesel are shown
in table:
A AA A
A
mbien mbienmbien mbien
mbien
t tt t
t
P PP P
P
er erer er
er
c cc c
c
en enen en
en
tage tagetage tage
tage
temperature upto temperature uptotemperature upto temperature upto
temperature upto
Summer SummerSummer Summer
Summer
Suppl. Suppl.Suppl. Suppl.
Suppl.
Deg C. Deg C.Deg C. Deg C.
Deg C.
Grade diesel Grade dieselGrade diesel Grade diesel
Grade diesel
fuel fuelfuel fuel
fuel
upto 0 100 0
0 to -10 70 30
-10 to -15 50 50Ambient AmbientAmbient Ambient
Ambient
Percentage PercentagePercentage Percentage
Percentage
temperature upto temperature uptotemperature upto temperature upto
temperature upto
Winter WinterWinter Winter
Winter
Suppl. Suppl.Suppl. Suppl.
Suppl.
Deg C. Deg C.Deg C. Deg C.
Deg C.
Grade diesel Grade dieselGrade diesel Grade diesel
Grade diesel
fuel fuelfuel fuel
fuel
upto -15 100 0
-15 to -20 70 30
-20 and below 50 50
Care should be taken that diesel and supplementary fuel are
thoroughly mixed before filling.
Recommended Fuel Specification for engines to be added.
Parameter ParameterParameter Parameter
Parameter
Unit UnitUnit Unit
Unit
BS III BS III BS III BS III
BS III
1 Cetane Number (min) CN 51
2 Sulphur contentmg/kg 350
3 Lubricity (HFRR) micon 460
ProCarManuals.com

93
FUEL, LUBRICANTS & COOLANTS
Lubricants and Oils Lubricants and OilsLubricants and Oils Lubricants and Oils
Lubricants and Oils
Recommended lubricants conform to the following
specifications :
1. 1.1. 1.
1.
Engine oil Engine oilEngine oil Engine oil
Engine oil -API-CH4 + MB 228.3 or higher
grade engine oil
2. 2.2. 2.
2.
Gear Box oil Gear Box oilGear Box oil Gear Box oil
Gear Box oil - 75W90 GL-4
3. 3.3. 3.
3.
Power Steering Power SteeringPower Steering Power Steering
Power Steering - ATF Type A, Suffix A
and and and and
and
T TT T
T
r rr r
r
ansf ansfansf ansf
ansf
er C er Cer C er C
er C
ase asease ase
ase
4. 4.4. 4.
4.
Rear & Front axle Rear & Front axleRear & Front axle Rear & Front axle
Rear & Front axle -M/Grade oil SAE 85W 140 GL5
Angolmol AG043 oil
* * * *
* Friction modifier 40819 (2-5%) to be added to oil for
Limited Slip Differential
5. 5.5. 5.
5.
Chassis and wheel Chassis and wheelChassis and wheel Chassis and wheel
Chassis and wheel -SS6805 bearing grease
bearing
bearingbearing bearing
bearing
Please use only recommended grades for good Please use only recommended grades for goodPlease use only recommended grades for good Please use only recommended grades for good
Please use only recommended grades for good
performance. performance.performance. performance.
performance.
DO NOT DO NOT DO NOT DO NOT
DO NOT mix grease of different brands and optional grades.
Replace old grease completely.
The oil change periods recommended in maintenance
schedule should be adhered to.
L LL L
L
UBRIC UBRICUBRIC UBRIC
UBRIC
ANT ANTANT ANT
ANT
S SS S
S
Engine EngineEngine Engine
Engine
Qty : 7.5 Litres Qty : 7.5 Litres Qty : 7.5 Litres Qty : 7.5 Litres
Qty : 7.5 Litres
Recommended grades of engine oil for range of ambient
temperature :
A AA A
A
mbien mbienmbien mbien
mbien
t t t t
t
T TT T
T
emp empemp emp
emp
er erer er
er
a aa a
a
tur turtur tur
tur
e e e e
e
0 00 0
0C CC C
C
Engine Oil Grade Engine Oil GradeEngine Oil Grade Engine Oil Grade
Engine Oil Grade
- 5 and above SAE 15W/40
- 10 to 0 SAE 5W30
- 20 and -10 SAE 0W30
Front live axle and rear axle oil (Spicer axles) Front live axle and rear axle oil (Spicer axles)Front live axle and rear axle oil (Spicer axles) Front live axle and rear axle oil (Spicer axles)
Front live axle and rear axle oil (Spicer axles)
Use Multigrade oil SAE 85W 140 Angolmol A6043 oil
Capacity : Capacity :Capacity : Capacity :
Capacity :
For Rear axle For Rear axleFor Rear axle For Rear axle
For Rear axle
- 2.2 litres - 2.2 litres- 2.2 litres - 2.2 litres
- 2.2 litres
For Front axle For Front axleFor Front axle For Front axle
For Front axle
- 1.2 litres - 1.2 litres- 1.2 litres - 1.2 litres
- 1.2 litres
Gear Box oil : Gear Box oil :Gear Box oil : Gear Box oil :
Gear Box oil :
Qty : 1.6 Litres Qty : 1.6 LitresQty : 1.6 Litres Qty : 1.6 Litres
Qty : 1.6 Litres
75W90, (Synthetic oil GL4)
ProCarManuals.com

