2014 MITSUBISHI OUTLANDER SPORT auxiliary battery

11
MaintenanceService precautions ......................................................................... 11-2Catalytic converter .......................................................................... 11-3Bonnet ............................................................................................. 11-3Engine oil ........................................................................................ 11-5Engine coolant/Plug-in hybrid EV system coolant ......................... 11-6Wa s h e r f l u i d . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 7Brake fluid ...................................................................................... 11-7Auxiliary battery ............................................................................. 11-8Ty r e s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 9Wiper blade rubber replacement ................................................... 11-12General maintenance .................................................................... 11-14Fusible links .................................................................................. 11-15Fuses ............................................................................................. 11-15Replacement of lamp bulbs .......................................................... 11-21
BK0203201EN.book 1 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Catalytic converterMaintenance 11-3
11
E01000202437
The exhaust gas scavenging devices usedwith catalytic converter are extremely effi-cient for the reduction of noxious gases. Thecatalytic converter is installed in the exhaustsystem.It is important to keep the engine properlytuned to ensure proper catalyst operation andprevent possible catalyst damage.
E01000303868
1. Pull the release lever towards you tounlock the bonnet.
zMake sure that the engine and Plug-inHybrid EV system has cooled down beforeremoving the radiator cap and EV coolingsystem reserve tank cap, because hotsteam or boiling water otherwise will gushfrom the filler port and may scald you.zDo not smoke, cause sparks or allow openflames around fuel or auxiliary battery.The fumes are flammable.zBe extremely cautious when workingaround the auxiliary battery. It containspoisonous and corrosive sulphuric acid.zDo not get under your vehicle with just thebody jack supporting it. Always use auto-motive jack stands.zImproper handling of
components and
materials used in the vehicle can endangeryour personal safety. We recommend youto consult a specialist for necessary infor-mation.zThe components inside the engine roommight be very hot to the touch.To a v o i d b e i n g b u r n t , m a k e s u r e a l l c o m -ponents have sufficiently cooled beforebeginning an inspection. These compo-nents are affixed with the label indicatingprecautions for handling. Follow theinstructions on the label.WA R N I N G
1- Brake fluid reservoir (RHD)2- Engine oil level gauge3- Engine oil cap4- Brake fluid reservoir (LHD)5- Washer fluid reservoir6- EV cooling system reservoir7- Engine coolant reservoirCatalytic converter
WA R N I N GzAs with any vehicle, do not park or oper-ate this vehicle in areas where combustiblematerials such as dry grass or leaves cancome in contact with a hot exhaust since afire could occur.zPaint should not be applied to the catalyticconverter.NOTE
zUse fuel of the type recommended in “Fuelselection” on page 2.
Bonnet To o p e n
BK0203201EN.book 3 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Auxiliary battery11-8 Maintenance
11
The fluid level is monitored by a float. Whenthe fluid level falls below the “MIN” mark,the brake fluid warning lamp lights up.The fluid level falls slightly with wear of thebrake pads, but this does not indicate anyabnormality.The fluid in the master cylinder should bechecked when doing other work under the
bonnet. The brake system should also bechecked for leaks at the same time.If the fluid level falls markedly in a shortlength of time, it indicates leaks from thebrake system.If this occurs, we recommend you to have thevehicle checked.Use brake fluid conforming to DOT3 orDOT4 from a sealed container. The brakefluid is hygroscopic. Too much moisture inthe brake fluid will adversely affect the brakesystem, reducing the performance.
E01001203284
The condition of the auxiliary battery is veryimportant for quick starting of the plug-inhybrid EV system and proper functioning ofthe vehicle’s electrical system. Regularinspection is especially important in coldweather. Be sure to have a MITSUBISHIMOTORS Authorized Service Point checkthe auxiliary battery.
LHDRHD
Fluid type
CAUTIONzTa k e c a r e i n h a n d l i n g b r a k e f l u i d a s i t i sharmful to the eyes,
may irritate your skin
and also damage to painted surfaces.zUse only the specified brake fluid.Do not mix or add different brand of brakefluid to prevent chemical reaction.Do not let any petrol
eum-based fluid touch,
mix with, or get into the brake fluid.This will damage the seals.zKeep the reservoir tank cap closed to preventthe brake fluid from deteriorating exceptmaintenance.zClean the filler cap before removing andclose the cap securely after maintenance.
Auxiliary battery
WA R N I N GzBe sure to have a MITSUBISHI MOTORSAuthorized Service Point charge the bat-tery. Do not charge the battery yourself.Flammable gases may leak and explode.CAUTIONzThere is a type of auxiliary battery is notproperly installed in the vehicle, even if thesame specification.When replacing the auxiliary battery, pleasecontact a MITSUBISHI MOTORS Author-ized Service Point.