94
T TT T
T
r rr r
r
ansf ansfansf ansf
ansf
er c er cer c er c
er c
ase oil : ase oil :ase oil : ase oil :
ase oil :
Qty : 1.2 Litres Qty : 1.2 LitresQty : 1.2 Litres Qty : 1.2 Litres
Qty : 1.2 Litres
Recommended lubricants should confirm to General
Motors, ATF A specification
Hub bearing grease Hub bearing greaseHub bearing grease Hub bearing grease
Hub bearing grease
Use lithium base multipurpose grease -
Quantity : Quantity :Quantity : Quantity :
Quantity :
92 gms p 92 gms p92 gms p 92 gms p
92 gms p
er hub er huber hub er hub
er hub
.. ..
.
(F (F (F (F
(F
r rr r
r
on onon on
on
t axles 4X4) t axles 4X4)t axles 4X4) t axles 4X4)
t axles 4X4)
47 gms p 47 gms p47 gms p 47 gms p
47 gms p
er hub er huber hub er hub
er hub
.. ..
.
(F (F (F (F
(F
r rr r
r
on on
on on
on
t axles 4X2) t axles 4X2)t axles 4X2) t axles 4X2)
t axles 4X2)
25 gms p 25 gms p25 gms p 25 gms p
25 gms p
er hub er huber hub er hub
er hub
.. ..
.
(R (R (R (R
(R
ear) ear)ear) ear)
ear)
Brake and Clutch Fluid Brake and Clutch FluidBrake and Clutch Fluid Brake and Clutch Fluid
Brake and Clutch Fluid
Brake fluid confirming to SAE J 1703, DOT 3 is recommended.
Spicer propeller shaft Spicer propeller shaftSpicer propeller shaft Spicer propeller shaft
Spicer propeller shaft
Lubricant slip joint with NLGI-2 grade grease.
FUEL, LUBRICANTS & COOLANTSLUBRICANTS & COOLANTS LUBRICANTS & COOLANTSLUBRICANTS & COOLANTS LUBRICANTS & COOLANTS
LUBRICANTS & COOLANTS
Coolants CoolantsCoolants Coolants
Coolants
Qty : Approx. 9-10 Litres Qty : Approx. 9-10 LitresQty : Approx. 9-10 Litres Qty : Approx. 9-10 Litres
Qty : Approx. 9-10 Litres
Presence of dirt in coolant chokes up passages in radiator,
cylinder head and crankcase, thereby causing overheating of
engine.
To prevent rust formation and freezing of coolant inside the
passages of radiator, crankcase and cylinder head use premixed
coolant as recommended.
It is recommended that the entire cooling system should
be drained and filled with fresh premixed coolant.
Engine coolant antifreeze coolant as per class II, JIS K2234
Windscreen Washer Antifrost
Make -Antifrost- K
Concentration - 1 : 5 For 0
0C
1 : 1 For 100C
2 : 5 For 160C
1 : 0 For 370C
ProCarManuals.com

95
FUEL, LUBRICANTS & COOLANTSBRANDED LUBRICANTS, COOLANTS & ADHESIVES BRANDED LUBRICANTS, COOLANTS & ADHESIVESBRANDED LUBRICANTS, COOLANTS & ADHESIVES BRANDED LUBRICANTS, COOLANTS & ADHESIVES
BRANDED LUBRICANTS, COOLANTS & ADHESIVES
PLEASE USE ONL PLEASE USE ONLPLEASE USE ONL PLEASE USE ONL
PLEASE USE ONL
Y FOLL Y FOLLY FOLL Y FOLL
Y FOLL
O OO O
O
WING GENUINE OILS, WING GENUINE OILS,WING GENUINE OILS, WING GENUINE OILS,
WING GENUINE OILS,


C CC C
C
OOL OOLOOL OOL
OOL
ANT ANTANT ANT
ANT
S , S ,S , S ,
S ,
L L L L
L
UBRIC UBRICUBRIC UBRIC
UBRIC
ANT ANTANT ANT
ANT
S , S ,S , S ,
S ,
ANTI R ANTI R ANTI R ANTI R
ANTI R
UST & SOUND DEADENING UST & SOUND DEADENINGUST & SOUND DEADENING UST & SOUND DEADENING
UST & SOUND DEADENING
C CC C
C
O OO O
O
A AA A
A
T TT T
T
S, S,S, S,
S,


WINDSCREEN SEAL WINDSCREEN SEALWINDSCREEN SEAL WINDSCREEN SEAL
WINDSCREEN SEAL
ANT ANTANT ANT
ANT
,, ,,
,
ADHESIVES & FUEL ADDITIVES BR ADHESIVES & FUEL ADDITIVES BR ADHESIVES & FUEL ADDITIVES BR ADHESIVES & FUEL ADDITIVES BR
ADHESIVES & FUEL ADDITIVES BR
ANDED BY ANDED BY ANDED BY ANDED BY
ANDED BY
T TT T
T
A AA A
A
T TT T
T
A MO A MOA MO A MO
A MO
T TT T
T
ORS F ORS FORS F ORS F
ORS F
OR OPTIMUM OR OPTIMUMOR OPTIMUM OR OPTIMUM
OR OPTIMUM
PERFORMANCE OF PERFORMANCE OF PERFORMANCE OF PERFORMANCE OF
PERFORMANCE OF
Y YY Y
Y
OUR OUR OUR OUR
OUR
T TT T
T
A AA A
A
T TT T
T
A Saf A SafA Saf A Saf
A Saf
ari DICOR ari DICORari DICOR ari DICOR
ari DICOR
... ......
...
...
ITEM COMPANY BRAND QTY
ENGINE OIL ENGINE OILENGINE OIL ENGINE OIL
ENGINE OIL
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol GTX (Diesel) Castrol GTX (Diesel)Castrol GTX (Diesel) Castrol GTX (Diesel)
Castrol GTX (Diesel)
HPCL HPCLHPCL HPCL
HPCL
HP MIL HP MILHP MIL HP MIL
HP MIL
CY CY CY CY
CY
TURBO PL TURBO PLTURBO PL TURBO PL
TURBO PL
US USUS US
US
7.5 Litres 7.5 Litres7.5 Litres 7.5 Litres
7.5 Litres
COOLANT COOLANTCOOLANT COOLANT
COOLANT
SUNST SUNSTSUNST SUNST
SUNST
AR ARAR AR
AR
Golden Cruiser Premium 1400 M Golden Cruiser Premium 1400 MGolden Cruiser Premium 1400 M Golden Cruiser Premium 1400 M
Golden Cruiser Premium 1400 M
HPCL HPCLHPCL HPCL
HPCL
HP HP HP HP
HP
T TT T
T
handa R handa Rhanda R handa R
handa R
aja P aja Paja P aja P
aja P
Approx 13 Litres Approx 13 LitresApprox 13 Litres Approx 13 Litres
Approx 13 Litres
CASTROL CASTROLCASTROL CASTROL
CASTROL
Radicool
RadicoolRadicool Radicool
Radicool
GEAR BOX (G-76) GEAR BOX (G-76)GEAR BOX (G-76) GEAR BOX (G-76)
GEAR BOX (G-76)
HPCL HPCLHPCL HPCL
HPCL
HP Gear Oil XP 75W90 HP Gear Oil XP 75W90HP Gear Oil XP 75W90 HP Gear Oil XP 75W90
HP Gear Oil XP 75W90
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol Syntro 75W90 GL4 Castrol Syntro 75W90 GL4Castrol Syntro 75W90 GL4 Castrol Syntro 75W90 GL4
Castrol Syntro 75W90 GL4
1.6 Litres 1.6 Litres1.6 Litres 1.6 Litres
1.6 Litres
TRANSFERCASE TRANSFERCASETRANSFERCASE TRANSFERCASE
TRANSFERCASE
HPCL HPCLHPCL HPCL
HPCL
HP-A HP-AHP-A HP-A
HP-A
ut utut ut
ut
oma omaoma oma
oma
tic tic tic tic
tic
T TT T
T
r rr r
r
ansmission F ansmission Fansmission F ansmission F
ansmission F
luid luid luid luid
luid
T TT T
T
yp ypyp yp
yp
e A e Ae A e A
e A
1.2 Litres 1.2 Litres
1.2 Litres 1.2 Litres
1.2 Litres
CASTROL CASTROLCASTROL CASTROL
CASTROL
C CC C
C