BK0203201EN.book 8 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Tyres
Maintenance 11-9
11
E01001300255
NOTE
zWhen the auxiliary battery is removed, thecontrolling timer for forcibly starting theengine may be reset. Since a fuel injection device may cause aclogging if the state where the engine doesnot operate continues after reset of the timer,please press the battery charge switch inorder to start the engi
ne. However, when the
drive battery is near full charge, even if thebattery charge switch is
pressed, the engine
may not start. In that case, press the batterycharge switch again after the drive batteryquantity decreases. Refer to “Battery chargeswitch” on page 7-23.zWhen the auxiliary batte
ry is removed, since
the timer control of the MITSUBISHIRemote Control is reset and the drive batterytemperature control can not be used, commu-nicate the wireless LAN device and yourvehicle again.zWhen the auxiliary battery is removed, thetimer control of the MITSUBISHI RemoteControl is reset and each function of theMITSUBISHI Remote Control can not beused. Also the drive battery can not bewarmed up.Communicate the wireless LAN device andyour vehicle again.
Ty r e s
WA R N I N GzDriving with tyres that are worn, damagedor improperly inflated can lead to a loss ofcontrol or blow out of the tyres which canresult in a collision with serious or fatalinjury.
BK0203201EN.book 9 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Electric motor specifications12-8 Specifications
12
E01100603947E01100803747E01100904211
Normal charging system
IP degrees
IP44: When a charge connector is connected
IP55: When charging lid is closed and vehicle is moving
Electric motor specifications
Item
Front Motor
Rear Motor
Electric motor model
S61
Y61
Maximum output (ECE net)
60 kW
Maximum torque
137 N•m
195 N•m
Maximum 30 minutes power
25 kW
Low voltage electrical system Vo l t a g e
12 V
Auxiliary battery
Ty p e ( J I S )
S46B24L(S)
Capacity (5HR)
36 Ah
Spark plug type
NGK
DIFR5C11
Ty r e s a n d w h e e l s Ty r e
215/70R16 100H
225/55R18 98H
Wheel
Size
16x6 1/2JJ
18x7J
Offset
38 mm
BK0203201EN.book 8 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Alphabetical index
13-1
13
Numerics
4-wheel drive operation
.......................
7-20
A
Accessory (Installation)
.......................
2-14
Accessory socket
................................
8-66
Active stability control (ASC)
..............
7-32
Adaptive Cruise Control System (ACC) 7-43Air conditioner
Automatic climate control air conditioner
.
8-4Important operation tips for the air condi-tioner
...........................................
8-11
Air purifier
.........................................
8-12
Airbag
...............................................
5-21
AM/FM radio
.....................................
8-12
Antenna
.............................................
8-40
Anti-lock brake system (ABS)
.............
7-29
Ashtray
..............................................
8-65
Assist grips
........................................
8-72
Audio
AM/FM radio
.................................
8-12
CD player
......................................
8-12
To listen to a disc in the rear-seat display
.
8-34Troubleshooting
.............................
8-38
Automatic transmission
Fluid
............................................
12-10
Auxiliary battery
................................
11-8
Auxiliary battery charge warning lamp
.6-39
B
Battery
Auxiliary battery charge warning lamp
.....
6-39Discharged battery (Emergency starting)
..
9-2Specification
..................................
12-8
Battery charge switch
..........................
7-23
Battery save switch
.............................
7-22
Bluetooth® 2.0 interface
.....................
8-41
Bonnet
..............................................
11-3
Bottle holders
.....................................
8-71
Brake
Anti-lock brake
..............................
7-29
Braking
.........................................
7-26
Fluid
...................................
11-7
, 12-10
Parking brake
...................................
7-4
Brake assist system
.............................
7-28
Brake warning lamp
............................
6-37
Bulb capacity
....................................
11-22
C
Capacities
.........................................
12-10
Card holder
...............................
8-65
, 8-69
Cargo area cover
.................................
8-71
Cargo loads
........................................
7-70
Catalytic converter
..............................
11-3
Cautions on the handling of 4-wheel drive vehicles
............................................
7-22
CD player
...........................................
8-12
Central door locks
...............................
4-15
Charging indicator
..............................
6-37
Check engine warning lamp
.................
6-38
Child restraint
.....................................
5-15
Child restraint anchorage points
...........
5-16
Child-protection rear doors
..................
4-15
Cleaning
Exterior of your vehicle
...................
10-3
Interior of your vehicle
....................
10-2
Clutch
Fluid
............................................
12-10
Coat hook
...........................................
8-72
Combination headlamps and dipper switch
...
6-40Compliance label
................................
12-3
Coolant (engine)
......................
11-6
, 12-10
Coolant (plug-in hybrid EV system)
.....
11-6
Corner sensor
.....................................
7-63
Cruise control
.....................................
7-35
Cup holder
.........................................
8-70
BK0203201EN.book 1 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分