astr astrastr astr
astr
ol ol ol ol
ol
T TT T
T
r rr r
r
ansp anspansp ansp
ansp
o oo o
o
w ww w
w
er er er er
er
T TT T
T
Q QQ Q
Q
POWER STEERING OIL POWER STEERING OILPOWER STEERING OIL POWER STEERING OIL
POWER STEERING OIL
HPCL HPCLHPCL HPCL
HPCL
HP-A HP-AHP-A HP-A
HP-A
TF D TF DTF D TF D
TF D
e ee e
e
x II x IIx II x II
x II
1.4 Litres 1.4 Litres1.4 Litres 1.4 Litres
1.4 Litres
CASTROL CASTROLCASTROL
CASTROL
CASTROL
C CC C
C
astr astrastr astr
astr
ol ol ol ol
ol
T TT T
T
QD QDQD QD
QD
REAR AXLE, LIVE FRONT AXLE, REAR AXLE, LIVE FRONT AXLE,REAR AXLE, LIVE FRONT AXLE, REAR AXLE, LIVE FRONT AXLE,
REAR AXLE, LIVE FRONT AXLE,
HPCL HPCLHPCL HPCL
HPCL
HP AXLE OIL 85W140 HP AXLE OIL 85W140HP AXLE OIL 85W140 HP AXLE OIL 85W140
HP AXLE OIL 85W140
2.2 2.2 2.2 2.2
2.2
(Rear) (Rear)(Rear) (Rear)
(Rear) 1.2 1.2 1.2 1.2
1.2(Front (Front(Front (Front
(Front) )) )
)
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol Long Drain 85W140 Castrol Long Drain 85W140Castrol Long Drain 85W140 Castrol Long Drain 85W140
Castrol Long Drain 85W140
BR BRBR BR
BR
AKE / CL AKE / CLAKE / CL AKE / CL
AKE / CL
UT UTUT UT
UT
CH FL CH FLCH FL CH FL
CH FL
UID UIDUID UID
UID
HP CL HP CLHP CL HP CL
HP CL
Super Duty Brake Fluid DOT - 3 Super Duty Brake Fluid DOT - 3Super Duty Brake Fluid DOT - 3 Super Duty Brake Fluid DOT - 3
Super Duty Brake Fluid DOT - 3
As required As requiredAs required As required
As required
CASTROL CASTROLCASTROL CASTROL
CASTROL
Universal Brake Fluid DOT 3 Universal Brake Fluid DOT 3Universal Brake Fluid DOT 3 Universal Brake Fluid DOT 3
Universal Brake Fluid DOT 3
WHEEL BEARING & CHASSIS WHEEL BEARING & CHASSISWHEEL BEARING & CHASSIS WHEEL BEARING & CHASSIS
WHEEL BEARING & CHASSIS
HPCL HPCLHPCL HPCL
HPCL
HP Multipurpose Grease-2 HP Multipurpose Grease-2HP Multipurpose Grease-2 HP Multipurpose Grease-2
HP Multipurpose Grease-2
As required As requiredAs required As required
As required
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol AP2 Castrol AP2Castrol AP2 Castrol AP2
Castrol AP2
ANTI R ANTI R ANTI R ANTI R
ANTI R
UST
UST UST UST
UST
TREA TREATREA TREA
TREA
T TT T
T
MENT MENTMENT MENT
MENT
DINITROL DINITROLDINITROL DINITROL
DINITROL
Dinitrol DinitrolDinitrol Dinitrol
Dinitrol
— —— —
—
& SOUND DEADENING & SOUND DEADENING & SOUND DEADENING & SOUND DEADENING
& SOUND DEADENING
WUERTH WUERTHWUERTH WUERTH
WUERTH
Wuerth WuerthWuerth Wuerth
Wuerth
3M 3M3M 3M
3M
3M 3M3M 3M
3M
— —— —
—


WIND SCREEN SEAL WIND SCREEN SEALWIND SCREEN SEAL WIND SCREEN SEAL
WIND SCREEN SEAL
ANT ANTANT ANT
ANT
WUERTH WUERTHWUERTH WUERTH
WUERTH
Wuerth WuerthWuerth Wuerth
Wuerth
— —— —
—
3M 3M3M 3M
3M
3M 3M3M 3M
3M
— —— —
—
Car System Car SystemCar System Car System
Car System
Car System Car SystemCar System Car System
Car System— —— —
—
ProCarManuals.com

96
ProCarManuals.com